局部表面改性紫铜方柱阵列池沸腾传热特性和机理

牟帅; 赵长颖; 徐治国

doi:10.11949/j.issn.0438-1157.20181070

您当前的位置：

首页 >

文章列表页 >

局部表面改性紫铜方柱阵列池沸腾传热特性和机理

流体力学与传递现象 | 更新时间：2026-07-24

- 局部表面改性紫铜方柱阵列池沸腾传热特性和机理
- Pool boiling heat transfer performance and mechanism of square copper pillar arrays with partially-modified surface
- 化工学报 2019年70卷第4期页码：1291-1301
- 作者机构：
  
  上海交通大学工程热物理研究所，上海 200240
- 作者简介：
  
  牟帅（1992—），男，硕士研究生，moushuai1020@sjtu.edu.cn
  徐治国（1978—），男，博士，副研究员，zhiguoxu@sjtu.edu.cn
- 基金信息：
  
  国家自然科学基金项目(51576126)
- DOI：10.11949/j.issn.0438-1157.20181070
  中图分类号： TK 124
- 收稿：2018-09-25，
  
  修回：2019-01-16，
  
  网络首发：2020-06-15，
  
  纸质出版：2019-04-12
- 稿件说明：
移动端阅览
牟帅, 赵长颖, 徐治国. 局部表面改性紫铜方柱阵列池沸腾传热特性和机理[J]. 化工学报, 2019, 70(4): 1291-1301

MOU Shuai, ZHAO Changying, XU Zhiguo. Pool boiling heat transfer performance and mechanism of square copper pillar arrays with partially-modified surface[J]. CIESC Journal, 2019, 70(4): 1291-1301
牟帅, 赵长颖, 徐治国. 局部表面改性紫铜方柱阵列池沸腾传热特性和机理[J]. 化工学报, 2019, 70(4): 1291-1301 DOI： 10.11949/j.issn.0438-1157.20181070.

MOU Shuai, ZHAO Changying, XU Zhiguo. Pool boiling heat transfer performance and mechanism of square copper pillar arrays with partially-modified surface[J]. CIESC Journal, 2019, 70(4): 1291-1301 DOI： 10.11949/j.issn.0438-1157.20181070.

摘要

以局部表面改性的紫铜直方柱和梯度方柱阵列为研究对象，实验研究了表面润湿性、表面形貌和表面活性剂对池沸腾换热性能和气泡生长特性的影响。实验工质为去离子水，浓度分别为100、200、400、800 mg·L

-1

的异丙醇溶液和正庚醇溶液。实验结果表明：方柱阵列表面镀银之后润湿性变差，表面产生的气泡数量减少。向去离子水中添加异丙醇或正庚醇后，在热通量为66.1～202 kW·m

-2

时，气泡脱离直径变小、数目减少，而当热通量增至413 kW·m

-2

时，活性剂能够有效阻碍气泡合并，故池沸腾传热系数随着浓度增加先减小后增大。上下层宽分别0.5 mm和1 mm、间距为2 mm的梯度方柱阵列结构有助于气泡的合并，但由于促进了固体表面气膜的形成，从而降低了沸腾换热性能。

Abstract

In the present study

the effects of wettability

surface topography and surfactant on the growth of bubbles and pool boiling heat transfer of straight and gradient square copper pillar arrays with partially-modified surface were investigated. The experimental medium was deionized water

100

200

400

800 mg·L

-1

in isopropanol solution and

-heptanol solution. The results showed that silver deposition on square copper pillar decreases the wettability

and increases bubble number. Addition of isopropanol or

-heptanol into deionized water decreases the number and departure diameter of bubbles in the heat flux range of 66.1—202 kW·m

-2

. However

when the heat flux increases to 413 kW·m

-2

the surfactant can effectively prevent bubbles from merging

so the boiling heat transfer coefficient of the pool boiling decreases first and then increases with t

he increase of the concentration. The gradient square pillar structure with upper and lower layers of 0.5 mm and 1mm and a spacing of 2 mm promotes the coalescence of bubbles and formation of a gas film on the heating surface

and then worsens pool boiling heat transfer.

关键词

Keywords

references

Liang G , Mudawar I . Pool boiling critical heat flux (CHF)(1): Review of mechanisms, models, and correlations [J ] . International Journal of Heat & Mass Transfer , 2018 , 117 : 1352 - 1367 .

Song G , Davies P A , Wen J , et al . Nucleate pool boiling heat transfer of SES36 fluid on nanoporous surfaces obtained by electrophoretic deposition of Al 2 O 3 [J ] . Applied Thermal Engineering , 2018 , 141 : 143 - 152 .

Kim S H , Lee G C , Kang J Y , et al . A study of nucleate bubble growth on microstructured surface through high speed and infrared visualization [J ] . International Journal of Multiphase Flow , 2017 , 95 : 12 - 21 .

吴慧英 , 吴信宇 . 水/乙醇混合工质在硅基微通道中的流动与换热 [J ] . 化工学报 , 2008 , 59 ( 11 ): 2706 - 2712 .

