节流参数对液氮贮箱热力排气系统运行特性的影响

汪彬; 李江道; 黄永华; 吴静怡; 王天祥; 雷刚

doi:10.11949/j.issn.0438-1157.20181509

您当前的位置：

首页 >

文章列表页 >

节流参数对液氮贮箱热力排气系统运行特性的影响

流体力学与传递现象 | 更新时间：2020-06-24

- 节流参数对液氮贮箱热力排气系统运行特性的影响
- Effect of throttle parameters on operating performance of thermodynamic vent system in liquid nitrogen tank
- 化工学报 2019年70卷第S2期页码：101-107
- 作者机构：
  
  1.上海宇航系统工程研究所，上海 201109
  2.上海交通大学制冷与低温工程研究所，上海 200240
  3.航天低温推进剂技术国家重点实验室，北京 100028
- 作者简介：
  
  汪彬（1990—），男，博士，工程师，wangbin_cryo@163.com
- 基金信息：
- DOI：10.11949/j.issn.0438-1157.20181509
  中图分类号： V 511.6
- 收稿：2018-12-24，
  
  修回：2019-05-18，
  
  纸质出版：2019-09-05
- 稿件说明：
移动端阅览
汪彬, 李江道, 黄永华, 吴静怡, 王天祥, 雷刚. 节流参数对液氮贮箱热力排气系统运行特性的影响[J]. 化工学报, 2019, 70(S2): 101-107

WANG Bin, LI Jiangdao, HUANG Yonghua, WU Jingyi, WANG Tianxiang, LEI Gang. Effect of throttle parameters on operating performance of thermodynamic vent system in liquid nitrogen tank[J]. CIESC Journal, 2019, 70(S2): 101-107
汪彬, 李江道, 黄永华, 吴静怡, 王天祥, 雷刚. 节流参数对液氮贮箱热力排气系统运行特性的影响[J]. 化工学报, 2019, 70(S2): 101-107 DOI： 10.11949/j.issn.0438-1157.20181509.

WANG Bin, LI Jiangdao, HUANG Yonghua, WU Jingyi, WANG Tianxiang, LEI Gang. Effect of throttle parameters on operating performance of thermodynamic vent system in liquid nitrogen tank[J]. CIESC Journal, 2019, 70(S2): 101-107 DOI： 10.11949/j.issn.0438-1157.20181509.

摘要

为了研究低温推进剂贮箱的控压特性和热力排气系统的运行特性，搭建了一套以液氮为贮存工质的低温流体高效贮存平台，用于模拟液氧贮箱在热力排气系统运行下的压力变化规律。采用单一变量控制法，进行了不同节流比和节流形式下的液氮贮箱热力排气系统控压的实验研究。分析了不同节流参数下液氮贮箱的压力、温度变化特性和排气质量损失。研究发现，当节流比从2%增大到16%时，系统运行占空比从3.42减小到了2.31，但流体损失量也从0.5%增加到了3.3%。以减少系统工作时间和流体质量损失为原则，得到了液相节流条件下热力排气系统的最优节流比为8%。节流开度同样对热力排气系统的制冷量影响明显，小开度带来的大压差有利于提高系统制冷量。

Abstract

In order to investigate the pressure control behavior of cryogenic propellant tank and operating performance of thermodynamic vent system (TVS)

a set of high-efficiency cryogenic fluid storage platform with liquid nitrogen as storage medium was set up

to simulate the pressure variations of liquid oxygen tank under the operation of TVS. The single variable control method was used to carry out the experimental research

which concentrate on the pressure control of TVS in a liquid nitrogen (LN

) tank with different throttle rates and modes. The pressure

temperature variations and vent mass loss of LN

tank under different throttling parameters were analyzed. It was found that the duty rate of TVS decreases significantly with the increase of throttle rate

and the cooling capacity of the system is increased

which greatly reduces the TVS operating time. Based on the principle of reducing the working time and fluid mass loss

the optimal throttling ratio of TVS is obtained. On the other hand

the throttle opening has a remarkable influence on the cooling power of TVS

the large pressure difference helps to improve the cooling power.

关键词

Keywords

references

Lewandowski C . NASA’s exploration systems architecture study [R]. NASA-TM-214062 , 2005 .

Starke J . Human mission to moon final architecture review [R]. AIAA2005-6738 , 2005 .

果琳丽 , 王平 , 梁鲁 , 等 . 载人月面着陆及起飞技术初步研究 [J]. 航天返回与遥感 , 2013 , 34 ( 4 ): 10 - 16 .

