氧化石墨烯/石蜡复合相变乳液的制备及对流传热特性

刘小诗; 邹得球; 贺瑞军; 马先锋

doi:10.11949/j.issn.0438-1157.20180895

您当前的位置：

首页 >

文章列表页 >

氧化石墨烯/石蜡复合相变乳液的制备及对流传热特性

材料化学工程与纳米技术 | 更新时间：2026-07-24

- 氧化石墨烯/石蜡复合相变乳液的制备及对流传热特性
- Preparation and heat transfer characteristics of GO/paraffin composite phase change emulsions
- 化工学报 2019年70卷第3期页码：1188-1197
- 作者机构：
  
  宁波大学海运学院，浙江宁波 315211
- 作者简介：
  
  刘小诗（1992—），男，硕士研究生，1563940515@qq.com
  邹得球（1981—），男，博士，副教授，zoudeqiu@nbu.edu.cn
- 基金信息：
  
  浙江省自然科学基金项目(LY17E060001);宁波市自然科学基金项目(2017A610019);国家自然科学基金项目(51206083)
- DOI：10.11949/j.issn.0438-1157.20180895
  中图分类号： TB 34
- 收稿：2018-08-03，
  
  修回：2018-11-10，
  
  网络首发：2026-07-24，
  
  纸质出版：2019-03-05
- 稿件说明：
移动端阅览
刘小诗, 邹得球, 贺瑞军, 马先锋. 氧化石墨烯/石蜡复合相变乳液的制备及对流传热特性[J]. 化工学报, 2019, 70(3): 1188-1197

LIU Xiaoshi, ZOU Deqiu, HE Ruijun, MA Xianfeng. Preparation and heat transfer characteristics of GO/paraffin composite phase change emulsions[J]. CIESC Journal, 2019, 70(3): 1188-1197
刘小诗, 邹得球, 贺瑞军, 马先锋. 氧化石墨烯/石蜡复合相变乳液的制备及对流传热特性[J]. 化工学报, 2019, 70(3): 1188-1197 DOI： 10.11949/j.issn.0438-1157.20180895.

LIU Xiaoshi, ZOU Deqiu, HE Ruijun, MA Xianfeng. Preparation and heat transfer characteristics of GO/paraffin composite phase change emulsions[J]. CIESC Journal, 2019, 70(3): 1188-1197 DOI： 10.11949/j.issn.0438-1157.20180895.

摘要

为提高石蜡相变乳液的传热性能，通过添加氧化石墨烯(GO)，制备了GO/石蜡复合相变乳液并对其相关性能进行了表征。搭建了流动阻力、对流换热试验台，对比研究了石蜡相变乳液及GO/石蜡复合相变乳液的流动阻力特性和对流换热特性，试验结果表明，由于GO的亲水性，复合相变乳液都表现出较好的稳定性。当GO的质量分数为0.01％、0.02％、0.03％时，复合相变乳液的热导率分别增加了20.01％、30.50％、35.18％。添加GO使乳液的流动阻力略有增加，直管段最大增加了6.70%，90°弯管处最大增加了13.20%；对流传热系数随着GO浓度的增加而增大，当GO浓度为0.03％时，对流传热系数最大提高了43.90％。

Abstract

To improve the heat transfer performance of paraffin phase change emulsion

GO/paraffin composite phase change emulsion was prepared by adding graphene oxide (GO) and its properties were characterized. The flow resistance and convection heat transfer test rig were set up

and the flow resistance characteristics and convective heat transfer characteristics of paraffin phase change emulsion and GO/paraffin composite phase change emulsion were comparatively studied. The results show that the composite phase change emulsion shows good stability due to the hydrophilicity of GO. When the mass fraction of GO is 0.01%

0.02%

and 0.03%

the thermal conductivity of the composite phase change emulsion increases by 20.01%

30.50%

and 35.18%

respectively. The flow resistance of the GO/paraffin composite phase change emulsion increases slightly compared to that of paraffin phase change emulsion. The straight pipe section increased by 6.70%

and the 90°elbow section increased by 13.20%.The convective heat transfer coefficient increases with the increase of GO concentration. The maximum convective heat transfer coefficient was increased by 43.90% at the GO addition amount of 0.03%.

关键词

Keywords

references

黄莉 . 石蜡/水相变乳液的制备与性能 [J ] . 化工学报 , 2018 , 69 ( 4 ): 1749 - 1757 .

Huang L . Preparation and properties of paraffin/water phase change emulsion [J ] . CIESC Journal , 2018 , 69 ( 4 ): 1749 - 1757 .

刘东 , 何蔚然 , 钟小龙 , 等 . 潜热型功能热流体在微小管道内的换热特性 [J ] . 化工进展 , 2016 , 35 ( 10 ): 3042 - 3048 .

