一种天然气液化和CO<sub>2</sub>捕集相结合的余热回收发电系统

张丽; 王文武; 张智恩; 刘培胜; 文江波; 董亮

doi:10.11949/j.issn.0438-1157.20180567

您当前的位置：

首页 >

文章列表页 >

一种天然气液化和CO₂捕集相结合的余热回收发电系统

能源和环境工程 | 更新时间：2020-06-24

- 一种天然气液化和CO₂捕集相结合的余热回收发电系统
- A waste heat recovery power generation system combined with natural gas liquefaction and CO₂ capture
- 化工学报 2019年70卷第1期页码：261-270
- 作者机构：
  
  1.辽宁石油化工大学石油天然气工程学院，辽宁抚顺 113001
  2.重庆理工大学化学与化工学院，重庆400054
  3.辽宁石油化工大学计算机与通信工程学院，辽宁抚顺 113001
  4.广东石油化工大学石油工程学院，广东茂名 525000
- 作者简介：
  
  张丽（1994—），女，硕士研究生，zhanglili1229@hotmail.com
  王文武（1975—），男，硕士，讲师，41116521@qq.com
- 基金信息：
  
  辽宁省自然科学基金项目(201602470)
- DOI：10.11949/j.issn.0438-1157.20180567
  中图分类号： TE 09
- 收稿：2018-05-28，
  
  修回：2018-10-10，
  
  纸质出版：2019-01-05
- 稿件说明：
移动端阅览
张丽, 王文武, 张智恩, 刘培胜, 文江波, 董亮. 一种天然气液化和CO₂捕集相结合的余热回收发电系统[J]. 化工学报, 2019, 70(1): 261-270 DOI: 10.11949/j.issn.0438-1157.20180567.

ZHANG Li, WANG Wenwu, ZHANG Zhi’en, LIU Peisheng, WEN Jiangbo, DONG Liang. A waste heat recovery power generation system combined with natural gas liquefaction and CO₂ capture[J]. CIESC Journal, 2019, 70(1): 261-270 DOI: 10.11949/j.issn.0438-1157.20180567.
张丽, 王文武, 张智恩, 刘培胜, 文江波, 董亮. 一种天然气液化和CO₂捕集相结合的余热回收发电系统[J]. 化工学报, 2019, 70(1): 261-270 DOI: 10.11949/j.issn.0438-1157.20180567. DOI：

ZHANG Li, WANG Wenwu, ZHANG Zhi’en, LIU Peisheng, WEN Jiangbo, DONG Liang. A waste heat recovery power generation system combined with natural gas liquefaction and CO₂ capture[J]. CIESC Journal, 2019, 70(1): 261-270 DOI: 10.11949/j.issn.0438-1157.20180567. DOI：

摘要

针对余热回收和能源利用的问题，以液化天然气(LNG)作为冷源，稠油开采废气作为热源，提出了一种结合天然气液化和废气发电与CO

捕集的余热回收利用系统。分析了关键热力学参数对系统热力学性能的影响。结果表明：对于有机朗肯循环和制冷循环，增加透平膨胀机的进口温度，降低其出口压力以及减少制冷循环压缩机进出口的压缩比，可获得最大净输出功为454.9 kW，余热回收效率为34.2%。对于天然气液化系统，采用C++进行非线性约束优化计算，以氮膨胀制冷循环压缩机总功耗为目标函数进行优化，得到压缩机最优总功耗为101.54 kW。降低天然气压缩机(K110)进口温度，氮气膨胀机(T3)出口压力以及氮气质量流量，可获得最大LNG调峰量为378.8 kg/h，反之，CO

捕集量可提高28.6%。

Abstract

Aiming at the problem of waste heat recovery and energy utilization

LNG and heavy oil extraction exhaust gas are used as cold source and heat source respectively

and a waste heat recovery and utilization system combined with natural gas liquefaction and exhaust gas power generation and CO

capture is proposed. The effect of key parameters on thermodynamic performance is evaluated. The results show that increasing the turbine inlet temperature

decreasing of turbine outlet pressure and in the compression ratio

have a positive effect on the organic Rankine cycle and refrigeration cycle. The maximum net output power and waste heat recovery efficiency are 454.9 kW and 34.2%

respectively. For the natural gas liquefaction system

the nonlinear optimization of natural gas liquefaction cycles was calculated by using C++. The total power consumption within the nitrogen expansion refrigeration compressors has been selected as the objective function. The nonlinear constrained optimization problem of the liquefaction process is constructed. The optimal total power consumption of the compressors is 101.54 kW. The gas peak load regulation can be taken by decreasing the natural gas compressor (K110) inlet temperature

nitrogen turbine (T3) outlet pressure and its mass flow rate; the maximum value is 378.8 kg/h. On the contrary

the volume of carbon dioxide captured can be increased by 28.6%.