Guo L L , Wang P , Liang L , et al . Preliminary research on manned lunar landing and lifting off technology [J]. Spacecraft Recovery & Remote Sensing , 2013 , 34 ( 4 ): 10 - 16 .

Flachbart R , Hastings L , Martin J . Testing of a spray bar zero gravity cryogenic vent system for upper stages [C]// The 35th Joint Propulsion Conference and Exhibit . Los Angeles, CA , 1999 .

Flachbart R , Hastings L , Hedayat A . Spray bar zero-gravity vent system for on-orbit liquid hydrogen storage [R]. NASA/TM-2003-212926 , 2003 .

Hedayat A , Bailey J , Hastings L . Test data analysis of a spray bar zero-g liquid hydrogen vent system for upper stages [C]// The 35th Joint Propulsion Conference and Exhibit . Los Angeles, CA , 1999 .

Flachbart R , Hastings L , Hedayat A , et al . Testing the effects of helium pressurant on thermodynamic vent system performance with liquid hydrogen [J]. Advances in Cryogenic Engineering , 2008 , 985 ( 1 ): 1483 - 1490 .

Hastings L , Bolshinskiy L , Hedayat A , et al . Liquid methane testing with a large-scale spray bar thermodynamic vent system [R]. NASA/TP-2014-218197 , 2014 .

Flachbart R , Hastings L , Hedayat A , et al . Thermodynamic vent system performance testing with subcooled liquid methane and gaseous helium pressurant [J]. Cryogenics , 2008 , 48 ( 5/6 ): 217 - 222 .

Flachbart R , Hastings L , Hedayat A , et al . Testing of a spray-bar thermodynamic vent system in liquid nitrogen [C]// AIP Conference Proceedings . AIP , 2006 , 823 : 240 - 247 .

Hedayat A , Nelson S , Hastings L , et al . Liquid nitrogen (oxygen simulant) thermodynamic vent system test data analysis [C]// AIP Conference Proceedings . AIP , 2006 , 823 : 232 - 239 .

VanOverbeke T . Thermodynamic vent system test in a low earth orbit simulation [C]// The 40th AIAA/SAE /ASME /ASEE Joint Propulsion Conference and Exhibit . Fort Lauderdale, Florida , 2004 : 11 - 14 .

Van D . Low-gravity pressure volume temperature gauging concept demonstrated with liquid oxygen [J]. Power and Propulsion , 2007 : 31 - 32 .

Thibault J , Corre C , Demeure L , et al . Thermodynamic control systems for cryogenic propellant storage during long missions [C]// The ASME 2014 4th Joint US-European Fluids Engineering Division Summer Meeting . Chicago, Illinois, USA , 2014 .

Mer S , Thibault J , Corre C . Active insulation technique applied to the experimental analysis of a thermodynamic control system for cryogenic propellant storage [J]. Journal of Thermal Science and Engineering Applications , 2016 , 8 ( 2 ): 021024 .

Liu Z , Li Y , Zhou K . Thermal analysis of double-pipe heat exchanger in thermodynamic vent system [J]. Energy Conversion and Management, 2016 , 126 : 837 – 849 .

陈忠灿 , 李鹏 , 黄永华 , 等 . 工作于室温温区的热力学排气系统装置及初步测试 [J]. 上海交通大学学报 , 2017 , 51 ( 7 ): 8 - 15 .

Chen Z C , Li P , Huang Y H , et al . Simulation of a thermodynamic vent system working at room temperature and its preliminary pressurization testing [J]. Journal of Shanghai Jiaotong University , 2017 , 51 ( 7 ): 8 - 15 .

Wang B , Huang Y , Wu J , et al . Performance of thermodynamic vent system for cryogenic propellant storage using different control strategies [J]. Applied Thermal Engineering , 2017 , 126 : 100 - 107 .

Wang B , Huang Y , Wu J , et al . Experimental study on pressure control of liquid nitrogen tank by thermodynamic vent system [J]. Applied Thermal Engineering , 2017 , 125 : 1037 - 1046 .

Liu Z , Xia S , Li Y , et al . Ground experimental investigation of thermodynamic vent system with HCFC123 [J]. International Journal of Thermal Sciences , 2017 , 122 : 218 - 230 .

Liu Z , Li Y , Zhang S , et al . Experimental study on thermodynamic vent system with different influence factors [J]. International Journal of Energy Research , 2017 , 3 : 1 - 16 .

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

节流作用下CO2管道放空过程的冻堵风险实验研究

变温吸附碳捕集系统能效性能实验研究

控制策略对贮箱热力排气系统性能的影响

液氢贮箱热力学排气系统建模及控压特性

水下管道向下泄漏的羽/射流特性