刚柔组合桨强化粉煤灰酸浸搅拌槽内固液混沌混合

熊黠; 刘作华; 谷德银; 邱发成; 王靓; 陶长元; 王运东

doi:10.11949/j.issn.0438-1157.20181179

您当前的位置：

首页 >

文章列表页 >

刚柔组合桨强化粉煤灰酸浸搅拌槽内固液混沌混合

流体力学与传递现象 | 更新时间：2026-07-24

- 刚柔组合桨强化粉煤灰酸浸搅拌槽内固液混沌混合
- Chaotic mixing process of fly ash in acid leaching tank intensified by rigid-flexible impeller
- 化工学报 2019年70卷第5期页码：1693-1701
- 作者机构：
  
  1.重庆大学化学化工学院，重庆 400044
  2.清华大学化学工程系，北京 100084
- 作者简介：
  
  熊黠（1993—），女，硕士研究生，1457069686@qq.com
  刘作华（1973—），男，博士，教授，liuzuohua@cqu.edu.cn
- 基金信息：
  
  国家重点研发计划项目(2017YFB0603105);国家自然科学基金项目(21636004);重庆市研究生科研创新项目(CYS18031);重庆市社会事业与民生保障科技创新专项项目(cstc2017shmsA90016);国家科技支撑计划项目(2015BAB17B01)
- DOI：10.11949/j.issn.0438-1157.20181179
  中图分类号： TQ 027.2
- 收稿：2018-10-10，
  
  修回：2019-02-19，
  
  网络首发：2026-07-24，
  
  纸质出版：2019-05-05
- 稿件说明：
移动端阅览
熊黠, 刘作华, 谷德银, 邱发成, 王靓, 陶长元, 王运东. 刚柔组合桨强化粉煤灰酸浸搅拌槽内固液混沌混合[J]. 化工学报, 2019, 70(5): 1693-1701

XIONG Xia, LIU Zuohua, GU Deyin, QIU Facheng, WANG Liang, TAO Changyuan, WANG Yundong. Chaotic mixing process of fly ash in acid leaching tank intensified by rigid-flexible impeller[J]. CIESC Journal, 2019, 70(5): 1693-1701
熊黠, 刘作华, 谷德银, 邱发成, 王靓, 陶长元, 王运东. 刚柔组合桨强化粉煤灰酸浸搅拌槽内固液混沌混合[J]. 化工学报, 2019, 70(5): 1693-1701 DOI： 10.11949/j.issn.0438-1157.20181179.

XIONG Xia, LIU Zuohua, GU Deyin, QIU Facheng, WANG Liang, TAO Changyuan, WANG Yundong. Chaotic mixing process of fly ash in acid leaching tank intensified by rigid-flexible impeller[J]. CIESC Journal, 2019, 70(5): 1693-1701 DOI： 10.11949/j.issn.0438-1157.20181179.

摘要

传统粉煤灰提铝工艺中酸浸搅拌槽均采用刚性搅拌桨。因刚性桨卷吸能力有限，导致固体颗粒易沉槽、流体混沌混合效率低。提出刚柔组合桨强化酸浸搅拌槽中固液混沌混合行为。实验基于固含率为30%的粉煤灰-自来水体系，研究了刚柔组合酸浸搅拌槽内混沌混合特性及能量耗散规律。采用扭矩传感器采集扭矩时间序列信号，借助Matlab软件编译计算混合过程中最大Lyapunov指数和多尺度熵等混沌特性参数，以单位体积功耗表征搅拌反应器的功率特性。实验考察了搅拌桨安装离底高度、柔性片长度、柔性片宽度等因素对酸浸槽内粉煤灰混沌混合的影响，对比了刚性桨与刚柔组合桨体系的能耗差异。

研究结果表明：刚柔组合桨通过柔性片的作用，能增大搅拌桨的卷吸力，进而减少固体颗粒沉槽现象，促进全槽混沌混合；在最优化条件（120 r/min，搅拌桨安装离底高度为

/4，柔性片长度为1.2

、柔性片宽度为

/8）下，体系最大Lyapunov指数达到最大值0.0645，各尺度下的MSE均比其他条件更大，表明刚柔组合桨能够通过柔性片的多体运动，强化体系混沌混合，均化体系能量分布；刚性桨与刚柔组合桨的单位体积功耗随着转速的增加呈现指数规律增长。

