吸湿性盐溶液振荡热管的传热特性研究

张航; 翁建华; 崔晓钰

doi:10.11949/j.issn.0438-1157.20180661

您当前的位置：

首页 >

文章列表页 >

吸湿性盐溶液振荡热管的传热特性研究

流体力学与传递现象 | 更新时间：2026-07-24

- 吸湿性盐溶液振荡热管的传热特性研究
- Heat transfer performance of pulsating heat pipe with hygroscopic salt solution
- 化工学报 2019年70卷第3期页码：874-882
- 作者机构：
  
  1.上海电力学院能源与机械工程学院，上海 200090
  2.上海理工大学能源与动力工程学院，上海 200093
- 作者简介：
  
  张航（1994—），男，硕士研究生，467948121@qq.com
  翁建华（1968—），男，博士，副教授，jhweng@126.com
- 基金信息：
  
  国家自然科学基金项目(51076104)
- DOI：10.11949/j.issn.0438-1157.20180661
  中图分类号： TK 124
- 收稿：2018-06-15，
  
  修回：2018-11-16，
  
  网络首发：2026-07-24，
  
  纸质出版：2019-03-05
- 稿件说明：
移动端阅览
张航, 翁建华, 崔晓钰. 吸湿性盐溶液振荡热管的传热特性研究[J]. 化工学报, 2019, 70(3): 874-882

ZHANG Hang, WENG Jianhua, CUI Xiaoyu. Heat transfer performance of pulsating heat pipe with hygroscopic salt solution[J]. CIESC Journal, 2019, 70(3): 874-882
张航, 翁建华, 崔晓钰. 吸湿性盐溶液振荡热管的传热特性研究[J]. 化工学报, 2019, 70(3): 874-882 DOI： 10.11949/j.issn.0438-1157.20180661.

ZHANG Hang, WENG Jianhua, CUI Xiaoyu. Heat transfer performance of pulsating heat pipe with hygroscopic salt solution[J]. CIESC Journal, 2019, 70(3): 874-882 DOI： 10.11949/j.issn.0438-1157.20180661.

摘要

研究了10%(质量分数)LiCl吸湿性盐溶液作为工质的振荡热管传热特性。测试了在45％～90％充液率、10～100 W加热功率下振荡热管蒸发端温度及热阻的变化，并与去离子水工质的实验数据进行了对比。结果表明：在45％、55％的低充液率下，加热功率达到50 W以上时，LiCl溶液振荡热管的热阻明显比去离子水振荡热管低，能有效延迟烧干现象的发生。在62%的中等充液率，35W加热功率以上，LiCl溶液振荡热管的蒸发端温度较离子水振荡热管振荡频率快，幅度小且热阻低。在80%、90%的高充液率下，两种工质振荡热管的蒸发端温度曲线在平均温度、振荡频率、振荡幅度上都较为相似，热阻也比较接近。

Abstract

The heat transfer characteristics of the 10% (mass) concentration LiCl hygroscopic salt solution as the oscillating heat pipe of the working fluid were studied. The 10% LiCl salt solution was prepared to test the PHP evaporator section temperature and the thermal resistance at 45%—90% filling rate and 10—100 W heating power. Besides

that of deionized water PHP was compared. The results show that at the low filling rate of 45% and 55%

when the heating power reaches over 50 W

the thermal resistance of LiCl solution pulsating heat pipe is obviously lower than that of the deionized water PHP. LiCl solution can effectively delay the occurrence of dry-out phenomenon and reduce the thermal resistance of the PHP. At the filling rate of 62%

when the heating power reaches over 35 W

the evaporator section temperature curve of LiCl solution PHP has higher oscillation frequency and smaller oscillation amplitude. The thermal resistance of LiCl solution PHP at different heat power is lower than that of the deionized water PHP. At the high filling rate of 80% and 90%

the temperature curves of the evaporator section of the two types of PHP are similar for the average temperature

the oscillation frequency and the amplitude. The thermal resistance is relatively close.

关键词

Keywords

references

Akachi H , Polasek F , Stulc P . Pulsating heat pipe [C ] //Proceeding of 5th International Heat Pipe Symposium. Melbourne , 1996 .

施赛燕 , 崔晓钰 , 周宇 , 等 . 石墨烯/去离子水纳米流体振荡热管传热性能 [J ] . 化工学报 , 2016 , 67 ( 12 ): 4944 - 4950 .

Shi S Y , Cui X Y , Zhou Y , et al . Heat transfer performance of pulsating heat pipe with graphene aqueous nanofluids [J ] . CIESC Journal , 2016 , 67 （ 12 ）: 4944 - 4950 .

