高效大冷量液氦温区GM制冷机研究

周志坡; 木松松; 李奥; 屈方杰; 何韩军; 陶杰; 董文庆

doi:10.11949/0438-1157.20260239

您当前的位置：

首页 >

文章列表页 >

高效大冷量液氦温区GM制冷机研究

更新时间：2026-06-03

- 高效大冷量液氦温区GM制冷机研究
- Research on high-efficiency and large-capacity liquid helium temperature range GM cryocooler
- 化工学报 2026年页码：1-9
- 作者机构：
  
  1.中船鹏力（南京）超低温技术有限公司，江苏南京 211106
  2.江苏省超低温技术及应用重点实验室，江苏南京 211106
- 作者简介：
  
  周志坡（1991—），男，硕士研究生，高级工程师，zhouzhipozzu@163.com
  李奥（1981—），男，博士，研究员，liao@724pride.com
- 基金信息：
  
  国家重点研发计划项目(2023YFF0721300;2023YFF0713502)
- DOI：10.11949/0438-1157.20260239
  中图分类号： TB 651
- 收稿：2026-02-23，
  
  修回：2026-05-27，
  
  网络首发：2026-06-03，
- 稿件说明：
移动端阅览
周志坡, 木松松, 李奥, 屈方杰, 何韩军, 陶杰, 董文庆. 高效大冷量液氦温区GM制冷机研究[J]. 化工学报,

ZHOU Zhipo, MU Songsong, LI Ao, QU Fangjie, HE Hanjun, TAO Jie, DONG Wenqing. Research on high-efficiency and large-capacity liquid helium temperature range GM cryocooler[J]. CIESC Journal,
周志坡, 木松松, 李奥, 屈方杰, 何韩军, 陶杰, 董文庆. 高效大冷量液氦温区GM制冷机研究[J]. 化工学报, DOI： 10.11949/0438-1157.20260239

ZHOU Zhipo, MU Songsong, LI Ao, QU Fangjie, HE Hanjun, TAO Jie, DONG Wenqing. Research on high-efficiency and large-capacity liquid helium temperature range GM cryocooler[J]. CIESC Journal, DOI： 10.11949/0438-1157.20260239

摘要

GM制冷机由于结构简单、运行可靠、高性价比等优点，在低温超导磁体、高端科学仪器等领域得到了广泛的应用，然而目前的制冷量已难以满足不断增长的低温环境使用需求。采用数值模拟与实验相结合的研究方法，系统研究了影响制冷机性能的关键因素。数值模拟结果显示，当冷端质量流由22g/s增至40g/s时，制冷量从4W增至7.3W，近似线性增长；当压力从1.35MPa增至1.75MPa（29.7%）时，制冷量仅增大7%，成弱相关性。实验结果表明充气压力越高，系统降温速率越快，充气压力从1.45 MPa增至1.65 MPa，降温速率由5.38 K/min增至6.58 K/min。该制冷机在流量分别为69Nm

/h和130Nm

/h下，在4.2K分别可以获得3.1W和5.4W制冷量，对应功耗分别为5.5kW和9.9 kW。最后研究了“一拖二”工况下不同充气压力下制冷机的性能，结果表明功耗8kW时，制冷量为6.1W@4.2K，功耗9.5kW时，制冷量为6.5W@4.2K。

Abstract

GM cryocoolers have been widely used in fields such as low-temperature superconducting magnets and advanced scientific instruments due to their simple structure

reliable operation

and high cost-effectiveness. However

the current cooling capacity is unable to meet the growing demand for low-temperature environments. Therefore

the key factors affecting the performance of the cryocoolers were systematically studied using a combination of numerical simulation and experiments. The numerical simulation results show that when the mass flow rate at the cold-head increases from 22 g/s to 40 g/s

the cooling capacity increases from 4 W to 7.3 W

exhibiting an approximately linear increase. In contrast

when the pressure increases from 1.35 MPa to 1.75 MPa (a 29.7% increase)

the cooling capacity only increases by 7%

indicating a weak dependence. The experimental results indicate that the higher the charging pressure

the faster the system's cooling rate. When the charging pressure increases from 1.45 MPa to 1.65 MPa

the cooling rate increases from 5.38 K/min to 6.58 K/min. At 4.2K

this cryocooler provides 3.1 W and 5.4 W of cooling capacity at flow rates o

f 69 Nm

/h and 130 Nm

/h respectively

with corresponding power consumption is 5.5 kW and 9.9 kW. Finally

the performance of the cryocoolers under the condition of one compressor driving two cold heads with different charging pressures was studied. The results show that when the power consumption is 8 kW

the cooling capacity at 4.2 K is 6.1W; when the power consumption is 9.5 kW

the cooling capacity at 4.2 K is 6.5W.

