鼓泡流化床垃圾衍生燃料富氧气化

牛淼淼; 黄亚继; 金保昇; 王妍艳; 董新新

doi:10.3969/j.issn.0438-1157.2014.12.044

您当前的位置：

首页 >

文章列表页 >

鼓泡流化床垃圾衍生燃料富氧气化

能源和环境工程 | 更新时间：2025-12-10

- 鼓泡流化床垃圾衍生燃料富氧气化
- Enriched-air gasification of refuse derived fuel in bubbling fluidized bed
- 化工学报 2014年第12期页码：4971-4977
- 作者机构：
  
  东南大学能源热转换及其过程测控教育部重点实验室,江苏,南京,210096
- 作者简介：
- 基金信息：
- DOI：10.3969/j.issn.0438-1157.2014.12.044
  中图分类号： 705
- 网络首发：2014-12-05，
  
  纸质出版：2014-12-05
- 稿件说明：
移动端阅览
牛淼淼, 黄亚继, 金保昇, 等. 鼓泡流化床垃圾衍生燃料富氧气化[J]. 化工学报, 2014,(12):4971-4977.

NIU Miaomiao, HUANG Yaji, JIN Baosheng, et al. Enriched-air gasification of refuse derived fuel in bubbling fluidized bed[J]. CIESC Journal, 2014, (12): 4971-4977.
牛淼淼, 黄亚继, 金保昇, 等. 鼓泡流化床垃圾衍生燃料富氧气化[J]. 化工学报, 2014,(12):4971-4977. DOI： 10.3969/j.issn.0438-1157.2014.12.044.

NIU Miaomiao, HUANG Yaji, JIN Baosheng, et al. Enriched-air gasification of refuse derived fuel in bubbling fluidized bed[J]. CIESC Journal, 2014, (12): 4971-4977. DOI： 10.3969/j.issn.0438-1157.2014.12.044.

摘要

在鼓泡流化床上进行两种垃圾衍生燃料(RDF)的富氧气化试验

考察了RDF的热重特性并分析了气化温度、当量比及富氧浓度对气化特性的影响.结果表明:两种RDF均由纤维素及塑料类组分构成.随着温度由650℃升高至800℃

两种RDF产气的H2、CO及CH4浓度均逐渐增加

产气热值和气化效率同时提高.当量比增大时可燃组分浓度先略有增大后逐渐减小

但气体产率不断增大.RDF1及RDF2分别在当量比为0.22及0.27处达到最佳气化效率.富氧气化可有效改善气化品质

提升合成气热值

富氧浓度为45%时RDF1及RDF2合成气热值均达到最大

分别为8.6 MJ·m-3及9.2 MJ·m-3.

Abstract

Enriched air gasification of two different refuse derived fuels (RDF) was performed in a bubbling fluidized bed reactor. Thermo-gravimetric analysis of the two RDFs was performed and the effect of temperature

equivalence ratio (ER) and oxygen percentage of enriched air was investigated. Both RDFs were composed of cellulose and plastics based materials. With increasing temperature from 650℃ to 800℃

concentrations of H2

CO and CH4 increased in both RDFs gasification. Gas yield and gasification efficiency were also improved. The combustible components first increased slightly and then decreased with increasing ER

while gas yield kept constant growth. The optimum ER values for RDF1 and RDF2 were 0.22 and 0.27 respectively for obtaining the highest gasification efficiency. The use of enriched air could improve gasification effectively and lead to higher heating value of the syngas. When oxygen percentage of enriched air was 45%

the maximum low heating values of the syngas for RDF1 and RDF2 were 8.6 MJ·m-3 and 9.2 MJ·m-3 respectively.

关键词

Keywords

references

浏览量

354

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

熔融盐辅助生物质热化学高值化转化研究进展

基于ReaxFF-MD和DFT的废旧PP塑料水蒸气气化机理研究

水蒸气/氧流化床两段煤气化制备低焦油合成气工艺实验

改性BaFe2O4载氧体生物质化学链气化特性

基于CPFD方法的流化床生物质气化数值模拟