宽流道反渗透膜元件抗污染性能分析

吴降麟; 张朝晖; 王亮; 赵斌; 李腾飞; 陈萌萌

doi:10.11949/j.issn.0438-1157.20181257

您当前的位置：

首页 >

文章列表页 >

宽流道反渗透膜元件抗污染性能分析

分离工程 | 更新时间：2026-07-24

- 宽流道反渗透膜元件抗污染性能分析
- Analysis of anti-fouling performance of wider spacer RO membrane module
- 化工学报 2019年70卷第4期页码：1446-1454
- 作者机构：
  
  1.天津工业大学环境与化学工程学院，天津 300387
  2.天津工业大学省部共建分离膜与膜过程国家重点实验室，天津 300387
- 作者简介：
  
  吴降麟（1992—），男，硕士研究生，wujianglin999@126.com
  张朝晖（1974—），女，博士，副教授，zzh7448@126.com
- 基金信息：
  
  国家重点研发计划项目(2016YFC0400506);国家自然科学基金面上项目(51678408)
- DOI：10.11949/j.issn.0438-1157.20181257
  中图分类号： TQ 028.8
- 收稿：2018-10-24，
  
  修回：2018-12-18，
  
  网络首发：2020-06-15，
  
  纸质出版：2019-04-12
- 稿件说明：
移动端阅览
吴降麟, 张朝晖, 王亮, 赵斌, 李腾飞, 陈萌萌. 宽流道反渗透膜元件抗污染性能分析[J]. 化工学报, 2019, 70(4): 1446-1454

WU Jianglin, ZHANG Zhaohui, WANG Liang, ZHAO Bin, LI Tengfei, CHEN Mengmeng. Analysis of anti-fouling performance of wider spacer RO membrane module[J]. CIESC Journal, 2019, 70(4): 1446-1454
吴降麟, 张朝晖, 王亮, 赵斌, 李腾飞, 陈萌萌. 宽流道反渗透膜元件抗污染性能分析[J]. 化工学报, 2019, 70(4): 1446-1454 DOI： 10.11949/j.issn.0438-1157.20181257.

WU Jianglin, ZHANG Zhaohui, WANG Liang, ZHAO Bin, LI Tengfei, CHEN Mengmeng. Analysis of anti-fouling performance of wider spacer RO membrane module[J]. CIESC Journal, 2019, 70(4): 1446-1454 DOI： 10.11949/j.issn.0438-1157.20181257.

摘要

以活性蓝MB-R和硫酸钠模拟高盐染色废水，分析了宽流道反渗透膜组件的抗污染性能，对比研究了不同流道宽度和膜内隔网定向角度变化对于膜组件抗污染性能及运行能耗的影响。实验结果表明，适当增加流道宽度可以有效减缓膜通量衰减速率，延长膜运行时间，但流道宽度增加到一定程度后膜组件抗污染性能不再随流道宽度增加而有明显改善。进水隔网定向角度对膜组件抗污染性能影响非常明显。实验结果表明，在流道宽度不变前提下，进水隔网定向角度从40°变成45°时165 min内膜通量衰减速率下降3.9%，一个低压冲洗周期内的膜运行时间延长了35.7%，低压冲洗后膜通量恢复率提高了4.5%。综合trade-off效应和进水压降分析，与普通反渗透组件相比，当宽流道组件的进水流道宽度达到30 mil（1 mil=0.025 mm），隔网定向45°时具有更优越的抗污染性能和更低的运行能耗。

Abstract

The high-salt dyeing wastewater was simulated by reactire blue MB-R and sodium sulfate. The effects of different channel height and spacer orientation on the anti-fouling performance and energy consumption of RO membrane modules were compared. The results showed that the membrane flux decline could be slowed down and the membrane running time could be prolonged by increasing the spacer thickness appropriately. However

the anti-fouling performance of the membrane module could not be improved significantly with the increase of the spacer thickness when the spacer thickness was increased to a certain extent. On the other hand

the influence of spacer orientation on the anti-fouling performance of membrane module was very obvious. The results suggested that when the spacer thickness remained unchanged and the spacer orientation changed from 40° to 45°

the membrane flux decline rate decreased by 3.9% after 165 min of operation

the filtration time of one low pressure flushing cycle was prolonged by 35.7%

and the flux recovery rate was increased by 4.5% after the low pressure flushing. The comprehensive analysis based on the trade-off effects and the feed channel pressure drops indicated that a better anti-fouling performance and lower operation energy consumption can be obtained when the feed channel height was set at 30 mil and the spacer orientation was set at 45°.