Abstract

In the traditional fly ash aluminizing process

the acid immersion stirring tank adopts a rigid stirring paddle. Due to the limited pumping capacity of rigid impellers

some problems such as settlement of solid particles

deficiently of chaotic

and low efficiency of mixing in this process often occur in solid-liquid mixing processes. Thus

the rigid-flexible impeller was adopted to enhance solid-liquid chaotic mixing behavior in acid leaching process. In a fly ash-water system with a solids concentration of 30%

the chaotic mixing characteristics and energy dissipation were investigated in STRs equipped with rigid-flexible impeller. Torque sensor was employed to collect the torque time series signal. The largest Lyapunov exponents and the multi-scale entropy were compiled and calculated by Matlab to indicate the degree of chaotic mixing based on the torque time series signal. Meanwhile

the power consumption per unit volume was used to characterize the stirred reactor power characteristics. The effects of impeller types

rotation speed

flexible piece width/length

and impeller off-bottom clearance on chaotic mixing behavior were taken into consideration in the solid-liquid mixing processes. The results showed that the rigid-flexible impeller could effectively promote the chaotic mixing and reduce the accumulation of solid particles at the bottom of STRs in the fly ash-water system. Largest Lyapunov exponents of the system reached the maximum value of 0.0645 and multi-scale entropy was bigger than that of other conditions at the rotation speed of 120 r/min

the off-bottom clearance of

the flexible piece length of 1.2

and width of

/8. The power consumption increases exponentially with the increase of rotation speed.

关键词

Keywords

references

Shemi A , Mpana R N , Ndlovu S , et al . Alternative techniques for extracting alumina from coal fly ash [J ] . Minerals Engineering , 2012 , 34 : 30 - 37 .

Ding J , Ma S , Zheng S , et al . Study of extracting alumina from high-alumina PC fly ash by a hydro-chemical process [J ] . Hydrometallurgy , 2016 , 161 : 58 - 64 .

Cobo M , Gálvez A , Conesa J A , et al . Characterization of fly ash from a hazardous waste incinerator in Medellin, Colombia [J ] . Journal of Hazardous Materials , 2009 , 168 ( 2 ): 1223 - 1232 .

Xu D , Li H , Bao W , et al . A new process of extracting alumina from high-alumina coal fly ash in NH 4 HSO 4 +H 2 SO 4 mixed solution [J ] . Hydrometallurgy , 2016 , 165 : 336 - 344 .

Nayak N , Panda C R . Aluminium extraction and leaching characteristics of Talcher thermal power station fly ash with sulphuric acid [J ] . Fuel , 2010 , 89 ( 1 ): 53 - 58 .

Doucet F J , Mohamed S , Neyt N , et al . Thermochemical processing of a South African ultrafine coal fly ash using ammonium sulphate as extracting agent for aluminium extraction [J ] . Hydrometallurgy , 2016 , 166 : 174 - 184 .

Klenov O P , Noskov A S . Solid dispersion in the slurry reactor with multiple impellers [J ] . Chemical Engineering Journal , 2011 , 176 / 177 : 75 - 82 .

Bulnes Abundis D , Alvarez M M . The simplest stirred tank for laminar mixing: mixing in a vessel agitated by an off‐centered angled disc [J ] . AIChE Journal , 2013 , 59 ( 8 ): 3092 - 3108 .

Nie A , Gao Z , Xue L , et al . Micromixing performance and the modeling of a confined impinging jet reactor/high speed disperser [J ] . Chemical Engineering Science , 2018 , 184 : 14 - 24 .

刘作华 , 唐巧 , 王运东 , 等 . 刚柔组合搅拌桨增强混合澄清槽内流体宏观不稳定性 [J ] . 化工学报 , 2014 . 65 ( 1 ): 78 - 86 .

Liu Z H , Tang Q , Wang Y D , et al . Enhancement of macro-instability in mixer-settler with rigid-flexible impeller [J ] . CIESC Journal , 2014 , 65 ( 1 ): 78 - 86 .

Zhang M , Hu Y , Wang W , et al . Intensification of viscous fluid mixing in eccentric stirred tank systems [J ] . Chemical Engineering and Processing: Process Intensification , 2013 , 66 : 36 - 43 .

Hashimoto S , Osaka R , Kawamata M . Analysis on laminar chaotic mixing based on configuration of streak lobes in an impeller-agitated vessel [J ] . Industrial & Engineering Chemistry Research , 2012 , 51 ( 19 ): 6939 - 6947 .

刘作华 , 孙瑞祥 , 王运东 , 等 . 刚柔组合桨强化流体混沌混合 [J ] . 化工学报 , 2014 , 65 ( 9 ): 3340 - 3349 .

Liu Z H , Sun R X , Wang Y D , et al . Chaotic mixing enhanced by rigid-flexible impeller in stirred vessel [J ] . CIESC Journal , 2014 , 65 ( 1 ): 61 - 70 .

刘作华 , 曾启琴 , 杨鲜艳 , 等 . 刚柔组合搅拌桨与刚性桨调控流场结构的对比 [J ] . 化工学报 , 2014 , 65 ( 6 ): 2078 - 2084 .

Liu Z H , Zeng Q Q , Yang X Y , et al . Flow field structure with rigid-flexible impeller and rigid impeller [J ] . CIESC Journal , 2014 , 65 ( 6 ): 2078 - 2084 .

刘作华 , 杨鲜艳 , 谢昭明 , 等 . 柔性桨与自浮颗粒协同强化高黏度流体混沌混合 [J ] . 化工学报 , 2013 , 64 ( 8 ): 2794 - 2800 .

