Yb掺杂CuO构筑氧空位和低价铜活性位点用于高效催化CO₂电还原制多碳产物

陈心昊; 薛文杰; 王辉; 庞昕雅; 白珮金; 梁硕; 刘淑靖; 马晓丽; 张雪菲; 宁汇

doi:10.11949/0438-1157.20260813

您当前的位置：

首页 >

文章列表页 >

Yb掺杂CuO构筑氧空位和低价铜活性位点用于高效催化CO₂电还原制多碳产物

催化、动力学与反应器 | 更新时间：2026-08-17

- Yb掺杂CuO构筑氧空位和低价铜活性位点用于高效催化CO₂电还原制多碳产物
- Construction of Oxygen Vacancies and Low-Valence Copper Active Sites in CuO via Yb Doping for Efficient Electrocatalytic Reduction of CO₂ to Multi-Carbon Products
- 化工学报 2026年
- 作者机构：
  
  1.中国石油大学(华东)化学化工学院，山东青岛 266580
  2.山东亿维新材料有限责任公司山东东营 257000
- 作者简介：
  
  陈心昊（2002—），男，硕士研究生，1506672939@qq.com
  宁汇（1984—），男，博士，副教授，ninghui@upc.edu.cn
- 基金信息：
  
  国家自然科学基金项目(22378428)
- DOI：10.11949/0438-1157.20260813
  中图分类号： O646
- 收稿：2026-06-12，
  
  修回：2026-08-14，
  
  录用：2026-08-17，
- 稿件说明：
移动端阅览
陈心昊, 薛文杰, 王辉, 等. Yb掺杂CuO构筑氧空位和低价铜活性位点用于高效催化CO₂电还原制多碳产物[J/OL]. 化工学报, 2026.

CHEN Xinhao, XUE Wenjie, WANG Hui, et al. Construction of Oxygen Vacancies and Low-Valence Copper Active Sites in CuO via Yb Doping for Efficient Electrocatalytic Reduction of CO₂ to Multi-Carbon Products[J/OL]. CIESC Journal, 2026.
陈心昊, 薛文杰, 王辉, 等. Yb掺杂CuO构筑氧空位和低价铜活性位点用于高效催化CO₂电还原制多碳产物[J/OL]. 化工学报, 2026. DOI： 10.11949/0438-1157.20260813.

CHEN Xinhao, XUE Wenjie, WANG Hui, et al. Construction of Oxygen Vacancies and Low-Valence Copper Active Sites in CuO via Yb Doping for Efficient Electrocatalytic Reduction of CO₂ to Multi-Carbon Products[J/OL]. CIESC Journal, 2026. DOI： 10.11949/0438-1157.20260813.

摘要

CuO作为一种典型的CO₂电还原催化剂，其多碳产物选择性不足极大限制了其工业化应用进程。本文利用Yb掺杂方法构建了Yb/CuO

催化剂，系统研究了其催化CO

电还原生成C

产物的性能及构效关系。研究发现：该催化剂在200 mA/cm

的电流密度下，多碳产物法拉第效率从修饰前的55.8%提升至修饰后的73.8%。X射线光电子能谱及密度泛函理论计算证明Yb

离子的引入造成局部电荷重新分布，使得部分Cu位点电子密度升高、Cu的低价特征增强，并伴随氧空位附近未饱和Cu位点的形成。其中富电子Cu位点有利于增强对CO的吸附与活化，提高表面含碳中间体覆盖度；同时，Yb

的亲氧特征和氧空位附近的电子调控作用能够进一步稳定OCCHO中间体，从而降低C-C偶联相关步骤的自由能，促进多碳产物生成。本研究对稀土元素改性铜基催化剂的设计及CO

高效电还原制多碳产物提供了重要理论基础。

Abstract

CuO

as a typical CO₂ electroreduction catalyst

suffers from insufficient selectivity toward multicarbon products

which greatly limits its industrial application. Herein

a Yb/CuO

catalyst was constructed via Yb doping

and its performance for CO₂ electroreduction to C₂ products as well as the structure–activity relationship were systematically investigated. It was found that the catalyst achieves a Faradaic efficiency for multicarbon products of 73.8% at a current density of 200 mA/cm²

increased from 55.8% before modification. X-ray photoelectron spectroscopy and density function

al theory calculations demonstrate that the introduction of Yb³⁺ ions induces local charge redistribution

leading to increased electron density on some Cu sites

enhanced low-valence character of Cu

and the formation of unsaturated Cu sites near oxygen vacancies. The electron‑rich Cu sites favor the adsorption and activation of CO

thereby increasing the surface coverage of carbon‑containing intermediates. Meanwhile

the oxophilic nature of Yb³⁺ and the electronic modulation near oxygen vacancies further stabilize the OCCHO intermediate

thus lowering the free energy of the C–C coupling steps and promoting the generation of multicarbon products. This study provides an important theoretical basis for the design of rare‑earth‑modified copper‑based catalysts and for the efficient electroreduction of CO₂ to multicarbon products

关键词

Keywords

references

Wakerley D , Lamaison S , Wicks J , et al . Gas diffusion electrodes, reactor designs and key metrics of low-temperature CO 2 electrolysers [J ] . Nature Energy , 2022 , 7 ( 2 ): 130 - 143 .

