高温烟气中吸附剂捕集K的模型及其反应动力学研究

郑传杰; 盛昌栋

doi:10.11949/j.issn.0438-1157.20181497

您当前的位置：

首页 >

文章列表页 >

高温烟气中吸附剂捕集K的模型及其反应动力学研究

能源和环境工程 | 更新时间：2026-07-24

- 高温烟气中吸附剂捕集K的模型及其反应动力学研究
- Modeling and reaction kinetics study on K capture by adsorbents in high temperature flue gas
- 化工学报 2019年70卷第6期页码：2259-2268
- 作者机构：
  
  东南大学能源与环境学院，江苏南京 210096
- 作者简介：
  
  郑传杰（1994—），男，硕士研究生，920343372@qq.com
  盛昌栋（1967—），男，博士，教授，c.d.sheng@seu.edu.cn
- 基金信息：
  
  国家重点研发计划项目(2016YFB0600601)
- DOI：10.11949/j.issn.0438-1157.20181497
  中图分类号： TK 16
- 收稿：2018-12-21，
  
  修回：2019-03-05，
  
  网络首发：2020-06-15，
  
  纸质出版：2019-06-05
- 稿件说明：
移动端阅览
郑传杰, 盛昌栋. 高温烟气中吸附剂捕集K的模型及其反应动力学研究[J]. 化工学报, 2019, 70(6): 2259-2268

ZHENG Chuanjie, SHENG Changdong. Modeling and reaction kinetics study on K capture by adsorbents in high temperature flue gas[J]. CIESC Journal, 2019, 70(6): 2259-2268
郑传杰, 盛昌栋. 高温烟气中吸附剂捕集K的模型及其反应动力学研究[J]. 化工学报, 2019, 70(6): 2259-2268 DOI： 10.11949/j.issn.0438-1157.20181497.

ZHENG Chuanjie, SHENG Changdong. Modeling and reaction kinetics study on K capture by adsorbents in high temperature flue gas[J]. CIESC Journal, 2019, 70(6): 2259-2268 DOI： 10.11949/j.issn.0438-1157.20181497.

摘要

针对生物质燃烧时采用吸附剂控制烟气中含K气体成分行为的性能描述，采用一维柱塞流反应器模型探究高岭土和煤灰捕集KOH（K

）、KCl和K

的性能及影响因素。通过模型计算与文献实验值比较检验模型合理性和确定动力学参数，并比较高岭土和煤灰捕集不同含K成分的性能差异。结果表明，采用表观动力学模型和单一的动力学参数可预测广泛反应条件下高岭土和煤灰捕集K的量，所确定的动力学参数是合理的；在给定的K浓度和烟气温度范围内，单位质量高岭土和煤灰捕集K的规律相似，均随烟气温度的升高而增大，随K浓度的增大而增大，且高岭土捕集能力受K浓度影响更明显；高岭土和煤灰捕集K的能力均为KOH强于KCl，强于K

，且高岭土捕集能力明显强于煤灰。

Abstract

Aiming at the performance description of using adsorbent to control the behavior of K-containing gas in flue gas during biomass combustion

the performance and influencing factors of kaolin and coal fly ash trapping KOH (K

)

KCl and K

were investigated by one-dimensional plug flow reactor model. After comparing the model calculations with the experimental measurements in the literature to verify the rationality of the model and to determine the kinetic parameters

the differences in the performance of kaolin and coal fly ash adsorbing various K-containing gases were compared. The results showed that employing the global kinetic model and a single set of kinetic parameters was capable of predicting the amount of K captured by kaolin and coal fly ash under a wide range of reaction conditions and the kinetic parameters determined were reasonable. Within the given ranges of K concentration and flue gas temperature

the patterns of K capture by kaolin and coal fly ash were similar

both increasing with the increase of flue gas temperature and K concentration

but the effect of K concentration on kaolin adsorption was more obvious.

The capabilities of K adsorption by both kaolin and coal fly ash were: KOH

KCl

but the adsorption capability of kaolin was much stronger than coal fly ash.

关键词

Keywords

references

斯俊平 . 燃煤过程中钠对焦特性及细颗粒物控制的影响 [D ] . 武汉 : 华中科技大学 , 2014 .

Si J P . Effects of sodium on char characteristics and fine particulate matters control during coal combustion [D ] . Wuhan : Huazhong University of Science and Technology , 2014 .

