垂直水冷壁异形鳍片区域温度与热应力分布

徐青蓝; 周克毅; 肖杰; 杨浩蓝; 张凌翔

doi:10.11949/j.issn.0438-1157.20190471

您当前的位置：

首页 >

文章列表页 >

垂直水冷壁异形鳍片区域温度与热应力分布

流体力学与传递现象 | 更新时间：2026-07-24

- 垂直水冷壁异形鳍片区域温度与热应力分布
- Distribution of temperature and thermal stress in vertical water wall special-shape fin region
- 化工学报 2019年70卷第12期页码：4582-4589
- 作者机构：
  
  1. 东南大学能源热转换及其过程测控教育部重点实验室，江苏南京 210096
  2. 江苏方天电力技术有限公司，江苏南京 211102
- 作者简介：
  
  徐青蓝（1995—），女，硕士研究生，220170437@seu.edu.cn
  周克毅（1955—），男，博士，教授，boiler@seu.edu.cn
- 基金信息：
  
  国家自然科学基金项目(51676035)
- DOI：10.11949/j.issn.0438-1157.20190471
  中图分类号： TK 223.3
- 收稿：2019-05-06，
  
  修回：2019-09-17，
  
  网络首发：2020-06-09，
  
  纸质出版：2019-12-05
- 稿件说明：
移动端阅览
徐青蓝, 周克毅, 肖杰, 杨浩蓝, 张凌翔. 垂直水冷壁异形鳍片区域温度与热应力分布[J]. 化工学报, 2019, 70(12): 4582-4589

XU Qinglan, ZHOU Keyi, XIAO Jie, YANG Haolan, ZHANG Lingxiang. Distribution of temperature and thermal stress in vertical water wall special-shape fin region[J]. CIESC Journal, 2019, 70(12): 4582-4589
徐青蓝, 周克毅, 肖杰, 杨浩蓝, 张凌翔. 垂直水冷壁异形鳍片区域温度与热应力分布[J]. 化工学报, 2019, 70(12): 4582-4589 DOI： 10.11949/j.issn.0438-1157.20190471.

XU Qinglan, ZHOU Keyi, XIAO Jie, YANG Haolan, ZHANG Lingxiang. Distribution of temperature and thermal stress in vertical water wall special-shape fin region[J]. CIESC Journal, 2019, 70(12): 4582-4589 DOI： 10.11949/j.issn.0438-1157.20190471.

摘要

超/超超临界锅炉垂直水冷壁中间集箱附近的水冷壁异形鳍片区域向火侧易出现横向裂纹，可能导致水冷壁泄漏或爆管。以某660 MW超超临界锅炉为对象，介绍了水冷壁异形鳍片区域温度和热应力的数值计算模型。针对横向裂纹问题，基于计算数据分析了该区域的温度和热应力分布特征，以及锅炉负荷变化和水冷壁尺寸的影响。结果表明，异形鳍片旁的管壁向火侧顶点的轴向拉应力和等效应力大，锅炉变负荷运行易产生交变热应力，导致横向裂纹；异形鳍片中心为整个模型温度最高处，轴向应力和等效应力值也较大，需要重点关注；异形鳍片与管壁交接处等效应力大，材料失效时容易产生裂纹，可能向旁边的异形鳍片区域管壁向火侧延伸。

Abstract

Transverse cracks are easily produced in ultra-supercritical boiler vertical water wall special-shaped fin region near intermediate heater. It is the hidden trouble of water wall leakage and explosion. Take special-shape fin region from a 660 MW ultra-supercritical boiler as research object. Temperature fields and thermal stress fields were obtained by numerical model. Based on calculation data

temperature and thermal stress characteristics were analyzed. The influence of varying load operation and water wall geometry size was also considered. The results show that the axial tensile stress and equivalent stress of the tube wall beside the shaped fin to the apex of the fire side are large

and the alternating load of the boiler is prone to alternating thermal stress

resulting in transverse crack. The highest temperature of the whole model is located at water wall special-shape fin center. Axial stress and equivalent stress are also large in this region. It deserves special attention. Equivalent stress is large in connection point of special-shape fin and tube wall

which results in materials failure and cracks. Cracks may extend to fire-side tube of special-shape fin region.

关键词

Keywords

references

Dhua S K . Metallurgical investigation of failed boiler water-wall tubes received from a thermal power station [J ] . Engineering Failure Analysis , 2010 , 7 ( 17 ): 1572 - 1579 .