屈健 , 吴慧英 . 微型硅基振荡热管传热特性 [J ] . 化工学报 , 2011 , 62 ( 11 ): 3046 - 3052 .

Qu J , Wu H Y . Thermal performance of micro pulsating heat pipe [J ] . CIESC Journal , 2011 , 62 ( 11 ): 3046 - 3052 .

Gi K , Sato F , Maezawa S ． Flow visualization experiment on oscillating heat pipe [C ] //International Heat Pipe Conference.Japan , 1999 : 659 - 660 .

Sun Q , Qu J , Li X J , et al . Experimental investigation of thermo-hydrodynamic behavior in a closed loop oscillating heat pipe [J ] . Experimental Thermal and Fluid Science , 2017 , 82 : 450 - 458 .

Khandekar S , Groll M . An insight into thermo-hydrodynamic coupling in closed loop pulsating heat pipes [J ] . International Journal of Thermal Sciences , 2004 , 43 ( 1 ): 13 - 20 .

商福民 , 刘登瀛 , 冼海珍 . 振荡热管内不同形态纳米颗粒流动及传热特性 [J ] . 化工学报 , 2007 , 58 ( 9 ): 2200 - 2204 .

Shang F M , Liu D Y , Xian H Z . Flow and heat transfer characteristics of different forms of nanometer particles in oscillating heat pipe [J ] . Journal of Chemical Industry and Engineering(China) , 2007 , 58 ( 9 ): 2200 - 2204 .

Rittidech S , Terdtoon P , Tantakom P , et al . Effect of inclination angles, evaporator section lengths and working fluid properties on heat transfer characteristics of a closed-end oscillating heat pipe [C ] //Proceedings of 6th International Heat Pipe Symposium. Chiengmai , 2000 : 413 - 421 .

Schneider M , Khandekar S , Schaefer P , et al . Visualization of thermo fluid dynamic phenomena in flat plate closed loop pulsating heat pipes [C ] //Proceedings of 6th International Heat Pipe Symposium. Chiengmai , 2000 : 366 - 380 ．

蔡骥驰 , 王瑞祥 , 徐荣吉 , 等 . SDBS对铜-水脉动热管启动及传热性能影响 [J ] . 化工学报 , 2016 , 67 ( 5 ): 1852 - 1857 .

Cai J C , Wang R X , Xu R J , et al . Influence of SDBS on start time and heat transfer performance of pulsating heat pipe [J ] . CIESC Journal , 2016 , 67 ( 5 ): 1852 - 1857 .

Sarangi R K , Rane M V . Experimental investigations for start up and maximum heat load of closed loop pulsating heat pipe [J ] . Procedia Engineering , 2013 , 51 : 683 - 687 .

徐进良 , 张显明 , 施慧烈 . 脉冲热管中的热力型脉动现象及实验测量 [J ] . 自然科学进展 , 2004 , 14 ( 4 ): 436 - 441 .

Xu J L , Zhang X M , Shi H L . Thermomechanical pulsation and experimental measurement on oscillating heat pipe [J ] . Progress in Natural Science Materials International , 2004 , 14 ( 4 ): 436 - 441 .

Chu H R , Xie G Z , Liu L . Discussion on thermodynamic properties of binary mixture adaptation of pulsating heat pipe [J ] . Refrigeration and Air-conditioning 2011 , 25 ( 3 ): 216 - 219 .

朱悦 , 崔晓钰 , 韩华 . 水、丙酮混合工质振荡热管传热性能 [J ] . 化工学报 , 2014 , 65 ( 8 ): 2940 - 2947 .

Zhu Y , Cui X Y , Hang H . Heat transfer performance of pulsating heat pipes with water-acetone mixtures [J ] . CIESC Journal , 2014 , 65 ( 8 ): 2940 - 2947 .

崔晓钰 , 段威威 , 乔铁梁 . 两组元乙醇基混合工质振荡热管的传热性能 [J ] . 化工学报 , 2014 , 65 ( 10 ): 3852 - 3860 .

Cui X Y , Duan W W , Qiao T L . Heat transfer performance of pulsating heat pipe with ethanol-based binary mixtures [J ] . CIESC Journal , 2014 , 65 ( 10 ): 3852 - 3860 .

Zhang Y , Faghri A , Shafi M B . Capillary blocking in forced convective condensation in horizontal miniature channels [J ] . ASME J. Heat Transfer , 2001 , 123 ( 3 ): 501 - 511 .

曹小林 , 席战利 , 周晋 , 等 . 脉动热管运行可视化及传热与流动特性的实验研究 [J ] . 热能动力工程 , 2004 , 4 : 411 - 415 .