Wu H Y , Wu X Y . Flow and heat transfer of water/ethanol mixed working fluid in silicon-based microchannels [J ] . Journal of Chemical Industry and Engineering（China） , 2008 , 59 ( 11 ): 2706 - 2712 .

Park S D , Lee S W , Kang S , et al . Effects of nanofluids containing graphene/graphene-oxide nanosheets on critical heat flux [J ] . Applied Physics Letters , 2010 , 97 ( 2 ): 718 .

纪献兵 , 徐进良 . 表面活性剂对池沸腾换热的影响 [J ] . 工程热物理学报 , 2008 , 29 ( 12 ): 2049 - 2052 .

Ji X B , Xu J L . Effects of surfactants on pool boiling heat transfer [J ] . Journal of Engineering Thermophysics , 2008 , 29 ( 12 ): 2049 - 2052 .

柴永志 , 张伟 , 李亚 , 等 . 非均匀润湿性微通道表面池沸腾换热特性 [J ] . 化工学报 , 2017 , 68 ( 5 ): 1852 - 1859 .

Chai Y Z , Zhang W , Li Y , et al . Surface pool boiling heat transfer characteristics of non-uniform wettability microchannels [J ] . CIESC Journal , 2017 , 68 ( 5 ): 1852 - 1859 .

Hendricks T J , Krishnan S , Choi C , et al . Enhancement of pool-boiling heat transfer using nanostructured surfaces on aluminum and copper [J ] . International Journal of Heat and Mass Transfer , 2010 , 53 ( 15/16 ): 3357 - 3365 .

钟达文 , 孟继安 , 李志信 . 朝下沟槽结构表面池沸腾换热 [J ] . 化工学报 , 2016 , 67 ( 9 ): 3559 - 3565 .

Zhong D W , Meng J A , Li Z X . Boiling heat transfer in the surface of a trench structure [J ] . CIESC Journal , 2016 , 67 ( 9 ): 3559 - 3565 .

薛淑文 , 李雨晴 , 肖卓楠 , 等 . 水基 SiO 2 纳米流体沸腾换热特性 [J ] . 化工学报 , 2017 , 68 ( 11 ): 4147 - 4153 .

Xue S W , Li Y Q , Xiao Z N , et al . Boiling heat transfer characteristics of water-based SiO 2 nanofluids [J ] . CIESC Journal , 2017 , 68 ( 11 ): 4147 - 4153 .

Ciloglu D , Bolukbasi A . A comprehensive review on pool boiling of nanofluids [J ] . Applied Thermal Engineering , 2015 , 84 : 45 - 63 .

Fang X , Wang R , Chen W , et al . A review of flow boiling heat transfer of nanofluids [J ] . Applied Thermal Engineering , 2015 , 91 : 1003 - 1017 .

Wu J M , Zhao J . A review of nanofluid heat transfer and critical heat flux enhancement—research gap to engineering application [J ] . Progress in Nuclear Energy , 2013 , 66 : 13 - 24 .

徐立 , 赖喜锐 , 王斌 , 等 . 脉冲加热下微加热器在 Al 2 O 3 纳米流体中的沸腾换热 [J ] . 化工学报 , 2011 , 62 ( 3 ): 678 - 684 .

Xu L , Lai X R , Wang B , et al . Boiling heat transfer of micro-heaters in Al 2 O 3 nanofluids under pulse heating [J ] . CIESC Journal , 2011 , 62 ( 3 ): 678 - 684 .

Manetti L L , Stephen M T , Beck P A , et al . Evaluation of the heat transfer enhancement during pool boiling using low concentrations of Al 2 O 3 -water based nanofluid [J ] . Experimental Thermal and Fluid Science , 2017 , 87 : 191 - 200 .

Karimzadehkhouei M , Shojaeian M , Şendur K , et al . The effect of nanoparticle type and nanoparticle mass fraction on heat transfer enhancement in pool boiling [J ] . International Journal of Heat and Mass Transfer , 2017 , 109 : 157 - 166 .

Özbey A , Karimzadehkhouei M , Sefiane K , et al . Changing bubble dynamics in subcooled boiling with TiO 2 , nanoparticles on a platinum wire [J ] . Journal of Molecular Liquids , 2017 , 242 : 456 - 470 .

程立新 , 陈听宽 . 沸腾传热强化技术及方法 [J ] . 化工装备技术 , 1999 , 20 ( 1 ): 30 - 34 .

Cheng L X , Chen T K . Boiling heat transfer enhancement technology and method [J ] . Chemical Industry Equipment Technology , 1999 , 20 ( 1 ): 30 - 34 .

陈宏霞 , 黄林滨 , 宫逸飞 . 多孔结构及表面浸润性对池沸腾传热影响的研究进展 [J ] . 化工进展 , 2017 , 36 ( 8 ): 2798 - 2808 .

Chen H X , Huang L B , Gong Y F . Research progress on the effect of porous structure and surface wettability on pool boiling heat transfer [J ] . Chemical Industry and Engineering Progress , 2017 , 36 ( 8 ): 2798 - 2808 .