Ahmad T , Liu S , Sajid M , et al . Electrochemical CO 2 reduction to C 2+ products using Cu-based electrocatalysts: a review [J ] . Nano Research Energy , 2022 , 1 : e9120021 .

Qu J P , Cao X J , Gao L , et al . Electrochemical carbon dioxide reduction to ethylene: from mechanistic understanding to catalyst surface engineering [J ] . Nano-Micro Letters , 2023 , 15 ( 1 ): 178 .

Qi Z , Biener M M , Kashi A R , et al . Electrochemical CO 2 to CO reduction at high current densities using a nanoporous gold catalyst [J ] . Materials Research Letters , 2021 , 9 ( 2 ): 99 - 104 .

Liu W , Zhai P B , Li A W , et al . Electrochemical CO 2 reduction to ethylene by ultrathin CuO nanoplate arrays [J ] . Nature Communications , 2022 , 13 : 1877 .

Zhang H , Gao J X , Raciti D , et al . Promoting Cu-catalysed CO 2 electroreduction to multicarbon products by tuning the activity of H 2 O [J ] . Nature Catalysis , 2023 , 6 ( 9 ): 807 - 817 .

Ji D G , Yang Z , Yao Y X , et al . Rare-earth Y–O skeleton-mediated stabilization of Cu 2+ for efficient CO 2 electroreduction to CH 4 [J ] . Small , 2025 , 21 ( 27 ): 2503169 .

张琦钰 , 高利军 , 苏宇航 , 等 . 碳基催化材料在电化学还原二氧化碳中的研究进展 [J ] . 化工学报 , 2023 , 47 ( 7 ): 2753 - 2772 .

刘旭升 , 李泽洋 , 杨宇森 , 等 . 电催化二氧化碳还原制备气态产物的研究进展 [J ] . 化工学报 , 2024 , 75 ( 7 ): 2385 - 2408 .

Yan X , Wang S , Chen Z L , et al . Construction of coherent interface between Cu 2 O and CeO 2 via electrochemical recon struction for efficient carbon dioxide reduction to methane [J ] . Journal of Colloid and Interface Science , 2024 , 673 : 60 - 69 .

Casebolt DiDomenico R , Levine K , Reimanis L , et al . Mechanistic insights into the formation of CO and C 2 products in electrochemical CO 2 Reduction─The role of sequential charge transfer and chemical reactions [J ] . ACS Catalysis , 2023 , 13 ( 7 ): 4938 - 4948 .

He X Y , Lin L , Li X Y , et al . Roles of copper(I) in water-promoted CO 2 electrolysis to multi-carbon compounds [J ] . Nature Communications , 2024 , 15 : 9923 .

Lei Q , Huang L , Yin J , et al . Structural evolution and strain generation of derived-Cu catalysts during CO 2 electroreduction [J ] . Nature Communications , 2022 , 13 : 4857 .

Amirbeigiarab R , Tian J , Herzog A , et al . Atomic-scale surface restructuring of copper electrodes under CO 2 electroreduction conditions [J ] . Nature Catalysis , 2023 , 6 ( 9 ): 837 - 846 .

Yang Y , Louisia S , Yu S , et al . Operando studies reveal active Cu nanograins for CO 2 electroreduction [J ] . Nature , 2023 , 614 ( 7947 ): 262 - 269 .

Lian Z , Dattila F , López N . Stability and lifetime of diffusion-trapped oxygen in oxide-derived copper CO 2 reduction electrocatalysts [J ] . Nature Catalysis , 2024 , 7 ( 4 ): 401 - 411 .

Yao K L , Li J , Ozden A , et al . In situ copper faceting enables efficient CO 2 /CO electrolysis [J ] . Nature Communications , 2024 , 15 : 1749 .

Li H B , Jiang Y L , Li X Y , et al . C 2+ selectivity for CO 2 electroreduction on oxidized Cu-based catalysts [J ] . Journal of the American Chemical Society , 2023 , 145 ( 26 ): 14335 - 14344 .

Jiang Y Q , Choi C , Hong S , et al . Enhanced electrochemical CO 2 reduction to ethylene over CuO by synergistically tuning oxygen vacancies and metal doping [J ] . Cell Reports Physical Science , 2021 , 2 ( 3 ): 100356 .

Li P S , Bi J H , Liu J Y , et al . P–d Orbital Hybridization Induced by p-Block Metal-Doped Cu Promotes the Formation of C 2+ Products in Ampere-Level CO 2 Electroreduction [J ] . Journal of the American Chemical Society , 2023 , 145 ( 8 ): 4675 - 4682 .