Cao X L , Xi Z L , Zhou J . Experimental investigation of the visualization of pulsating heat-pipe operation as well as heat transfer and flow characteristics [J ] . Journal of Engineering for Thermal Energy and Power , 2004 , 4 : 411 - 415 .

Gi K . Flow visualization experiment on oscillating capillary heat pipe [C ] //11th International Heat Pipe Conference. Tokyo , 1999 .

崔晓钰 , 李治华 , 孙慎德 . 振荡热管的热阻变化规律及烧干特性 [J ] . 化工学报 , 2013 , 64 ( 6 ): 2022 - 2028 .

Cui X Y , Li Z H , Sun S D . Thermal resistance variation and dryout phenomenon of pulsating heat pipe [J ] . CIESC Journal , 2013 , 64 ( 6 ): 2022 - 2028 .

赵相相 , 张燕 , 丁云飞 , 等 . 除湿溶液表面蒸汽压的实验研究 [J ] . 暖通空调 , 2007 , 37 ( 4 ): 15 - 18 .

Zhao X X , Zhang Y , Ding Y F , et al . Experiment on surface vapor pressure of liquid desiccant [J ] . Journal Heating Ventilating and Airconditioning , 2007 , 37 ( 4 ): 15 - 18 .

徐惠斌 , 胡自成 , 宋新南 , 等 . 高浓度氯化锂水溶液沸腾换热特性实验 [J ] . 长春工业大学学报(自然科学版) , 2012 , 33 ( 4 ): 465 - 468 .

Xu H B , Hu Z C , Song X N , et al . Experiment study on the of concentrated boiling heat transfer property aqueous LiCl solution [J ] . Journal of Changchun University of Technology , 2012 , 33 ( 4 ): 465 - 468 .

Cui Q . The effect of dissolving gases or solids in water droplets boiling on a hot surface [J ] . Journal of Heat Transfer , 2001 , 123 : 719 - 728 .

Cui Q . The effect of dissolving salts in water sprays used for quenching a hot surface(Ⅱ): Spray cooling [J ] . Int . J . Heat Mass Trans ., 2003 , 125 : 333 - 338 .

Jamialahmadi M , Helalizadeh A , Steinhagen H M ． Pool boiling heat transfer to electrolyte solutions [J ] ． International Journal of Heat and Mass Transfer , 2004 , 47 : 729 - 742 ．

郝婷婷 , 马学虎 , 兰忠 , 等 . 超疏水和超亲水表面对脉动热管性能的影响 [J ] . 工程热物理学报 , 2015 , 36 ( 12 ): 2670 - 2673 .

Hao T T , Ma X H , Lan Z , et al . Experimental investigation of the effects of superhydrophobic and superhydrophilic surfaces on the pulsating heat pipe [J ] . Journal of Engineering Thermophysics , 2015 , 36 ( 12 ): 2670 - 2673 .

曲伟 , 马同泽 . 脉动热管的工质流动和传热特性实验研究 [J ] . 工程热物理学报 , 2002 , 23 ( 5 ): 596 - 598 .

Qu W , Ma T Z . Experimental investigation on flow and heat transfer of pulsating heat pipe [J ] . Journal of Engineering Thermophysics , 2002 , 23 ( 5 ): 596 - 598 .

Hu Y X , Liu T Q , Li X Y , et al . Heat transfer enhancement of micro oscillating heat pipes with self-rewetting fluid [J ] . International Journal of Heat and Mass Transfer , 2017 , 70 : 496 - 503 .

Hao T , Ma X , Lan Z , et al . Effects of hydrophobic surface effect on heat transfer performance and oscillating motion for an oscillating heat pipe [J ] . International Journal of Heat and Mass Transfer , 2014 , 72 : 50 - 65 .

Wang X H , Zheng H C , Si M Q , et al . Experimental investigation of the influence of surfactant on the heat transfer performance of pulsating heat pipe [J ] . International Journal of Heat and Mass Transfer , 2015 , 83 : 586 - 590 .

邱成悌 , 赵亨殳 , 蒋全兴 . 电子设备结构设计原理 [M ] . 南京 : 东南大学出版社 , 2005 .

Qiu C T , Zhao H S , Jang Q X . Structure Design Principle of Electronic Equipment [M ] . Nanjing : Southeast University Press , 2005 .

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

V形沟槽纳米线团簇表面的毛细抽吸-补液蒸发传热特性研究

基于GA-BP神经网络的横管降膜蒸发传热系数预测

基于格子Boltzmann方法的荷电液滴蒸发及传热研究

微通道蒸发器优化两相制冷剂分配及沸腾传热研究进展

基板温度对HFE7100液滴蒸发过程的影响研究