关键词

Keywords

references

Joo S H , Tansel B . Novel technologies for reverse osmosis concentrate treatment: a review [J ] . Journal of Environmental Management , 2015 , 150 : 322 - 335 .

Qi S , Wang R , Chaitra G K M , et al . Aquaporin-based biomimetic reverse osmosis membranes: stability and long term performance [J ] . Journal of Membrane Science , 2016 , 508 : 94 - 103 .

Jiang S , Li Y , Ladewig B P . A review of reverse osmosis membrane fouling and control strategies [J ] . Science of the Total Environment , 2017 , 595 : 567 - 583 .

Safarpour M , Khataee A , Vatanpour V . Thin film nanocomposite reverse osmosis membrane modified by reduced graphene oxide/TiO 2 with improved desalination performance [J ] . Journal of Membrane Science , 2015 , 489 ( 5 ): 43 - 54 .

Asadollahi M , Bastani D , Musavi S A . Enhancement of surface properties and performance of reverse osmosis membranes after surface modification: a review [J ] . Desalination , 2017 , 420 : 330 - 383 .

Piyadasa C , Ridgway H F , Yeager T R , et al . The application of electromagnetic fields to the control of the scaling and biofouling of reverse osmosis membranes—a review [J ] . Desalination , 2017 , 418 : 19 - 34 .

Tirado M L M , Bass M , Piatkovsky M , et al . Assessing biofouling resistance of a polyamide reverse osmosis membrane surface-modified with a zwitterionic polymer [J ] . Journal of Membrane Science , 2016 , 520 : 490 - 498 .

祝敏 , 沈广录 , 黄洪伟 , 等 . 宽流道反渗透膜耐污染性分析及其在电厂的应用 [J ] . 工业水处理 , 2017 , 37 ( 3 ): 110 - 112 .

Zhu M , Shen G L , Huang H W , et al . Pollution-resistant analysis of wider spacer RO membrane and its application in power plants [J ] . Industrial Water Treatment , 2017 , 37 ( 3 ): 110 - 112 .

Hui Y , Yang B Q , Yang J M , et al . Bioevaporation treatment of concentrated landfill leachate from two-stage DTRO [J ] . China Environmental Science , 2017 , 37 ( 9 ): 3437 - 3445 .

Kavianipour O , Ingram G D , Vuthaluru H B . Investigation into the effectiveness of feed spacer configurations for reverse osmosis membrane modules using Computational Fluid Dynamics [J ] . Journal of Membrane Science , 2017 , 526 : 156 - 171 .

Gong H , Yan Z , Liang K Q , et al . Concentrating process of liquid digestate by disk tube-reverse osmosis system [J ] . Desalination , 2013 , 326 ( 10 ): 30 - 36 .

Zuo J , Song Y , Wang J . Application of DTRO technology in the treatment of landfill leachate [J ] . Membrane Science & Technology , 2011 , 31 ( 2 ): 110 - 115 .

杨庆峰 . 卷式反渗透膜器浓水侧流道缺陷诊断 [J ] . 化工学报 , 2006 , 57 ( 6 ): 1319 - 1322 .

Yang Q F . Diagnosis of membrane passage defects for reverse osmosis spiral wound membrane module [J ] . Journal of Chemical Industry and Engineering(China) , 2006 , 57 ( 6 ): 1319 - 1322 .

Geise G M , Park H B , Sagle A C , et al . Water permeability and water/salt selectivity tradeoff in polymers for desalination [J ] . Journal of Membrane Science , 2011 , 369 ( 1 ): 130 - 138 .

