微通道内单乙醇胺水溶液吸收CO<sub>2</sub>/N<sub>2</sub>混合气的传质特性

姜山; 朱春英; 张璠玢; 马友光

doi:10.11949/j.issn.0438-1157.20160902

您当前的位置：

首页 >

文章列表页 >

微通道内单乙醇胺水溶液吸收CO₂/N₂混合气的传质特性

流体力学与传递现象 | 更新时间：2025-12-10

- 微通道内单乙醇胺水溶液吸收CO₂/N₂混合气的传质特性
- Mass transfer performance of CO₂/N₂ mixture absorption into monoethanolamine aqueous solution in microchannel
- 化工学报 2017年第2期页码：643-652
- 作者机构：
  
  化学工程联合国家重点实验室, 天津大学化工学院, 天津化学化工协同创新中心,天津,300072
- 作者简介：
- 基金信息：
- DOI：10.11949/j.issn.0438-1157.20160902
  中图分类号： Q021.4
- 网络首发：2017-02-05，
  
  纸质出版：2017-02-05
- 稿件说明：
移动端阅览
姜山, 朱春英, 张璠玢, 等. 微通道内单乙醇胺水溶液吸收CO₂/N₂混合气的传质特性[J]. 化工学报, 2017,(2):643-652. DOI: 10.11949/j.issn.0438-1157.20160902.

JIANG Shan, ZHU Chunying, ZHANG Fanbin, et al. Mass transfer performance of CO₂/N₂ mixture absorption into monoethanolamine aqueous solution in microchannel[J]. CIESC Journal, 2017, (2): 643-652. DOI: 10.11949/j.issn.0438-1157.20160902.
姜山, 朱春英, 张璠玢, 等. 微通道内单乙醇胺水溶液吸收CO₂/N₂混合气的传质特性[J]. 化工学报, 2017,(2):643-652. DOI: 10.11949/j.issn.0438-1157.20160902. DOI：

JIANG Shan, ZHU Chunying, ZHANG Fanbin, et al. Mass transfer performance of CO₂/N₂ mixture absorption into monoethanolamine aqueous solution in microchannel[J]. CIESC Journal, 2017, (2): 643-652. DOI: 10.11949/j.issn.0438-1157.20160902. DOI：

摘要

采用高速摄像仪对400 μm×400 μm T形微通道内单乙醇胺（MEA）水溶液吸收混合气中CO2过程的气液两相流及传质特性进行了实验研究，微通道内的压力降采用压力传感器进行测量。考察了弹状流型下气液两相流量及MEA浓度对压力降、比表面积和传质性能的影响。结果表明，当MEA浓度不变，气液两相流量增大时，压力降、比表面积、传质系数、体积传质系数和增强因子均增大，并逐渐趋于恒定。当气液流量不变，MEA浓度增大时，压力降、传质系数、体积传质系数和增强因子增大，但比表面积减小。实验条件下，压力降范围为2.00~5.23 kPa，化学吸收过程的传质系数范围为7.74×10-4~2.97×10-3 m·s-1。对于伴有快速化学反应的传质过程，以Sherwood数、Reynolds数、Schmidt数及增强因子为变量建立了体积传质系数的预测关联式，平均偏差为5.09%，具有良好的预测性能。

Abstract

A high speed camera was used to investigate the gas-liquid two-phase flow and mass transfer performance of CO2/N2 gas mixture absorption into monoethanolamine (MEA) aqueous solution in a 400 μm×400 μm T-shape microchannel. The pressure drop along the microchannel was determined by a pressure sensor. The effects of the gas and liquid phase flow rates

MEA concentration on the pressure drop

specific surface area and mass transfer performance were investigated experimentally. The results showed that for a given concentration of MEA aqueous solution

the pressure drop

the mass transfer coefficient

the specific interfacial area

the volumetric mass transfer coefficient and the enhancement factor increased gradually up to a constant value with increasing gas phase or liquid phase flow rates. With increasing MEA concentration or the pressure drop

the mass transfer coefficient

the volumetric mass transfer coefficient and the enhancement factor increased

but the specific interfacial area decreased. Under experimental conditions

the range of pressure drop was 2.00 to 5.23 kPa and the mass transfer coefficient of gas-liquid two-phase flow accompanied with chemical absorption was ranged from 7.74×10-4 to 2.97×10-3 m·s-1. A correlation for predicting the volumetric mass transfer coefficient was proposed by taking Sherwood number

Reynolds number

Schmidt number and the enhancement factor into account. The average deviation of the model was 5.09%

indicating a good prediction performance.

关键词

Keywords

references

浏览量

441

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

三维菱形结构微通道内气液传质与强化

微通道内MEA/MDEA混合溶液吸收CO2的传质特性

微通道内离子液体/乙醇混合溶液吸收CO2的传质特性

微通道内伴有化学吸收气液两相流的空隙率与压力降

基于双差压模型的文丘里管气液两相CO2流量测量

微通道内单乙醇胺水溶液吸收CO2/N2混合气的传质特性

Mass transfer performance of CO2/N2 mixture absorption into monoethanolamine aqueous solution in microchannel

DOI：10.11949/j.issn.0438-1157.20160902

摘要

Abstract

关键词

Keywords

references

微通道内单乙醇胺水溶液吸收CO₂/N₂混合气的传质特性

Mass transfer performance of CO₂/N₂ mixture absorption into monoethanolamine aqueous solution in microchannel