粒数衡算与多相流耦合求解刮削制冰的晶粒特性

贾雪迎; 梁坤峰; 李盈盈; 袁争印; 阮春蕾; 王林; 董彬; 芮胜军; 李健

doi:10.11949/j.issn.0438-1157.20161399

您当前的位置：

首页 >

文章列表页 >

粒数衡算与多相流耦合求解刮削制冰的晶粒特性

流体力学与传递现象 | 更新时间：2025-11-26

- 粒数衡算与多相流耦合求解刮削制冰的晶粒特性
- Crystallization simulation of scraped surface freezer based on coupling model of population balance and multiphase flow
- 化工学报 2016年第S2期页码：128-135
- 作者机构：
  
  1. 河南科技大学制冷与空调技术研究所,河南,洛阳,471003
  2. 河南科技大学数学与统计学院,河南,洛阳,471003
  3. 河南科技大学土木学院,河南,洛阳,471003
- 作者简介：
- 基金信息：
- DOI：10.11949/j.issn.0438-1157.20161399
  中图分类号： K125
- 网络首发：2016-12-30，
  
  纸质出版：2016-12-30
- 稿件说明：
移动端阅览
贾雪迎, 梁坤峰, 李盈盈, 等. 粒数衡算与多相流耦合求解刮削制冰的晶粒特性[J]. 化工学报, 2016,(S2):128-135.

JIA Xueying, LIANG Kunfeng, LI Yingying, et al. Crystallization simulation of scraped surface freezer based on coupling model of population balance and multiphase flow[J]. CIESC Journal, 2016, (S2): 128-135.
贾雪迎, 梁坤峰, 李盈盈, 等. 粒数衡算与多相流耦合求解刮削制冰的晶粒特性[J]. 化工学报, 2016,(S2):128-135. DOI： 10.11949/j.issn.0438-1157.20161399.

JIA Xueying, LIANG Kunfeng, LI Yingying, et al. Crystallization simulation of scraped surface freezer based on coupling model of population balance and multiphase flow[J]. CIESC Journal, 2016, (S2): 128-135. DOI： 10.11949/j.issn.0438-1157.20161399.

摘要

在考虑晶粒成核、生长、聚并和破碎的情况下，采用分组法求解粒数衡算方程，通过耦合粒数衡算与多相流方程，建立了多尺度的结晶模型，模拟了表面刮削式制冰装置内水的动态结晶过程，获得不同温度、刮削速度、制冰时间等外界条件下晶粒数密度分布、云图等信息，分析了外界宏观条件对水的动态结晶过程的影响。结果表明：由于碰撞引起的晶粒聚并和破碎使得晶粒的尺寸分布更为集中和均匀；在过冷温差（流体局部温度与水的相变温度差值）不大于20℃，刮削速度不大于10 r·s-1范围内，降低壁面温度、增加刮削速度可以加速水的结晶与生长。

Abstract

By discretizing the population equation into different size groups

a method was established for solving the population balance equation coupled with multiphase flow field.A computational fluid dynamics simulation with population balance model was performed for the scraped surface freezer.The algorithm considering nucleation rate

growth rate

crystal aggregation and breakage was used for describing the water dynamic ice-making crystallization process.By using this model

the key role of crystal aggregation and breakage was reappraised

and the ice crystals number density distributions were obtained in the scraped surface freezer.Then the influence of temperature

scraping speed and the crystallization time on the dynamic crystallization process of the water was studied.The results show that the crystal size distribution would be more centralized and uniform with the crystals aggregation and breakage; if the supercold temperature difference is less than 20℃ and the scraping speed is not more than 10 r·s-1

the crystallization process would be accelerated by reducing the wall temperature or increasing the scraping speed.

关键词

Keywords

references

浏览量

163

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

基于自驱射流装置的强化池沸腾换热研究

多孔二氧化钛强化的相变材料储热机理研究

不同冷凝段温度下液氮脉动热管可视化实验研究

微间隙内R134a空化可视化实验研究

气氛和化学组成对高铁煤灰熔融特性的影响机理