关键词

Keywords

references

Radenbaugh R . Refrigeration for superconductors [J ] . Proceedings of the IEEE , 2004 , 92 ( 10 ): 1719 - 1734 .

Ackermann R A , Herd K G , Chen W E . Advanced cryocooler cooling for MRI systems [M ] // Cryocoolers 10 . Boston, MA : Springer US , 2002 : 857 - 867 .

Gandla S K , Dunn S , Longsworth R C , et al . Development of high-capacity GM cryocoolers and circulating cooling systems for HTS applications [J ] . Cryogenics , 2025 , 147 : 104046 .

刘士苋 , 王磊 , 王路忠 , 等 . 电动悬浮列车及车载超导磁体研究综述 [J ] . 西南交通大学学报 , 2023 , 58 ( 4 ): 734 - 753 .

Liu S X , Wang L , Wang L Z , et al . Review on electrodynamic suspension trains and on-board superconducting magnets [J ] . Journal of Southwest Jiaotong University , 2023 , 58 ( 4 ): 734 - 753 .

McMahon H O , Gifford W E . A new low-temperature gas expansion cycle, Part 1 [M ] // Advances in Cryogenic Engineering . Boston, MA : Springer US , 1960 : 354 - 367 .

Gifford W E , McMahon H O . A new low-temperature gas expansion cycle, Part 2 [M ] // Advances in Cryogenic Engineering . Boston, MA : Springer US , 1960 : 368 - 372 .

Kuriyama T , Takahashi M , Nakagome H , et al . Helium liquefaction by a two-stage Gifford-McMahon-cycle refrigerator using new regenerator material of Er3Ni [J ] . Japanese Journal of Applied Physics , 1992 , 31 ( 8B ): L1206 .

Wu A B , Ricci J , Conte G , et al . Design and construction of a low-cryogen, lightweight, head-only 7T MRI magnet [J ] . IEEE Transactions on Applied Superconductivity , 2024 , 34 ( 5 ): 4402205 .

Masuyama S , Fukuda Y , Imazu T , et al . Characteristics of a 4K Gifford–McMahon cryocooler using the Gd2O2S regenerator material [J ] . Cryogenics , 2011 , 51 ( 6 ): 337 - 340 .

Hao X H , Yao S H , Schilling T . Design and experimental investigation of the high efficiency 1.5W/4.2K pneumatic-drive G-M cryocooler [J ] . Cryogenics , 2015 , 70 : 28 - 33 .

Xu M Y , Morie T . Numerical simulation and experimental investigation of a novel Scotch yoke for a Gifford-McMahon cryocooler [J ] . IOP Conference Series: Materials Science and Engineering , 2015 , 101 ( 1 ): 012134 .

Masuyama S , Numazawa T . Characteristics of a 1.6 W Gifford-McMahon cryocooler with a double pipe regenerator [J ] . IOP Conference Series: Materials Science and Engineering , 2017 , 278 ( 1 ): 012041 .

Takashi I , Masashi N , Kouki N , et al . Development of 2W class 4K Gifford-McMahon cycle cryocooler [M ] // Proceedings of the Sixteenth International Cryogenic Engineering Conference/International Cryogenic Materials Conference . Amsterdam : Elsevier , 1997 : 335 - 338 .

Inaguchi T , Nagao M , Naka K , et al . Effects of thermal conductance in the cooling stage of a 4K-GM refrigerator on refrigeration capacity [M ] // Advances in Cryogenic Engineering . Boston, MA : Springer US , 1998 : 1807 - 1814 .

