小管径-粒径比颗粒无序堆积通道内壁面效应数值研究

胡映学; 周浪; 杨剑; 王秋旺

doi:10.11949/j.issn.0438-1157.20170513

您当前的位置：

首页 >

文章列表页 >

小管径-粒径比颗粒无序堆积通道内壁面效应数值研究

流体力学与传递现象 | 更新时间：2025-12-10

- 小管径-粒径比颗粒无序堆积通道内壁面效应数值研究
- Numerical simulation of wall effect in randomly packed bed with low tube to particle diameter ratio
- 化工学报 2017年第S1期页码：54-59
- 作者机构：
  
  西安交通大学热流科学与工程教育部重点实验室,陕西,西安,710049
- 作者简介：
- 基金信息：
- DOI：10.11949/j.issn.0438-1157.20170513
  中图分类号： K124
- 网络首发：2017-08-31，
  
  纸质出版：2017-08-31
- 稿件说明：
移动端阅览
胡映学, 周浪, 杨剑, 等. 小管径-粒径比颗粒无序堆积通道内壁面效应数值研究[J]. 化工学报, 2017,(S1):54-59.

HU Yingxue, ZHOU Lang, YANG Jian, et al. Numerical simulation of wall effect in randomly packed bed with low tube to particle diameter ratio[J]. CIESC Journal, 2017, (S1): 54-59.
胡映学, 周浪, 杨剑, 等. 小管径-粒径比颗粒无序堆积通道内壁面效应数值研究[J]. 化工学报, 2017,(S1):54-59. DOI： 10.11949/j.issn.0438-1157.20170513.

HU Yingxue, ZHOU Lang, YANG Jian, et al. Numerical simulation of wall effect in randomly packed bed with low tube to particle diameter ratio[J]. CIESC Journal, 2017, (S1): 54-59. DOI： 10.11949/j.issn.0438-1157.20170513.

摘要

采用DEM-CFD方法对小管径-粒径比颗粒无序堆积通道内壁面效应进行了数值研究。针对D/dp=5.0圆球无序堆积通道构建了光滑壁面和波节壁面两种通道壁面结构，分析了不同壁面结构堆积通道内孔隙率分布、流动和温度场分布及其流动换热性能。结果表明：小管径-粒径比光滑壁面颗粒无序堆积通道内壁面效应显著，壁面附近平均流速明显高于堆积中心区域，而平均温度要低于堆积中心区域，壁面附近0.5dp区域内通过的流体质量流量比例为46%；波节壁面结构抑制了通道壁面附近漏流，可小幅提高堆积通道的换热能力，但堆积通道内的流动阻力也随之增大，其综合换热性能较光滑壁面堆积通道有所下降。

Abstract

The wall effect in randomly packed bed with low tube to particle ratio is numerically investigated by coupling discrete element method (DEM) and computational fluid dynamics (CFD). The porosity

characteristics of fluid flow and heat transfer in randomly packed beds are carefully studied

including smooth tube wall model and corrugated tube wall model. Simulation results show that

the wall effect in smooth wall packing with low tube to particle diameter ratio is remarkable. The average velocity of the near tube wall region is higher than inner region

while the average temperature of this region is lower. Besides

the mass flow rate in the range of 0.5dp near the tube wall is about 46% of the total flow. With corrugated structure

the leakage near the tube wall is suppressed and the mass flow rate decreases to 36%. The heat transfer characteristics and drag coefficient have a slight increase

while the overall heat transfer coefficient is lower than smooth tube wall model.

关键词

Keywords

references

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

翼型印刷电路板式换热器流动传热特性数值研究

冷却条件下倾斜上升管S-CO2流动与传热特性研究

基于响应面法的矿用翅片管空冷器参数优化

超临界二氧化碳用印刷电路板式换热器性能分析

机械搅拌对原油储罐射流加热过程传热特性的影响规律研究