Ti/Zr复合纳滤膜的制备及其性能

朱瓌之; 郭红林; 姜迁; 漆虹

doi:10.11949/j.issn.0438-1157.20141645

您当前的位置：

首页 >

文章列表页 >

Ti/Zr复合纳滤膜的制备及其性能

材料化学工程与纳米技术 | 更新时间：2025-12-10

- Ti/Zr复合纳滤膜的制备及其性能
- Fabrication and properties of Ti/Zr composite nanofiltration membrane
- 化工学报 2015年第4期页码：1600-1606
- 作者机构：
  
  南京工业大学膜科学技术研究所, 材料化学工程国家重点实验室,江苏,南京,210009
- 作者简介：
  
  朱瓌之(1988-),男,硕士研究生.
- 基金信息：
- DOI：10.11949/j.issn.0438-1157.20141645
  中图分类号： Q028.5
- 网络首发：2015-04-05，
  
  纸质出版：2015-04-05
- 稿件说明：
移动端阅览
朱瓌之, 郭红林, 姜迁, 等. Ti/Zr复合纳滤膜的制备及其性能[J]. 化工学报, 2015,(4):1600-1606.

ZHU Guizhi, GUO Honglin, JIANG Qian, et al. Fabrication and properties of Ti/Zr composite nanofiltration membrane[J]. CIESC Journal, 2015, (4): 1600-1606.
朱瓌之, 郭红林, 姜迁, 等. Ti/Zr复合纳滤膜的制备及其性能[J]. 化工学报, 2015,(4):1600-1606. DOI： 10.11949/j.issn.0438-1157.20141645.

ZHU Guizhi, GUO Honglin, JIANG Qian, et al. Fabrication and properties of Ti/Zr composite nanofiltration membrane[J]. CIESC Journal, 2015, (4): 1600-1606. DOI： 10.11949/j.issn.0438-1157.20141645.

摘要

通过聚合溶胶路线制备出稳定的Ti/Zr(摩尔比=1:1)复合溶胶。采用浸浆法

在平均孔径为5～6 nm的片状a-Al2O3/g-Al2O3载体上制备出完整无缺陷的Ti/Zr复合纳滤膜。详细考察了焙烧温度对Ti/Zr粉体的影响

并考察了Ti/Zr复合纳滤膜的性能。结果表明:在较高烧成温度下(500℃)

Ti/Zr粉体依然呈无定形态且保持微孔结构。在400℃烧成温度下制备出孔径为1.49 nm的Ti/Zr复合纳滤膜

该膜的截留分子量(MWCO)为880

纯水通量为4.3 L·m-2·h-1·MPa-1。在pH=6

压力0.8 MPa的条件下

该膜对0.005 mol·L-1的MgCl2、CaCl2的截留率分别为85%和78%。

Abstract

A stable Ti/Zr composite polymeric sol with Ti:Zr molar ratio of 1:1 was synthesized through the polymeric sol route. Disk a-Al2O3 supported mesoporous g-Al2O3 membrane with an average pore size of 5-6 nm was used as support for nanofiltration membranes deposition. A defect-free Ti/Zr composite nanofiltration membrane superimposed on the support was fabricated via the dip-coating method followed by drying and calcination. The influence of calcination temperature on Ti/Zr powders was studied. The properties of Ti/Zr composite nanofiltration membrane were also investigated. Ti/Zr powders maintained amorphous state and microporous structure up to a calcination temperature of 500℃. The MWCO

mean pore size and pure water flux of Ti/Zr composite nanofiltration membrane calcined at 400℃ were 880

1.49 nm and 4.3 L·m-2·h-1·MPa-1

respectively. Under the condition of pH=6 and transmembrane pressure 0.8 MPa

the retention properties of Ti/Zr composite membrane towards 0.005 mol·L-1 MgCl2 and CaCl2 solutions were 85% and 78%

respectively.

关键词

Keywords

references

浏览量

271

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

碱式硫酸镁晶须的可控制备及不同离子的影响机制

ZrO2-TiO2复合纳滤膜在模拟放射性废水中的应用

锂离子电池负极材料Li4Ti5O12/C的制备与表征

Pr3+:Y2SiO5/TiO2上转换复合膜光催化性能

超疏水PET织物的制备及其抗菌性能