Hsu C C , Lee M R , Wu C H , et al . Effect of interlaced wettability on horizontal copper cylinders in nucleate pool boiling [J ] . Applied Thermal Engineering , 2017 , 112 : 1187 - 1194 .

Betz A R , Xu J , Qiu H , et al . Do surfaces with mixed hydrophilic and hydrophobic areas enhance pool boiling [J ] . Applied Physics Letters , 2010 , 97 ( 14 ): 141909 .

孔新 , 魏进家 , 张永海 . 亲疏水表面换热性能及其沸腾现象的微细化研究 [J ] . 工程热物理学报 , 2018 , 39 ( 6 ): 1373 - 1378 .

Kong X , Wei J J , Zhang Y H . Study on surface heat transfer performance of hydrophobic surface and micronization of boiling phenomenon [J ] . Journal of Engineering Thermophysics , 2018 , 39 ( 6 ): 1373 - 1378 .

Forrest E , Williamson E , Buongiorno J , et al . Augmentation of nucleate boiling heat transfer and critical heat flux using nanoparticle thin-film coatings [J ] . International Journal of Heat and Mass Transfer , 2010 , 53 ( 1/2/3 ): 58 - 67 .

Rioux R P , Nolan E C , Li C H . A systematic study of pool boiling heat transfer on structured porous surfaces: from nanoscale through microscale to macroscale [J ] . AIP Advances , 2014 , 4 ( 11 ): 117133 .

Chu K H , Soo J Y , Enright R , et al . Hierarchically structured surfaces for boiling critical heat flux enhancement [J ] . Applied Physics Letters , 2013 , 102 ( 15 ): 151602 .

张伟 , 牛志愿 , 李亚 , 等 . 石墨烯/镍复合微结构表面的池沸腾传热特性 [J ] . 化工进展 , 2018 , 37 ( 10 ): 3759 - 3765 .

Zhang W , Niu Z Y , Li Y , et al . Pool boiling heat transfer characteristics of graphene/nickel composite microstructures [J ] . Chemical Industry and Engineering Progress , 2018 , 37 ( 10 ): 3759 - 3765 .

Shin S , Seok Kim B , Choi G , et al . Double-templated electrodeposition: simple fabrication of micro-nano hybrid structure by electrodeposition for efficient boiling heat transfer [J ] . Applied Physics Letters , 2012 , 101 ( 25 ): 251909 .

Kim D E , Park S C , Yu D I , et al . Enhanced critical heat flux by capillary driven liquid flow on the well-designed surface [J ] . Applied Physics Letters , 2015 , 107 ( 2 ): 023903 .

Zou A , Maroo S C . Critical height of micro/nano structures for pool boiling heat transfer enhancement [J ] . Applied Physics Letters , 2013 , 103 ( 22 ): 221602 .

魏进家 , 张永海 . 柱状微结构表面强化沸腾换热研究综述 [J ] . 化工学报 , 2016 , 67 ( 1 ): 97 - 108 .

Wei J J , Zhang Y H . Review of surface enhanced boiling heat transfer on columnar microstructures [J ] . CIESC Journal , 2016 , 67 ( 1 ): 97 - 108 .

Lu M C , Huang C H , Huang C T , et al . A modified hydrodynamic model for pool boiling CHF considering the effects of heater size and nucleation site density [J ] . International Journal of Thermal Sciences , 2015 , 91 : 133 - 141 .

郭兆阳 , 徐鹏 , 王元华 , 等 . 烧结型多孔表面管外池沸腾传热特性 [J ] . 化工学报 , 2012 , 63 ( 12 ): 3798 - 3804 .

Guo Z Y , Xu P , Wang Y H , et al . Boiling heat transfer characteristics of sintered porous surface tube outside the tube [J ] . CIESC Journal , 2012 , 63 ( 12 ): 3798 - 3804 .

Xu Z G , Zhao C Y . Enhanced boiling heat transfer by gradient porous metals in saturated pure water and surfactant solutions [J ] . Applied Thermal Engineering , 2016 , 100 : 68 - 77 .

Lee C Y , Bhuiya M M H , Kim K J . Pool boiling heat transfer with nano-porous surface [J ] . International Journal of Heat and Mass Transfer , 2010 , 53 ( 19/20 ): 4274 - 4279 .

Kong X , Zhang Y , Wei J . Experimental study of pool boiling heat transfer on novel bistructured surfaces based on micro-pin-finned structure [J ] . Experimental Thermal and Fluid Science , 2018 , 91 : 9 - 19 .

杨世铭 , 陶文铨 . 传热学 [M ] . 4版 . 北京 : 高等教育出版社 , 2006 : 398 - 399 .

Yang S M , Tao W Q . Heat Transfer [M ] . 4th ed . Beijing : Higher Education Press , 2006 : 398 - 399 .

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

液晶弹性体温度自适应润湿性表面沸腾特性研究

基于自驱射流装置的强化池沸腾换热研究

水平管内分段式多孔镀层R245fa沸腾换热特性

可聚型Gemini表面活性剂的制备、表征及其稳定高内相乳液的研究

基于振荡座滴测定液滴表面张力的方法