黄忠友 . 试析生物质发电发展现状及前景 [J ] . 科技风 , 2019 , ( 2 ): 185 .

Huang Z Y . Analysis of current situation and prospect of biomass power generation [J ] . Technology Wind , 2019 , ( 2 ): 185 .

徐林林 . 高岭土对高钠煤燃烧过程中碱金属的脱除效果研究 [D ] . 天津 : 天津大学 , 2015 .

Xu L L . Effect of kaolin on removal of alkali metals during combustion of high sodium coal [D ] . Tianjin : Tianjin University , 2015 .

Mcnallan M J , Yurek G J , Elliott J F . The formation of inorganic particulates by homogeneous nucleation in gases produced by the combustion of coal [J ] . Combustion & Flame , 1981 , 42 ( 81 ): 45 - 60 .

兰泽全 , 曹欣玉 , 周俊虎 , 等 . 锅炉受热面沾污结渣的危害及其防治措施 [J ] . 电站系统工程 , 2003 , 19 ( 1 ): 31 - 33 .

Lan Z Q , Cao X Y , Zhou J H , et al . Hazards and prevention measures of fouling and slagging on heating surfaces of boilers [J ] . Power Plant System Engineering , 2003 , 19 ( 1 ): 31 - 33 .

董雪玲 . 大气可吸入颗粒物对环境和人体健康的危害 [J ] . 资源·产业 , 2004 , ( 5 ): 52 - 55 .

Dong X L . Hazards of inhalable particulates to environment and human health [J ] . Resources·Industry , 2004 , ( 5 ): 52 - 55 .

Zhan Z , Fry A R , Wendt J O L . Relationship between submicron ash aerosol characteristics and ash deposit compositions and formation rates during air- and oxy-coal combustion [J ] . Fuel , 2016 , 181 : 1214 - 1223 .

Waindich A , Müller M . Alkali removal at 1400℃ under gasification conditions [J ] . Fuel , 2014 , 116 : 889 - 893 .

Gibbs A R , Pooley F D . Analysis and interpretation of inorganic mineral particles in "lung" tissues [J ] . Thorax , 1996 , 51 ( 3 ): 327 - 334 .

周科 . 燃煤细微颗粒物生成特性与炉内控制的研究 [D ] . 武汉 : 华中科技大学 , 2011 .

Zhou K . Study on the generation characteristics and control of fine particles in coal combustion [D ] . Wuhan : Huazhong University of Science and Technology , 2011 .

温昶 , 徐明厚 , 于敦喜 , 等 . 煤粉O 2 /CO 2 燃烧时PM 2. 5 及其Fe、S的生成特性 [J ] . 化工学报 , 2011 , 62 ( 4 ): 1062 - 1069 .

Wen C , Xu M H , Yu D X , et al . Formation characteristics of PM 2. 5 including Fe, S during O 2 /CO 2 combustion of pulverized coal [J ] . CIESC Journal , 2011 , 62 ( 4 ): 1062 - 1069 .

Quann R J , Sarofim A F . Vaporization of refractory oxides during pulverized coal combustion [J ] . Symposium on Combustion , 1982 , 19 ( 1 ): 1429 - 1440 .

Si J P , Liu X W , Xu M H , et al . Effect of kaolin additive on PM 2. 5 , reduction during pulverized coal combustion: importance of sodium and its occurrence in coal [J ] . Applied Energy , 2014 , 114 ( 2 ): 434 - 444 .

Yan L , Gupta R P , Wall T F . The implication of mineral coalescence behaviour on ash formation and ash deposition during pulverised coal combustion [J ] . Fuel , 2001 , 80 ( 9 ): 1333 - 1340 .

徐明厚 , 于敦喜 , 刘小伟 . 燃煤可吸入颗粒物的形成与排放 [M ] . 北京 : 科学出版社 , 2009 .

Xu M H , Yu D X , Liu X W . Formation and Emission of Inhalable Particles from Coal Combustion [M ] . Beijing : Science Press , 2009 .

刘建忠 , 张光学 , 周俊虎 , 等 . 燃煤细灰的形成及微观形态特征 [J ] . 化工学报 , 2006 , 57 ( 12 ): 2976 - 2980 .