Liu S W , Wang W Z , Liu C J . Failure analysis of the boiler water-wall tube [J ] . Case Studies in Engineering Failure Analysis , 2017 , 9 : 35 - 39 .

Ahmad J , Purbolaksono J , Beng L C , et al . Failure investigation on rear water wall tube of boiler [J ] . Engineering Failure Analysis , 2009 , 16 ( 7 ): 2325 - 2332 .

石荣雪 , 张适宜 , 张胜寒 . 基于大数据分析的电厂锅炉水冷壁失效研究 [J ] . 化工进展 , 2016 , 35 ( 9 ): 2640 - 2646 .

Shi R X , Zhang S Y , Zhang S H . Failure investigation on boiler water wall tubes in power plant by large data analysis [J ] . Chemical Industry and Engineering Progress , 2016 , 35 ( 9 ): 2640 - 2646 .

马新立 , 徐颂梅 . 低NO x 燃烧器改造后水冷壁横向裂纹原因及治理 [J ] . 江苏电机工程 , 2015 , 34 ( 2 ): 72 - 74 .

Ma X L , Xu S M . Reasons and treatment of transverse crack in water wall after low NO x burner transformation [J ] . Jiangsu Electrical Engineering , 2015 , 34 ( 2 ): 72 - 74 .

殷尊 , 蔡晖 , 侯召堂 , 等 . 国产1000 MW超超临界机组水冷壁管典型横向裂纹分析 [J ] . 材料科学与工程学报 , 2015 , 33 ( 3 ): 442 - 447 .

Yin Z , Cai H , Hou Z T , et al . Study on typical transverse crack of water wall tube of 1000 MW domestic ultra-supercritical units [J ] . Journal of Materials Science & Engineering , 2015 , 33 ( 3 ): 442 - 447 .

严方 . 火电机组水冷壁管横向裂纹失效机理分析与热应力数值模拟 [J ] . 热加工工艺 , 2013 , 42 ( 10 ): 83 - 86 .

Yan F . Crack failure mechanism analysis of thermal power units of water wall tube transverse and numerical simulation of thermal stress [J ] . Hot Working Technology , 2013 , 42 ( 10 ): 83 - 86 .

Prabu S S , Choudhary A , Mittal N , et al . Failure evaluation of SA 210C riffle water wall tubes in 70 MW CFBC boiler [J ] . Engineering Failure Analysis , 2019 , 95 : 239 - 247 .

Wang S Y , Yang D , Liu D , et al . Experimental and theoretical analysis on the safety and efficiency of an ultra-supercritical pulverized coal-fired boiler with low mass flux vertical water wall [J ] . Applied Thermal Engineering , 2019 , 146 : 440 - 449 .

何洪浩 , 李文军 , 曾俊 , 等 . 超超临界直流锅炉垂直管屏水冷壁壁温分布特性 [J ] . 动力工程学报 , 2017 , 37 ( 4 ): 257 - 260+292 .

He H H , Li W J , Zeng J , et al . Temperature distribution of vertical tube water wall in an ultra-supercritical once-through boiler [J ] . Journal of Chinese Society of Power Engineering , 2017 , 37 ( 4 ): 257 - 260+292 .

徐力刚 , 黄亚继 , 王健 , 等 . 还原性气氛下水冷壁材料15CrMoG的高温腐蚀特性 [J ] . 浙江大学学报(工学版) , 2018 , 52 ( 8 ): 1535 - 1541 .

Xu L G , Huang Y J , Wang J , et al . High-temperature corrosion properties of water wall material 15CrMoG under reducing atmosphere [J ] . Journal of Zhejiang University (Engineering Science) , 2018 , 52 ( 8 ): 1535 - 1541 .

邹磊 , 岳峻峰 , 张恩先 , 等 . 超超临界锅炉水冷壁管材高温腐蚀特性研究 [J ] . 中国电机工程学报 , 2018 , 38 ( 21 ): 6353 - 6359+6497 .

Zou L , Yue J F , Zhang E X , et al . Study on characteristics of high temperature corrosion for water wall tube material in ultra supercritical boiler [J ] . Proceedings of the CSEE , 2018 , 38 ( 21 ): 6353 - 6359+6497 .

Badur J , Ziółkowski P , Sławiński D , et al . An approach for estimation of water wall degradation within pulverized-coal boilers [J ] . Energy , 2015 , 92 : 142 - 152 .

Fu J , Wei L , Li N , et al . Experimental study on temperature, heat flux, strain and stress distribution of boiler water walls [J ] . Applied Thermal Engineering , 2017 , 113 : 419 - 425 .