Cheng L , Wang R , Si W Z , et al . Enhancing CO 2 electroreduction performance through Si-doped CuO: stabilization of Cu + /Cu 0 sites and improved C 2 product selectivity [J ] . ACS Catalysis , 2024 , 14 ( 13 ): 10324 - 10333 .

Wu X , Tong Z , Liu Y L , et al . Modification of the CuO electronic structure for enhanced selective electrochemical CO 2 reduction to ethylene [J ] . Nano Research , 2024 , 17 ( 8 ): 7194 - 7202 .

Yan X P , Chen C J , Wu Y H , et al . Efficient electroreduction of CO 2 to C 2+ products on CeO 2 modified CuO [J ] . Chemical Science , 2021 , 12 ( 19 ): 6638 - 6645 .

Feng J Q , Wu L M , Song X N , et al . CO 2 electrolysis to multi- carbon products in strong acid at ampere-current levels on La-Cu spheres with channels [J ] . Nature Communications , 2024 , 15 : 4821 .

Feng J Q , Wu L M , Liu S J , et al . Improving CO 2 -to-C 2+ product electroreduction efficiency via atomic lanthanide dopant-induced tensile-strained CuO x catalysts [J ] . Journal of the American Chemical Society , 2023 , 145 ( 17 ): 9857 - 9866 .

Liu X , Liu T , Ouyang T , et al . Ce 3+ /Ce 4+ ion redox shuttle stabilized Cu δ+ for efficient CO 2 electroreduction to C 2 H 4 [J ] . Angewandte Chemie International Edition , 2025 , 64 ( 7 ): e202419796 .

Chu S L , Kang C , Park W , et al . Single atom and defect engineering of CuO for efficient electrochemical reduction of CO 2 to C 2 H 4 [J ] . SmartMat , 2022 , 3 ( 1 ): 194 - 205 .

Yang X F , Lai C , Li L , et al . Oxygen vacancy assisted Mn-CuO Fenton-like oxidation of ciprofloxacin: Performance, effects of pH and mechanism [J ] . Separation and Purification Technology , 2022 , 287 : 120517 .

Zhong X H , Liang S J , Yang T T , et al . Sn dopants with synergistic oxygen vacancies boost CO 2 electroreduction on CuO nanosheets to CO at low overpotential [J ] . ACS Nano , 2022 , 16 ( 11 ): 19210 - 19219 .

Ferdous Anik M J , Mim S R , Swapno S S , et al . Vacancy induced enhanced photocatalytic activity of nitrogen doped CuO NPs synthesized by co-precipitation method [J ] . Heliyon , 2024 , 10 ( 6 ): e27613 .

Cheng B , Shu M X , Chi B Z , et al . Enhancing electroreduction CO 2 to multi-carbon products by the synergistical effect of controllable pore size and local microenvironment on Y@CuO x catalysts [J ] . Chemical Engineering Journal , 2025 , 515 : 163571 .

Li R , Yin H , Jing W K , et al . Cu 2 O/lanthanide hydroxide boosting electrocatalytic CO 2 reduction via stabil izing Cu(I) [J ] . Science China Chemistry , 2025 , 68 ( 12 ): 6533 - 6540 .

Tian Y M , Fei X , Ning H , et al . Membrane-free electrocatalysis of CO 2 to C2 on CuO/CeO 2 nanocomposites [J ] . Frontiers in Chemistry , 2022 , 10 : 915759 .

Zhao Z Y , Li X T , Wang J H , et al . CeO 2 -modified Cu electrode for efficient CO 2 electroreduction to multi-carbon products [J ] . Journal of CO2 Utilization , 2021 , 54 : 101741 .

Feng A , Fang N , Yuan X T , et al . Yb-doped Cu-based catalyst boosting electrochemical CO 2 -to-C 2+ reduction across pH range at ampere-level current density [J ] . Angewandte Chemie International Edition , 2026 , 65 ( 8 ): e10755 .

Zhang X Y , Lou Z X , Chen J C , et al . Direct OC-CHO coupling towards highly C 2+ products selective electroreduction over stable Cu0/Cu 2+ interface [J ] . Nature Communications , 2023 , 14 : 7681 .

Yan J , Ni J Q , Sun H L , et al . Progress in tracking electrochemical CO 2 reduction intermediates over single-atom catalysts using operando ATR-SEIRAS [J ] . Chinese Journal of Catalysis , 2024 , 62 : 32 - 52 .

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

通用AI对化工AGI的启示：数据-算力-工具-机理协同体系构建

沸石择形作用原子尺度原位电镜研究进展

面向多组分混合物一步纯化乙烯的吸附分离材料研究进展

分级胺改性MOF-74的CO2吸附性能及机理研究

人工智能赋能酶工程