SiO<sub>2</sub>固载磺酸功能化离子液体的制备及其催化合成4,4'-二氨基二苯甲烷

安华良; 田金萍; 赵新强; 王延吉

doi:10.11949/j.issn.0438-1157.20150041

您当前的位置：

首页 >

文章列表页 >

SiO₂固载磺酸功能化离子液体的制备及其催化合成4,4'-二氨基二苯甲烷

催化、动力学与反应器 | 更新时间：2025-12-10

- SiO₂固载磺酸功能化离子液体的制备及其催化合成4,4'-二氨基二苯甲烷
- Preparation of silica-immobilized SO₃H-functionalized ionic liquids and its catalytic activity in reaction of 4, 4'-methylenedianiline synthesis
- 化工学报 2015年第S1期页码：171-179
- 作者机构：
  
  河北工业大学化工学院, 绿色化工与高效节能河北省重点实验室,天津,300130
- 作者简介：
- 基金信息：
- DOI：10.11949/j.issn.0438-1157.20150041
  中图分类号： Q246.3
- 网络首发：2015-06-30，
  
  纸质出版：2015-06-30
- 稿件说明：
移动端阅览
安华良, 田金萍, 赵新强, 等. SiO₂固载磺酸功能化离子液体的制备及其催化合成4,4'-二氨基二苯甲烷[J]. 化工学报, 2015,(S1):171-179. DOI: 10.11949/j.issn.0438-1157.20150041.

AN Hualiang, TIAN Jinping, ZHAO Xinqiang, et al. Preparation of silica-immobilized SO₃H-functionalized ionic liquids and its catalytic activity in reaction of 4, 4'-methylenedianiline synthesis[J]. CIESC Journal, 2015, (S1): 171-179. DOI: 10.11949/j.issn.0438-1157.20150041.
安华良, 田金萍, 赵新强, 等. SiO₂固载磺酸功能化离子液体的制备及其催化合成4,4'-二氨基二苯甲烷[J]. 化工学报, 2015,(S1):171-179. DOI: 10.11949/j.issn.0438-1157.20150041. DOI：

AN Hualiang, TIAN Jinping, ZHAO Xinqiang, et al. Preparation of silica-immobilized SO₃H-functionalized ionic liquids and its catalytic activity in reaction of 4, 4'-methylenedianiline synthesis[J]. CIESC Journal, 2015, (S1): 171-179. DOI: 10.11949/j.issn.0438-1157.20150041. DOI：

摘要

采用3种方法成功制备了固载型磺酸功能化离子液体

对其催化苯胺与甲醛缩合制备4

4'-二氨基二苯甲烷(4

4'-MDA)的反应性能进行了评价

并考察了其重复使用性能。结果表明

固载型磺酸功能化离子液体的催化效果与其固载量正相关

SiO2@[HSO3-ppim]CF3SO3-Ⅰ的固载量最高

催化效果最好。以SiO2@[HSO3-ppim]CF3SO3-Ⅰ为催化剂

4'-MDA合成反应适宜的反应条件为:w(cat.)/w(HCHO)=1.5

n(AN)/n(HCHO)=4

反应时间7 h

反应温度80℃。在此条件下

4'-MDA的收率和选择性分别为74.9%和94.5%。通过酸碱滴定法测定酸量和红外谱图分析发现

苯胺与离子液体的酸中心发生化学作用导致回收催化剂活性下降。利用CF3SO3H对回收催化剂进行酸化处理

其活性得以恢复

重复使用4次

催化活性没有明显降低。

Abstract

Immobilized SO3H-functionalized ionic liquids were prepared by three different pathways and their catalytic performance was evaluated in the condensation reaction for the synthesis of 4

4'-methylenedianiline (4

4'-MDA) from aniline and HCHO

and the reusability of the immobilized ionic liquids were investigated. The result showed that ionic liquid loading in the immobilized ionic liquids was consistent with their catalytic activity. Among the immobilized ionic liquids

SiO2@[HSO3-ppim]CF3SO3-Ⅰ with the highest loading showed the best catalytic activity. Then the influence of reaction conditions on the synthesis of 4

4'-MDA was investigated using SiO2@[HSO3-ppim]CF3SO3-Ⅰcatalyst. The suitable reaction conditions were as follows: mass ratio of catalyst to HCHO was 1.5

molar ratio of aniline to HCHO was 4

reaction time of 7 h

and reaction temperature of 80℃. Under the above conditions

the yield and selectivity of 4

4'-MDA were 74.9% and 94.5%

respectively. However

the catalytic activity of the recovered catalyst declined dramatically. The results of acid-base titration and FT-IR spectroscopy analyses showed that there was a chemical interaction between the immobilized ionic liquids and aniline. The deactivated immobilized ionic liquids could be regenerated by acidization with CF3SO3H

and the acidized immobilized ionic liquids could be reused four times with a tolerable loss of its catalytic activity.

关键词

Keywords

references

浏览量

299

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

富氧功能化超交联树脂的合成及其对苯胺的吸附

甲醇-甲醛-聚甲氧基二甲醚三元体系汽液平衡

过硫酸盐强化零价铁还原去除硝基苯的实验研究

蓝宝石衬底上PECVD生长石墨烯及其气敏传感器

LED可见光下Au/TiO2光催化氧化甲醛表观动力学

SiO2固载磺酸功能化离子液体的制备及其催化合成4,4'-二氨基二苯甲烷

Preparation of silica-immobilized SO3H-functionalized ionic liquids and its catalytic activity in reaction of 4, 4'-methylenedianiline synthesis

DOI：10.11949/j.issn.0438-1157.20150041

摘要

Abstract

关键词

Keywords

references

SiO₂固载磺酸功能化离子液体的制备及其催化合成4,4'-二氨基二苯甲烷

Preparation of silica-immobilized SO₃H-functionalized ionic liquids and its catalytic activity in reaction of 4, 4'-methylenedianiline synthesis