小曲率蛇形微通道弯头处弹状流流动及传质特性的数值研究

周云龙; 常赫

doi:10.11949/j.issn.0438-1157.20161283

您当前的位置：

首页 >

文章列表页 >

小曲率蛇形微通道弯头处弹状流流动及传质特性的数值研究

流体力学与传递现象 | 更新时间：2025-11-26

- 小曲率蛇形微通道弯头处弹状流流动及传质特性的数值研究
- Numerical simulation on gas-liquid flow and mass transfer in curve part of serpentine micro-channel with small curvature
- 化工学报 2017年第1期页码：97-103
- 作者机构：
  
  东北电力大学能源与动力工程学院,吉林市,吉林省,132012
- 作者简介：
- 基金信息：
- DOI：10.11949/j.issn.0438-1157.20161283
  中图分类号： Q021.1
- 网络首发：2017-01-05，
  
  纸质出版：2017-01-05
- 稿件说明：
移动端阅览
周云龙, 常赫. 小曲率蛇形微通道弯头处弹状流流动及传质特性的数值研究[J]. 化工学报, 2017,(1):97-103.

ZHOU Yunlong, CHANG He. Numerical simulation on gas-liquid flow and mass transfer in curve part of serpentine micro-channel with small curvature[J]. CIESC Journal, 2017, (1): 97-103.
周云龙, 常赫. 小曲率蛇形微通道弯头处弹状流流动及传质特性的数值研究[J]. 化工学报, 2017,(1):97-103. DOI： 10.11949/j.issn.0438-1157.20161283.

ZHOU Yunlong, CHANG He. Numerical simulation on gas-liquid flow and mass transfer in curve part of serpentine micro-channel with small curvature[J]. CIESC Journal, 2017, (1): 97-103. DOI： 10.11949/j.issn.0438-1157.20161283.

摘要

采用CLSVOF（coupled level set and volume of fluid）方法，以空气和水为工作流体对小曲率矩形截面蛇形微通道内气液两相流动进行模拟研究。验证模型的合理性后，研究了曲率对弯通道内压降的影响，曲率及气相速度对弹状流气泡及液塞长度的综合影响；同时深入分析了弯管内气液两相流动的传质特性，包括不同曲率下气泡长度的变化，弯管内液侧体积传质系数与液膜体积传质系数的比较，曲率及气相速度对液相体积传质系数的影响。同时，对比了回转弯道与直微通道传质系数的差异，发现弯微通道可以强化传质。

Abstract

A numerical analysis of flow pattern in a serpentine microchannel with small curvature and rectangular cross-section was made using the CLSVOF(coupled level set and volume of fluid method) multiphase model.The gas and water were used as working fluids.After verifying the rationality of the model with the experiment

the effect of curvature on the pressure drop in curved microchannel was studied

the combined influence of curvature and gas velocity on bubble and liquid slug length were investigated.At the same time

the mass transfer characteristics of gas-liquid two-phase flow in curve microchannel were analyzed deeply

including the change of bubble length under different curvature

and comparison of liquid volumetric mass transfer coefficient and mass transfer coefficient of liquid film in curve microchannel.Also

effect of curvature and gas phase velocity on liquid phase volumetric mass transfer coefficient was observed.Meanwhile

the difference of mass transfer coefficient between the curve and straight microchannel was compared

which leaded to a conclusion that the curve micro-channel can enhance the mass transfer.

关键词

Keywords

references

浏览量

227

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

微重力条件下低温贮箱加注-保持-排气式预冷特性研究

非对称锯齿型微通道结构流动沸腾传热的模拟研究

加氢站液氢泄漏扩散特性与安全监测数值模拟研究

基于一维漂移流模型的低温管路预冷过程两相流动与换热特性研究

负过载下多孔隔板对液氧贮箱蓄液性能的影响研究