Liu D , He W R , Zhong X L , et al . The heat transfer characteristics of latent functionally thermal fluid in micro tube [J ] . Chemical Industry and Engineering Progress , 2016 , 35 ( 10 ): 3042 - 3048 .

Zou D , Feng Z , Xiao R , et al . Preparation and flow characteristic of a novel phase change fluid for latent heat transfer [J ] . Solar Energy Materials & Solar Cells , 2010 , 94 ( 12 ): 2292 - 2297 .

Kumaresan V , Chandrasekaran P , Nanda M , et al . Role of PCM based nanofluids for energy efficient cool thermal storage system [J ] . International Journal of Refrigeration , 2013 , 36 ( 6 ): 1641 - 1647 .

Liu J , Xu C , Chen L L , et al . Preparation and photo-thermal conversion performance of modified graphene/ionic liquid nanofluids with excellent dispersion stability [J ] . Solar Energy Materials & Solar Cells , 2017 , 170 : 219 - 232 .

Ghorbani H R . Preparation of copper nanofluids using an appropriate technique [J ] . Oriental Journal of Chemistry , 2014 , 30 ( 4 ): 2025 - 2028 .

Li D , Hong B , Fang W , et al . Preparation of well-dispersed silver nanoparticles for oil-based nanofluids [J ] . Industrial & Engineering Chemistry Research , 2010 , 49 ( 4 ): 1697 - 1702 .

Liu M S , Lin C C , Tsai C Y , et al . Enhancement of thermal conductivity with Cu for nanofluids using chemical reduction method [J ] . International Journal of Heat & Mass Transfer , 2006 , 49 ( 17 ): 3028 - 3033 .

Madhesh D , Kalaiselvam S . Experimental study on the heat transfer and flow properties of Ag-ethylene glycol nanofluid as a coolant [J ] . Heat & Mass Transfer , 2014 , 50 ( 11 ): 1597 - 1607 .

Das S K , Putra N , Thiesen P , et al . Temperature dependence of thermal conductivity enhancement for nanofluids [J ] . Journal of Heat Transfer , 2003 , 125 ( 4 ): 567 .

常强 . 碳纳米管纳米流体传热特性实验研究 [D ] . 青岛 : 青岛科技大学 , 2015 .

Chang Q . Experimental study on the thermal conductivity of carbon nanotubes nanofluids [J ] . Qingdao: Qingdao University of Science and Technology , 2015 .

向军，李菊香 . 纳米悬浮液的有效导热系数 [J ] . 低温与超导 , 2009 , 37 ( 1 ): 59 - 62 .

Xiang J , Li J X . Effective thermal conductiv ity of nanoparticles suspension [J ] . Cryo. & Supercond , 2009 , 37 ( 1 ): 59 - 62 .

Morimoto T , Togashi K , Kumano H , et al . Thermophysical properties of phase change emulsions prepared by D-phase emulsification [J ] . Energy Conversion & Management , 2016 , 122 : 215 - 222 .

Zhang X , Wu J Y , Niu J . PCM-in-water emulsion for solar thermal applications: the effects of emulsifiers and emulsification conditions on thermal performance, stability and rheology characteristics [J ] . Solar Energy Materials & Solar Cells , 2016 , 147 : 211 - 224 .

Ho C J , Gao J Y . Preparation and thermophysical properties of nanoparticle-in-paraffin emulsion as phase change material [J ] . International Communications in Heat & Mass Transfer , 2009 , 36 ( 5 ): 467 - 470 .

Zheng Y F , Qiu Z Z , Chen J . The investigation of phase change emulsion (PCE): fabrication, thermal conductivity and utilization of nanoparticles [J ] . Advanced Materials Research , 2014 , 860-863 : 862 - 866 .

邹得球 , 肖睿 , 何世辉 , 等 . 基于纳米粒子/相变石蜡乳状液的研究 [J ] . 材料导报 , 2009 , 23 ( 15 ): 103 - 107 .

Zou D Q , Xiao R , He S H , et al . Research based on nanoparticles/ phase change wax emulsion [J ] . Materials Review , 2009 , 23 ( 15 ): 103 - 107 .

杨志涛 , 张军强 , 宗冬冬 , 等 . SiO 2 改性石墨烯–石蜡复合相变乳液的制备及热性能 [J ] . 新能源进展 , 2017 , 5 ( 2 ): 110 - 116 .

Yang Z T , Zhang J Q , Zong D D , et al . Preparation and thermal properties of SiO 2 modified graphene-paraffin composite phase change emulsions [J ] . Advances in New and Renewable Energy , 2017 , 5 ( 2 ): 110 - 116 .