Yang Z , Zhou Z W , Guo H , et al . Tannic acid/Fe 3+ nanoscaffold for interfacial polymerization: toward enhanced nanofiltration performance [J ] . Environ. Sci. Technol. , 2018 , 52 ( 16 ): 9341 - 9349 .

Tan Z , Chen S , Peng X , et al . Polyamide membranes with nanoscale turing structures for water purification [J ] . Science , 2018 , 360 ( 6388 ): 518 - 521 .

Araújo P A , Kruithof J C , Loosdrecht M C M V , et al . The potential of standard and modified feed spacers for biofouling control [J ] . Journal of Membrane Science , 2012, 403 / 404 ( 404 ): 58 - 70 .

Majamaa K , Aerts P E M , Groot C , et al . Industrial water reuse with integrated membrane system increases the sustainability of the chemical manufacturing [J ] . Desalination & Water Treatment , 2010 , 18 ( 1/2/3 ): 17 - 23 .

Haidari A H , Heijman S G J , van der Meer W G J . Optimal design of spacers in reverse osmosis [J ] . Separation and Purification Technology , 2018 , 192 : 441 - 456 .

Costa A R D , Fane A G , Wiley D E . Spacer characterization and pressure drop modelling in spacer-filled channels for ultrafiltration [J ] . Journal of Membrane Science , 1994 , 87 ( 1/2 ): 79 - 98 .

Darby R , Darby R , Chhabra R P . Chemical Engineering Fluid Mechanics, Revised and Expanded [M ] . New York : Marcel Dekker Inc ., 2001 : 330 - 358 .

Hoek E M V , Kim A S , Elimelech M . Influence of crossflow membrane filter geometry and shear rate on colloidal fouling in reverse osmosis and nanofiltration separations [J ] . Environmental Engineering Science , 2002 , 19 ( 6 ): 357 - 372 .

Costa A R D , Fane A G , Fell C J D , et al . Optimal channel spacer design for ultrafiltration [J ] . Journal of Membrane Science , 1991 , 62 ( 3 ): 275 - 291 .

Fimbres-Weihs G A , Wiley D E . Numerical study of mass transfer in three-dimensional spacer-filled narrow channels with steady flow [J ] . Journal of Membrane Science , 2007 , 306 ( 1 ): 228 - 243 .

Neal P R , Li H , Fane A G , et al . The effect of filament orientation on critical flux and particle deposition in spacer-filled channels [J ] . Journal of Membrane Science , 2003 , 214 ( 2 ): 165 - 178 .

Araújo P A , Miller D J , Correia P B , et al . Impact of feed spacer and membrane modification by hydrophilic, bactericidal and biocidal coating on biofouling control [J ] . Desalination , 2012 , 295 ( 6 ): 1 - 10 .

Chapman R G , Ostuni E , Liang M N , et al . Polymeric thin films that resist the adsorption of proteins and the adhesion of bacteria [J ] . Langmuir , 2001 , 17 ( 4 ): 1225 - 1233 .

Brzozowska A M , Spruijt E , Keizer A D , et al . On the stability of the polymer brushes formed by adsorption of Ionomer Complexes on hydrophilic and hydrophobic surfaces [J ] . Journal of Colloid & Interface Science , 2011 , 353 ( 2 ): 380 - 391 .

Ahmad A L , Lau K K , Bakar M Z A , et al . Integrated CFD simulation of concentration polarization in narrow membrane channel [J ] . Computers & Chemical Engineering , 2005 , 29 ( 10 ): 2087 - 2095 .

Amokrane M , Sadaoui D , Dudeck M , et al . New spacer designs for the performance improvement of the zigzag spacer configuration in spiral-wound membrane modules [J ] . Desalination & Water Treatment , 2016 , 57 ( 12 ): 5266 - 5274 .

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

双面组合槽型干气密封性能分析与结构优化

基于ANN-GA集成的ORC混合工质智能筛选与性能优化

3D打印结合冷冻干燥构建多级结构SiO2掺杂HA生物陶瓷支架

微重力条件下低温贮箱加注-保持-排气式预冷特性研究

功热集成中压力操作路径和换热匹配的同步优化