LIU Z H , YANG X Y , XIE Z M , et al . Chaotic mixing performance of high-viscosity fluid synergistically intensified by flexible impeller and floating particles [J ] . CIESC Journal , 2013 , 64 ( 8 ): 2794 - 2800 .

Gu D , Liu Z , Qiu F , et al . Design of impeller blades for efficient homogeneity of solid-liquid suspension in a stirred tank reactor [J ] . Advanced Powder Technology , 2017 , 28 ( 10 ): 2514 - 2523 .

Gu D , Liu Z , Xie Z , et al . Numerical simulation of solid-liquid suspension in a stirred tank with a dual punched rigid-flexible impeller [J ] . Advanced Powder Technology , 2017 , 28 ( 10 ): 2723 - 2734 .

Gu D , Liu Z , Xu C , et al . Solid-liquid mixing performance in a stirred tank with a double punched rigid-flexible impeller coupled with a chaotic motor [J ] . Chemical Engineering and Processing: Process Intensification , 2017 , 118 : 37 - 46 .

Deng K , Li J , Yu S . Dynamics analysis and synchronization of a new chaotic attractor [J ] . Optik-International Journal for Light and Electron Optics , 2014 , 125 ( 13 ): 3071 - 3075 .

Hu H , Liu D . The judgment of chaotic detection system’s state based on the Lyapunov exponent [J ] . Procedia Engineering , 2012 , 29 : 2894 - 2898 .

Liu Z , Zheng X , Liu D , et al . Enhancement of liquid-liquid mixing in a mixer-settler by a double rigid-flexible combination impeller [J ] . Chemical Engineering and Processing: Process Intensification , 2014 , 86 : 69 - 77 .

刘作华 , 许恢琴 , 谷德银 , 等 . 单层钢丝柔性桨强化搅拌槽中流体混沌混合行为 [J ] . 化工学报 , 2017 , 68 ( 12 ): 4592 - 4599 .

Liu Z H , Xu H Q , Gu D Y , et al . Chaotic mixing performance enhanced by single-wire flexible impeller in stirred vessel [J ] . CIESC Journal , 2017 , 68 ( 12 ): 4592 - 4599 .

Goldberger A L , Peng C K , Costa M . Multiscale entropy analysis of complex physiologic time series [J ] . Physical Review Letters , 2002 , 89 ( 6 ): 68102 .

Dou L , Wan S , Zhan C . Application of Multiscale Entropy in Mechanical Fault Diagnosis of High Voltage Circuit Breaker: Entropy [Z ] . 2018 : 20 .

Goldberger A L , Peng C K , Costa M . Multiscale entropy analysis of biological signals [J ] . Physical Review E , 2005 , 71 ( 2 ): 21906 .

Costa M D , Healey J A . Multiscale entropy analysis of complex heart rate dynamics: discrimination of age and heart failure effects [C ] //Murray A, Computers in Cardiology, 30th Annual Meeting on Computers in Cardiology. Greece: Institute of Electrical and Electronics Engineers Computer Society , 2003 : 705 - 708 .

Brismar T , Nikulin V V . Comment on “Multiscale Entropy Analysis of Complex Physiologic Time Series” [J ] . Physical Review Letters , 2004 , 92 ( 8 ): 89803 .

邱发成 , 刘作华 , 刘仁龙 , 等 . 偏心射流-刚柔组合桨搅拌器内混沌混合行为研究 [J ] . 化工学报 , 2018 , 69 ( 2 ): 618 - 624 .

Qiu F C , Liu Z H , Liu R L , et al . Chaotic mixing performance in a rigid-flexible impeller stirred tank with eccentric air jet [J ] . CIESC Journal , 2018 , 69 ( 2 ): 618 - 624 .

刘作华，许传林，何木川 , 等 . 穿流式刚-柔组合搅拌桨强化混合澄清槽内油-水两相混沌混合 [J ] . 化工学报 , 2017 , 68 ( 2 ): 637 - 642 .

Liu Z H , Xu C L , He M C , et al . Oil-water biphase chaotic mixing enhanced by punched rigid-flexible combination impeller in mixer-settler [J ] . CIESC Journal , 2017 , 68 ( 2 ): 637 - 642 .

刘作华 , 陈超 , 刘仁龙 , 等 . 刚柔组合搅拌桨强化搅拌槽中流体混沌混合 [J ] . 化工学报 , 2014 , 65 ( 1 ): 61 - 70 .

Liu Z H , Chen C , Liu R L , et al . Chaotic mixing enhanced by rigid-flexible impeller in stirred vessel [J ] . CIESC Journal , 2014 , 65 ( 1 ): 61 - 70 .

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

长短叶片复合型刚柔桨强化搅拌槽内流体混沌混合行为

错位刚柔桨强化搅拌槽内流体混合实验及数值模拟

搅拌槽内气液两相混沌混合及分散特性

偏心射流-刚柔组合桨搅拌器内混沌混合行为研究

单层钢丝柔性桨强化搅拌槽中流体混沌混合行为