毛凌波 , 梁志彬 , 林敬堂 , 等 . 纳米材料增强石蜡相变乳状液在太阳能中的应用 [J ] . 太阳能学报 , 2016 , 37 ( 1 ): 142 - 146 .

Mao L B , Liang Z B , Lin J T , et al . Nanomaterials enhanced phase change wax emulisions used in the solar energy [J ] . Acta Energiae Solaris Sinica , 2016 , 37 ( 1 ): 142 - 146 .

Wang F , Zhang C , Liu J , et al . Highly stable graphite nanoparticle-dispersed phase change emulsions with little supercooling and high thermal conductivity for cold energy storage [J ] . Applied Energy , 2017 , 188 : 97 - 106 .

Wang F , Liu J , Fang X , et al . Graphite nanoparticles-dispersed paraffin/water emulsion with enhanced thermal-physical property and photo-thermal performance [J ] . Solar Energy Materials & Solar Cells , 2016 , 147 : 101 - 107 .

Yu W , Xie H , Bao D . Enhanced thermal conductivities of nanofluids containing graphene oxide nanosheets [J ] . Nanotechnology , 2010 , 21 ( 5 ): 055705 .

Gupta S S , Siva V M , Krishnan S , et al . Thermal conductivity enhancement of nanofluids containing graphene nanosheets [J ] . Journal of Applied Physics , 2011 , 110 ( 8 ): 902 .

Yu W , Xie H , Chen W . Experimental investigation on thermal conductivity of nanofluids containing graphene oxide nanosheets [J ] . Journal of Applied Physics , 2010 , 107 ( 9 ): 666 .

Kausar A . Enhanced electrical and thermal conductivity of modified poly(acrylonitrile-co-butadiene)-based nanofluid containing functional carbon black-graphene oxide [J ] . Fullerene Science & Technology , 2016 , 24 ( 4 ): 278 - 285 .

Ranjbarzadeh R , Karimipour A , Afrand M , et al . Empirical analysis of heat transfer and friction factor of water/graphene oxide nanofluid flow in turbulent regime through an isothermal pipe [J ] . Applied Thermal Engineering , 2017 , 126 : 538 - 547 .

Özerinç S , Kakaç S , Yazicioglu A G . Enhanced thermal conductivity of nanofluids: a state-of-the-art review [J ] . Microfluidics & Nanofluidics , 2010 , 8 ( 2 ): 145 - 170 .

Kibria M A , Anisur M R , Mahfuz M H , et al . A review on thermophysical properties of nanoparticle dispersed phase change materials [J ] . Energy Conversion & Management , 2015 , 95 : 69 - 89 .

刘彦丰 , 高正阳 , 梁秀俊 . 传热学 [M ] . 北京：中国电力出版社 , 2015 : 54 .

Liu Y F , Gao Z Y , Liang X J , et al . Heat Transfer [M ] . Beijing : China Electric Power Press , 2015 : 54 .

Moffat R J . Describing the uncertainties in experimental results [J ] . Experimental Thermal & Fluid Science , 1988 , 1 ( 1 ): 3 - 17 .

Ma Z W , Zhang P , Wang R Z , et al . Forced flow and convective melting heat transfer of clathrate hydrate slurry in tubes [J ] . International Journal of Heat & Mass Transfer , 2010 , 53 ( 19 ): 3745 - 3757 .

Ma Z W , Zhang P . Pressure drops and loss coefficients of a phase change material slurry in pipe fittings [J ] . International Journal of Refrigeration , 2012 , 35 ( 4 ): 992 - 1002 .

张飞龙 , 王莉 , 俞树荣 , 等 . 氧化石墨烯及其导热纳米流体的制备与性能 [J ] . 功能材料 , 2015 , 46 ( 16 ): 16138-16141 .

Zhang L F , Wang L , Yu S R , et al . Preparation and properties of graphene oxide and its thermally conductive nanofluid [J ] . Journal of Functional Materials , 2015 , 46 ( 16 ): 16138-16141 .

Fotukian S M , Esfahany M N . Experimental study of turbulent convective heat transfer and pressure drop of dilute CuO/water nanofluid inside a circular tube [J ] . International Communications in Heat & Mass Transfer , 2010 , 37 ( 2 ): 214 - 219 .

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

氧化石墨烯/水脉动热管的启动及传热特性

基于自驱射流装置的强化池沸腾换热研究

氧化铝纳米流体液冷电池热管理性能研究

内管移动对卧式管壳相变储热器储放热性能影响的实验研究

石蜡/TPMS结构多孔AlSi10Mg合金复合相变材料蓄热性能实验研究