含磷阻燃剂阻燃环氧树脂热降解动力学

田秀娟; 王忠卫; 于青; 高军

doi:10.3969/j.issn.0438-1157.2014.12.059

您当前的位置：

首页 >

文章列表页 >

含磷阻燃剂阻燃环氧树脂热降解动力学

材料化学工程与纳米技术 | 更新时间：2025-12-10

- 含磷阻燃剂阻燃环氧树脂热降解动力学
- Kinetics of thermal decomposition of epoxy resins modified with phosphorus-containing flame retardant
- 化工学报 2014年第12期页码：5082-5089
- 作者机构：
  
  1. 山东科技大学材料科学与工程学院,山东,青岛,266590
  2. 山东科技大学化学与环境工程学院,山东,青岛,266590
- 作者简介：
- 基金信息：
- DOI：10.3969/j.issn.0438-1157.2014.12.059
  中图分类号： 631
- 网络首发：2014-12-05，
  
  纸质出版：2014-12-05
- 稿件说明：
移动端阅览
田秀娟, 王忠卫, 于青, 等. 含磷阻燃剂阻燃环氧树脂热降解动力学[J]. 化工学报, 2014,(12):5082-5089.

TIAN Xiujuan, WANG Zhongwei, YU Qing, et al. Kinetics of thermal decomposition of epoxy resins modified with phosphorus-containing flame retardant[J]. CIESC Journal, 2014, (12): 5082-5089.
田秀娟, 王忠卫, 于青, 等. 含磷阻燃剂阻燃环氧树脂热降解动力学[J]. 化工学报, 2014,(12):5082-5089. DOI： 10.3969/j.issn.0438-1157.2014.12.059.

TIAN Xiujuan, WANG Zhongwei, YU Qing, et al. Kinetics of thermal decomposition of epoxy resins modified with phosphorus-containing flame retardant[J]. CIESC Journal, 2014, (12): 5082-5089. DOI： 10.3969/j.issn.0438-1157.2014.12.059.

摘要

以2-二苯基膦酰基-1

4-苯二酚(DPO-HQ)为阻燃剂制备了阻燃环氧树脂

利用动态热重分析法(TGA)研究了纯环氧树脂(EP)和阻燃环氧树脂(FR-EP)在不同升温速率下的热稳定性

建立了EP和FR-EP体系的动力学模型和非模型动力学(MFK)

并对比分析了模型动力学和非模型动力学对于描述EP体系和FR-EP体系的适用性.结果表明:阻燃剂的引入降低了环氧树脂初始降解温度

但增加了残炭率.由Flynn-Wall-Ozawa方法和Coats-Redfern方法建立的模型动力学表征EP和FR-EP体系高温降解过程中误差较大

而非模型动力学能更准确地预测和描述EP和FR-EP体系的高温降解行为.

Abstract

Phosphorus-containing epoxy resin was prepared from 2-diphenylphosphonothioic-1

4-diphenol (DPO-HQ

as flame retardant). The thermal stabilities of neat epoxy resin (EP) and flame retardant modified epoxy resin (FR-EP) were studied with thermogravimetric analysis (TGA) at different heating rates. Kinetics model and model-free kinetics (MFK) were established based on TGA data. The serviceability values of model kinetics and model-free kinetics to epoxy resin and flame retardant modified epoxy resin were compared and analyzed. The initial degradation temperature of flame retardant modified epoxy resin slightly decreased with introduction of flame retardant

but the yield of char residue increased. The model kinetics of EP and FR-EP determined by using the Flynn-Wall-Ozawa method and the Coats-Redfern method were not applicable to epoxy resin system. MFK was more suitable to describe and predict the degradation behavior of epoxy resin and flame retardant modified epoxy resin.

关键词

Keywords

references

浏览量

581

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

基于环三磷腈/磷酸酯反应型磷-氮阻燃剂的合成、热降解及应用

适配环保制冷剂R290的阻燃剂性能研究

基于机器学习的改型歧管式微通道热沉流动传热特性多目标优化

磷酸钒锂正极材料的氮掺杂碳包覆与Ti4+共掺杂协同改性研究

一种顺序式模拟移动床混合建模与优化策略