Liu J Z , Zhang G X , Zhou J H , et al . Formation and micromorphology characteristics of fine particles generated during coal combustion [J ] . Journal of Chemical Industry and Engineering(China) , 2006 , 57 ( 12 ): 2976 - 2980 .

刘勇 , 赵汶 , 刘瑞 , 等 . 化学团聚促进电除尘脱除PM 2. 5 的实验研究 [J ] . 化工学报 , 2014 , 65 ( 9 ): 3609 - 3616 .

Liu Y , Zhao W , Liu R , et al . Improving removal of PM 2.5 by electrostatic precipitator with chemical agglomeration [J ] . CIESC Journal , 2014 , 65 ( 9 ): 3609 - 3616 .

Quann R J . Ash vaporization under simulated pulverized coal combustion conditions [D ] . Massachusetts : Massachusetts Institute of Technology , 1982 .

Li Y , Raj G A , Wall T . Fragmentation behavior of pyrite and calcite during high-temperature processing and mathematical simulation [J ] . Energy & Fuels , 2001 , 15 ( 2 ): 389 - 394 .

Quann R J , Neville M , Janghorbani M , et al . Mineral matter and trace-element vaporization in a laboratory-pulverized coal combustion system [J ] . Environmental Science & Technology , 1982 , 16 ( 11 ): 776 .

Helble J J . Mechanisms of ash particle formation and growth during pulverized coal combustion [D ] . Massachusetts : MIT Library in America , 1987 .

孙伟 , 刘小伟 , 徐义书 , 等 . 两种改性高岭土减排超细颗粒物的对比分析 [J ] . 化工学报 , 2016 , 67 ( 4 ): 1179 - 1185 .

Xun W , Liu X W , Xu Y S , et al . Contrastive analysis of reducing ultrafine particulate matters emission by two modified kaolin [J ] . CIESC Journal , 2016 , 67 ( 4 ): 1179 - 1185 .

Mwabe P O , Wendt J O L . Mechanisms governing trace sodium capture by kaolinite in a downflow combustor [J ] . Symposium on Combustion , 1996 , 26 ( 2 ): 2447 - 2453 .

Wang G L , Jensen P A , Wu H , et al . Potassium capture by kaolin (1): KOH [J ] . Energy & Fuels , 2018 , 32 ( 2 ): 1851 - 1862 .

Schürmann H , Unterberger S , Hein K R , et al . The influence of fuel additives on the behaviour of gaseous alkali-metal compounds during pulverised coal combustion [J ] . Faraday Discussions , 2001 , 119 ( 119 ): 433 - 444 .

Gale T , Wendt J L . Mechanisms and models describing sodium and lead scavenging by a kaolinite aerosol at high temperatures [J ] . Aerosol Science & Technology , 2003 , 37 ( 11 ): 865 - 876 .

Wang G L , Jensen P A , Wu H , et al . Potassium capture by kaolin (2): K 2 CO 3 , KCl, and K 2 SO 4 [J ] . Energy & Fuels , 2018 , 32 ( 3 ): 3566 - 3578 .

Damoe A J , Wu H , Frandsen F J , et al . Impact of coal fly ash addition on combustion aerosols (PM 2. 5 ) from full-scale suspension-firing of pulverized wood [J ] . Energy & Fuels , 2014 , 28 ( 5 ): 3217 - 3223 .

Scandrett L A , Clift R . The thermodynamics of alkali removal from coal derived gases [J ] . Journal of the Institute of Energy , 1984 , 57 ( 433 ): 391 - 397 .

Li Y , Li J , Jin Y , et al . Study on alkali-metal vapor removal for high-temperature cleaning of coal gas [J ] . Energy & Fuels , 2005 , 19 ( 4 ): 1606 - 1610 .

Wang G L . Potassium capture by kaolin and coal fly ash [D ] . Kongens Lyngby : Technical University of Denmark , 2018 .

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

退役光伏组件TPT背板热氧化降解特性研究

Ⅳ型储氢瓶PA6内胆材料氢渗透性能和老化机制的分子动力学模拟研究

温度敏感聚N-异丙基丙烯酰胺/谷氨酸钠/壳聚糖复合材料制备及吸附性能研究

羰基氧交联法制备沥青基片状碳负极材料及其储钾性能研究

锂硫电池电解液研究进展：分子设计与应用