关键词

Keywords

references

杨文学 , 杨科学 , 童建翔 , 等 . 稠油储罐余热回收利用改造技术 [J]. 石油技师 , 2015 : 197 - 199 .

Yang W X , Yang K X , Tong J X , et al . Heavy oil storage tank waste heat recovery and utilization technology [J]. Oil Technician , 2015 : 197 - 199 .

Xiao Z Z , Wang S Z , Yang J P . Research on recovering waste heat from liquid produced in heavy oil exploitation by SAGD technology [J]. Advanced Materials Research , 2014 , 960/961 : 410 - 413 .

Wang B , Cheng Q L , Sun W , et al . Application of heat pump technology in waste heat recovery of oilfield sewage [J]. Contemporary Chemical Industry , 2015 , 8 ( 10 ): 34 - 44 .

Wang X . Application of high-temperature water source heat pump units in the waste heat recovery and utilization of waste water in the oilfield [J]. Energy Conservation in Petroleum & Petrochemical Industry , 2017 , 158 ( 20 ): 60 - 70 .

Zhu Y . Promoting the utilization of sewage waste heat in the oilfield with boo management mode [J]. Energy Conservation in Petroleum & Petrochemical Industry , 2017 , 112 ( 3 ): 8 - 15 .

Srinivasan K K , Mago P J , Krishnan S R . Analysis of exhaust waste heat recovery from a dual fuel low temperature combustion engine using an organic Rankine cycle [J]. Energy , 2010 , 35 ( 6 ): 2387 - 2399 .

杨凯 , 张红光 , 宋松松 , 等 . 变工况下车用柴油机排气余热有机朗肯循环回收系统 [J]. 化工学报 , 2015 , 66 ( 3 ): 1097 - 1103 .

Yang K , Zhang H G , Song S S , et al . Waste heat organic Rankine cycle of vehicle diesel engine under variable working conditions [J]. CIESC Journal , 2015 , 66 ( 3 ): 1097 - 1103 .

Mago P J , Luck R . Energetic and exergetic analysis of waste heat recovery from a microturbine using organic Rankine cycles [J]. International Journal of Energy Research , 2013 , 37 ( 8 ): 888 - 898 .

Pan Z , Zhang L , Zhang Z , et al . Thermodynamic analysis of KCS/ORC integrated power generation system with LNG cold energy exploitation and CO 2 capture [J]. Journal of Natural Gas Science & Engineering , 2017 , 46 ( 8 ): 188 - 198 .

田华 , 井东湛 , 王轩 , 等 . 基于内燃机余热回收联产系统变工况特性分析 [J]. 化工学报 , 2018 , 69 ( 2 ): 792 - 800 .

Tian H , Jing D Z , Wang X , et al . Part-load performance analysis of cogeneration system for engine waste heat recovery [J]. CIESC Journal , 2018 , 69 ( 2 ): 792 - 800 .

仇阳 , 潘振 , 李萍 , 等 . 一种发电和天然气再液化相结合的LNG冷能利用系统 [J]. 化工学报 , 2017 , 68 ( 9 ): 3580 - 3591 .

Qiu Y , Pan Z , Li P , et al . An LNG cold energy utilization system combined with power generation and natural gas re-liquefaction [J]. CIESC Journal , 2017 , 68 ( 9 ): 3580 - 3591 .

常学煜 , 张盈盈 , 朱建鲁 , 等 . 一种蒸发天然气再液化氮膨胀制冷工艺流程的优化和海上适应性分析 [J]. 化工进展 , 2017 , 36 ( 5 ): 1619 - 1627 .

Chang X Y , Zhang Y Y , Zhu J L , et al . Optimization of the process of nitrogen expansion refrigeration of BOG and the analysis of the adaptability of the sea [J]. Chemical Industry and Engineering Progress , 2017 , 36 ( 5 ): 1619 - 1627 .

Razi M , Sinha S , Waghmare P R , et al . Effect of steam-assisted gravity drainage (SAGD) produced water properties on oil/water transient interfacial tension [J]. Energy & Fuels , 2016 , 156 ( 34 ): 324 - 330 .

Ashrafi O , Navarri P , Hughes R , et al . Heat recovery optimization in a steam-assisted gravity drainage (SAGD) plant [J]. Energy , 2016 , 111 ( 20 ): 981 - 990 .

