基于DOC+SCR的船用柴油机尾气污染物脱除实验

汪宗御; 邝海浪; 张继锋; 纪玉龙

doi:10.11949/j.issn.0438-1157.20171600

您当前的位置：

首页 >

文章列表页 >

基于DOC+SCR的船用柴油机尾气污染物脱除实验

能源和环境工程 | 更新时间：2025-12-10

- 基于DOC+SCR的船用柴油机尾气污染物脱除实验
- Removal of marine diesel engine exhaust pollutants with DOC+SCR technologies
- 化工学报 2018年第7期页码：3249-3256
- 作者机构：
  
  大连海事大学轮机工程学院,辽宁,大连,116026
- 作者简介：
- 基金信息：
- DOI：10.11949/j.issn.0438-1157.20171600
  中图分类号： 511
- 网络首发：2018-07-05，
  
  纸质出版：2018-07-05
- 稿件说明：
移动端阅览
汪宗御, 邝海浪, 张继锋, 等. 基于DOC+SCR的船用柴油机尾气污染物脱除实验[J]. 化工学报, 2018,(7):3249-3256.

WANG Zongyu, KUANG Hailang, ZHANG Jifeng, et al. Removal of marine diesel engine exhaust pollutants with DOC+SCR technologies[J]. CIESC Journal, 2018, (7): 3249-3256.
汪宗御, 邝海浪, 张继锋, 等. 基于DOC+SCR的船用柴油机尾气污染物脱除实验[J]. 化工学报, 2018,(7):3249-3256. DOI： 10.11949/j.issn.0438-1157.20171600.

WANG Zongyu, KUANG Hailang, ZHANG Jifeng, et al. Removal of marine diesel engine exhaust pollutants with DOC+SCR technologies[J]. CIESC Journal, 2018, (7): 3249-3256. DOI： 10.11949/j.issn.0438-1157.20171600.

摘要

在发电柴油机台架上，通过SMG 100颗粒分析仪、Testo 350烟气分析仪等设备测试了加装DOC和SCR后柴油机在额定转速时6个工况点的排放特性，分析了DOC对CO、NOx和PM的影响，以及不同功率和喷氨量时SCR的脱硝率。结果表明，温度对DOC影响很大，当温度高于250℃，CO的脱除率在96%以上。在中低负荷时，DOC对PM的质量浓度脱除率在76%以上，但在满负荷时，由于柴油机燃烧快速恶化，PM浓度快速增大，此时的PM脱除率仅为36%。DOC能将NO转化为NO2，但对NOx的总浓度几乎不产生影响。SCR受温度和氨氮比的影响比较大，当温度高于250℃，氨氮比为1时，脱硝率几乎达到100%。通过与多篇文献的对比分析，采用功率与催化剂体积之比作为钒基SCR的初期选型参数可能更加合适。

Abstract

The emission characteristics of DOC and SCR were tested by SMG 100 particle analyzer and Testo 350 flue gas analyzer on a diesel generator bench. Six working points were tested at rated speed. The effects of DOC on CO

NOx and PM were analyzed. The denitrification rates of SCR at different power points and urea injection were investigated. The results showed that DOC was greatly affected by temperature. CO removal rate was above 96% when the temperature was higher than 250℃. PM removal rate was above 76% at low or medium load. However

the PM removal rate was only 36% at full load because the PM concentration increased rapidly due to the rapid deterioration of diesel combustion. DOC could convert NO to NO2

but it had little effect on the total concentration of NOx. The denitrification rate of SCR was closely related to temperature and NH3/NOx ratio. It was almost 100% when the temperature was higher than 250℃ and NH3/NOx=1. Through the comparison with many articles

it may be more appropriate to use power/catalyst volume as the initial selection parameter for the vanadium-based SCR.

关键词

Keywords

references

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

SCR脱硝中催化剂表面NH4HSO4生成及分解的原位红外研究

催化裂化再生过程脱硝技术

溶胶-凝胶原位合成宽活性温度V2O5/TiO2脱硝催化剂

高Si掺杂RuO2材料的晶体结构、电子结构和导电性

臭氧氧化脱硝技术研究进展