王学 , 朱迪 , 胡磊 , 等 . 1000 MW塔式炉水冷壁T23钢接头短期失效分析 [J ] . 中国电机工程学报 , 2015 , 35 ( S1 ): 154 - 161 .

Wang X , Zhu D , Hu L , et al . Analysis on short-term failure of T23 steel welded joints in water wall of USC tower boilers [J ] . Proceedings of the CSEE , 2015 , 35 ( S1 ): 154 - 161 .

刘旭东 , 盛伟 , 关多娇 , 等 . 600 MW超临界锅炉膜式水冷壁的热应力分析 [J ] . 锅炉技术 , 2010 , 41 ( 6 ): 11 - 14+23 .

Liu X D , Sheng W , Guan D J , et al . An analysis of the thermal stress of membrane water wall of 600 MW supercritical boiler [J ] . Boiler Technology , 2010 , 41 ( 6 ): 11 - 14+23 .

刘旭东 , 盛伟 , 张劲松 . 600 MW超临界锅炉炉膛膜式水冷壁的热行为研究 [J ] . 动力工程 , 2009 , 29 ( 12 ): 1083 - 1087 .

Liu X D , Sheng W , Zhang J S . Thermal behavior of membrane waterwall of 600 MW supercritical pressure boiler furnace [J ] . Journal of Power Engineering , 2009 , 29 ( 12 ): 1083 - 1087 .

李斌 , 汪华剑 , 梁学东 , 等 . 超超临界锅炉水冷壁管传热恶化对横向裂纹影响的有限元分析 [J ] . 中国电力 , 2015 , 48 ( 12 ): 64 - 69 .

Li B , Wang H J , Liang X D , et al . Finite element analysis for the influence of heat transfer deterioration to transverse cracks in ultra-supercritical boiler water wall [J ] . Electric Power , 2015 , 48 ( 12 ): 64 - 69 .

范旭宸 , 陈晔 , 郑雄 , 等 . 600 MW超临界循环流化床锅炉水冷壁热应力分析 [J ] . 动力工程学报 , 2018 , 38 ( 4 ): 253 - 257 .

Fan X C , Chen Y , Zheng X , et al . Thermal stress analysis of water wall in a 600 MW supercritical CFB boiler [J ] . Journal of Chinese Society of Power Engineering , 2018 , 38 ( 4 ): 253 - 257 .

李舟航 , 唐国力 , 吴玉新 , 等 . 管内周向不均匀流动对超临界锅炉膜式水冷壁温度分布的影响及简化计算 [J ] . 中国电机工程学报 , 2015 , 35 ( 5 ): 1153 - 1160 .

Li Z H , Tang G L , Wu Y X , et al . Effect of circumferential flow non-uniformity on the temperature distribution of membrane water wall in supercritical boilers and simplified calculation methods [J ] . Proceedings of the CSEE , 2015 , 35 ( 5 ): 1153 - 1160 .

葛学利 , 张忠孝 , 范浩杰 , 等 . 热偏差和流量偏差对1000 MW超超临界锅炉水冷壁壁温影响的研究 [J ] . 中国电机工程学报 , 2018 , 38 ( 8 ): 2348 - 2357+2544 .

Ge X L , Zhang Z X , Fan H J , et al . Study on the effect of flame offset and flow deviation on wall water tube temperature of 1000 MW ultra-supercritical boiler [J ] . Proceedings of the CSEE , 2018 , 38 ( 8 ): 2348 - 2357 .

张志正 , 孙保民 , 徐鸿 , 等 . 沁北发电厂超临界压力电站锅炉水冷壁截面温度场分析 [J ] . 中国电机工程学报 , 2006 , 26 ( 7 ): 25 - 28 .

Zhang Z Z , Sun B M , Xu H , et al . Analysis of the water wall temperature field of 600 MW supercritical boiler of Qinbei power plant [J ] . Proceedings of the CSEE , 2006 , 26 ( 7 ): 25 - 28 .

王为术 , 徐维晖 , 顾红芳 , 等 . 超超临界锅炉垂直水冷壁温度场的数值计算 [J ] . 动力工程 , 2009 , 29 ( 8 ): 707 - 712+721 .

Wang W S , Xu W H , Gu H F , et al . Numerical calculation on temperature fields of vertical waterwall in ultra-supercritical boilers [J ] . Journal of Power Engineering , 2009 , 29 ( 8 ): 707 - 712+721 .