Li P , Li J , Pei G , et al . A cascade organic Rankine cycle power generation system using hybrid solar energy and liquefied natural gas [J]. Solar Energy , 2016 , 127 ( 8 ): 136 - 146 .

Guo C , Du X , Yang L , et al . Performance analysis of organic Rankine cycle based on location of heat transfer pinch point in evaporator [J]. Applied Thermal Engineering , 2014 , 62 ( 1 ): 176 - 186 .

Yu H , Feng X , Wang Y . A new pinch based method for simultaneous selection of working fluid and operating conditions in an ORC (organic Rankine cycle) recovering waste heat [J]. Energy , 2015 , 90 : 36 - 46 .

翁一武 . 低品位热能转换过程及利用 [M]. 上海 : 上海交通大学出版社 , 2014 .

Wen Y W . Conversion Process and Utilization of Low Grade Heat Energy [M]. Shanghai : Shanghai Jiao Tong University Press , 2014 .

Cimsit C , Ozturk I T , Kincay O . Thermoeconomic optimization of LiBr/H 2 O-R134a compression-absorption cascade refrigeration cycle [J]. Applied Thermal Engineering , 2015 , 76 : 105 - 115 .

Zegenhagen T , Ziegler F . Experimental investigation of the characteristics of a jet-ejector and a jet-ejector cooling system operating with R134a as a refrigerant [J]. International Journal of Refrigeration , 2015 , 56 : 173 - 185 .

Wang H , Shi X , Che D . Thermodynamic optimization of the operating parameters for a combined power cycle utilizing low-temperature waste heat and LNG cold energy [J]. Applied Thermal Engineering , 2013 , 59 ( 8 ): 490 - 497 .

Aali A , Pourmahmoud N , Zare V . Exergoeconomic analysis and multi-objective optimization of a novel combined flash-binary cycle for Sabalan geothermal power plant in Iran [J]. Energy Conversion & Management , 2017 , 143 ( 57 ): 377 - 390 .

Zhao Y , Wang J . Exergoeconomic analysis and optimization of a flash-binary geothermal power system [J]. Applied Energy , 2016 , 179 ( 46 ): 159 - 170 .

Wang J , Wang J , Dai Y , et al . Thermodynamic analysis and optimization of a flash-binary geothermal power generation system [J]. Geothermics , 2015 , 55 ( 10 ): 69 - 77 .

Bassyouni M , Hasan S W U , Abdelaziz M H , et al . Date palm waste gasification in downdraft gasifier and simulation using ASPEN HYSYS [J]. Energy Conversion & Management , 2014 , 88 ( 7 ): 693 - 699 .

Sunny A , Solomon P A , Aparna K . Syngas production from re-gasified liquefied natural gas and its simulation using Aspen HYSYS [J]. Journal of Natural Gas Science & Engineering , 2016 , 30 ( 2 ): 176 - 181 .

Zhang N , Lior N , Liu M , et al . COOLCEP (cool clean efficient power): a novel CO 2 -capturing oxy-fuel power system with LNG (liquefied natural gas) coldness energy utilization [J]. Energy , 2010 , 35 ( 2 ): 1200 - 1210 .

Wang J , Wang J , Dai Y , et al . Thermodynamic analysis and optimization of a flash-binary geothermal power generation system [J]. Geothermics , 2015 , 55 ( 3 ): 69 - 77 .

Shah N M , Rangaiah G P , Hoadley A F A . Multi-objective optimization of multi-stage gas-phase refrigeration systems [M]// Multi-Objective Optimization: Techniques and Applications in Chemical Engineering (With CD-ROM) . World Scientific , 2009 : 237 - 276 .

Song R , Cui M , Liu J . Single and multiple objective optimization of a natural gas liquefaction process [J]. Energy , 2017 , 124 ( 4 ): 19 - 28 .

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

一种发电和天然气再液化相结合的LNG冷能利用系统

天然气液化工艺发展的新趋势——关键技术问题与案例分析

基于双混合工质深冷的氢液化工艺优化与分析

沼气超临界压力低温脱碳-液化耦合流程研究

基于余热利用的活化MDEA法脱除CO2的天然气液化系统

一种天然气液化和CO2捕集相结合的余热回收发电系统

A waste heat recovery power generation system combined with natural gas liquefaction and CO2 capture

DOI：10.11949/j.issn.0438-1157.20180567

摘要

Abstract

关键词

Keywords

references

一种天然气液化和CO₂捕集相结合的余热回收发电系统

A waste heat recovery power generation system combined with natural gas liquefaction and CO₂ capture