周俊虎 , 杨卫娟 , 刘建忠 , 等 . 锅炉变负荷引起的水冷壁渣层热应力 [J ] . 化工学报 , 2003 , 54 ( 12 ): 1678 - 1682 .

Zhou J H , Yang W J , Liu J Z , et al . Thermal stress of slag on wall tube created by boiler load shift [J ] . Journal of Chemical Industry and Engineering(China) , 2003 , 54 ( 12 ): 1678 - 1682 .

林伟宁 , 梁钦锋 , 刘海峰 , 等 . 水冷壁气化炉变工况温度及热应力分析 [J ] . 化工学报 , 2009 , 60 ( 10 ): 2568 - 2575 .

Lin W N , Liang Q F , Liu H F , et al . Temperature and thermal stress analysis in membrane wall gasifier under varied work conditions [J ] . CIESC Journal , 2009 , 60 ( 10 ): 2568 - 2575 .

林伟宁 , 梁钦锋 , 徐赢 , 等 . 水冷壁气化炉紧急停车渣层热应力分析 [J ] . 化工学报 , 2008 , 59 ( 3 ): 713 - 720 .

Lin W N , Liang Q F , Xu Y , et al . Analysis of thermal stress of slag layer for emergency shutdown in water wall gasifier [J ] . Journal of Chemical Industry and Engineering(China) , 2008 , 59 ( 3 ): 713 - 720 .

刘瑞堂 , 侯彦芬 , 王忠华 , 等 . 电厂用锅炉水冷壁辐射过热器管弯头开裂原因分析 [J ] . 哈尔滨工程大学学报 , 2005 , 26 ( 1 ): 105 - 109 .

Liu R T , Hou Y F , Wang Z H , et al . Analysis of failure in elbow of radiation superheater of 500 MW boiler in a power plant [J ] . Journal of Harbin Engineering University , 2005 , 26 ( 1 ): 105 - 109 .

杨阳 , 许彤 . 640 MW超临界锅炉中间集箱水冷壁鳍片结构改进与探讨 [C ] // 2017年江西省电机工程学会年会 . 南昌 : 江西省电机工程学会 , 2018 : 149 - 151

Yang Y , Xu T . Improvement and investigation of the structure of water wall fin near intermediate header in a 640 MW supercritical boiler [C ] // 2017 Jiangxi Society for Electrical Engineering Annual Conference . Nanchang : Jiangxi Society for Electrical Engineering , 2018 : 149 - 151

Hirsch C . Numerical Computation of Internal and External Flows: The Fundamentals of Computational Fluid Dynamics [M ] . Dutch : Elsevier , 2007 .

沈倩 . 超超临界锅炉垂直管圈水冷壁水动力特性对金属壁温的影响 [D ] . 南京 : 东南大学 , 2018 .

Shen Q . Effect on metal wall temperature by hydrodynamic characteristics of vertical water-wall in ultra-supercritical pressure boiler [D ] . Nanjing : Southeast University , 2018 .

黄庆康 , 姜求志 , 王金瑞 , 等 . 火力发电厂金属材料手册 [M ] . 北京 : 中国电力出版社 , 2001 .

Huang Q K , Jiang Q Z , Wang J R , et al . Handbook of Metal Materials for Thermal Power Plants [M ] . Beijing : China Electric Power Press , 2001 .

周一工 . 膜式水冷壁表面热流密度分布的精确解 [J ] . 锅炉技术 , 1991 , ( 1 ): 1 - 6 .

Zhou Y G . Exact solution of flux on membrane water-wall [J ] . Boiler Technology , 1991 , ( 1 ): 1 - 6 .

Sadd M H . Elasticity: Theory, Applications, and Numerics [M ] . New York : Academic Press , 2009 .

中华人民共和国国家质量监督检验检疫总局 , 中国国家标准化管理委员会 . 高压锅炉用无缝钢管: GB/T 5310—2017 [S ] . 北京 : 中国标准出版社 , 2017 .

General Administration of Quality Supervision , Inspection and Quarantine of the People s Republic of China , Standardization Administration of the People s Republic of China . Seamless steel tubes and pipes for high pressure boiler: GB/T 5310—2017 [S ] . Beijing : Standards Press of China , 2017 .

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

泥水盾构仓体内射流对泥浆输送特性影响研究

海水激活电池电解液流动特性分析

氯化钛白氧化反应器结疤问题分析及数值模拟

卧式单轴捏合反应器流动与混合特性的数值模拟

颗粒黏度模型对采用欧拉多相流模型模拟超密相颗粒流动行为的影响