Ohtani Y , Hatakeyama H , Nakagome H , et al . Development of a high efficiency 4K GM refrigerator [M ] // Cryocoolers 10 . Boston, MA : Springer US , 2002 : 581 - 586 .

Usami T , Okamura T , Kabashima S , et al . Analysis of a high efficiency 4K GM refrigerator operating at a lower pressure ratio [M ] // Cryocoolers 10 . Boston, MA : Springer US , 2002 : 587 - 592 .

Lei T , Dunn S , Gronemeyer B , et al . SHI's two-stage 4K GM cryocoolers: enriching emerging technologies through leading-edge advancements [C ] // International Cryocooler Conference . 2022 : 219 - 226 .

Wu P Y , Huang W , Hu S L , et al . Dynamic simulation of magnetic material regenerator and comparison with experiment [J ] . Cryogenics , 1996 , 36 ( 4 ): 259 - 261 .

Shen L , Kozomora N , Moran P , et al . 3D-CFD Simulations of a Two-Stage GM Cryocooler [C ] // International Cryocooler Conference . 2023 : 197 - 205 .

周志坡 , 李奥 , 何韩军 , 等 . 4 K高效大冷量G-M制冷机二级回热器性能研究 [J ] . 低温工程 , 2025 ( 2 ): 18 - 25 .

Zhou Z P , Li A , He H J , et al . Performance analysis of second regenerator for a high efficiency and large cooling power 4K G-M cryocooler [J ] . Cryogenics , 2025 ( 2 ): 18 - 25 .

Gao T , Wu C T , Chen X , et al . Numerical simulation and loss analysis on a two-stage GM cryocooler working at liquid helium temperatures [J ] . Cryogenics , 2025 , 150 : 104145 .

巢伟 , 赵钦宇 , 李睿泽 , 等 . 液氦温区大冷量GM制冷机仿真及参数分布研究 [J ] . 低温工程 , 2024 ( 4 ): 57 - 63 .

Chao W , Zhao Q Y , Li R Z , et al . Simulation and parameter distribution study of high-capacity GM cryocoolers working in liquid helium temperature [J ] . Cryogenics , 2024 ( 4 ): 57 - 63 .

Chao W , Li R Z , Zhao Q Y , et al . A high capacity GM cryocooler working at liquid helium temperatures for horizontal operation [J ] . Applied Thermal Engineering , 2024 , 244 : 122765 .

Gifford W E , Longsworth R C . Pulse-tube refrigeration [J ] . Journal of Engineering for Industry , 1964 , 86 ( 3 ): 264 - 268 .

Hao X H , Cosco J , Zerkle B , et al . Development of high cooling capacity and high efficiency 4.2 K pulse tube cryocoolers [C ] // International Cryocooler Conference . 2022 : 235 - 240 .

Lei T , Xu M Y . Development of a 2 W 4K pulse tube refrigerator with remote valve [C ] // International Cryocooler Conference . 2022 : 241 - 247 .

Li R Z , Wang B , Zhao Q Y , et al . A high-capacity separated pulse tube cryocooler working at liquid helium temperatures [J ] . Science Bulletin , 2025 , 70 ( 13 ): 2028 - 2030 .

Hao X , Zerkle B , Cosco J , et al . Development of a 5 W/4.2 K two-stage pulse tube cryocooler [J ] . IOP Conference Series: Materials Science and Engineering , 2024 , 1301 ( 1 ): 012140 .

崔运浩 , 周伟 , 梁思源 , 等 . 液氦温区大冷量GM-JT制冷系统实验研究 [J ] . 真空与低温 , 2025 , 31 ( 6 ): 726 - 731 .

Cui Y H , Zhou W , Liang S Y , et al . Experimental study on GM-JT cryocooler system with large cooling capacity in liquid helium temperature range [J ] . Vacuum and Cryogenics , 2025 , 31 ( 6 ): 726 - 731 .

Fujimoto S , Taneya S , Kurihara T , et al . Development of a 4K GM/JT refrigerator for maglev vehicle [M ] // Proceedings of the Sixteenth International Cryogenic Engineering Conference/International Cryogenic Materials Conference . Amsterdam : Elsevier , 1997 : 331 - 334 .

島田卓弥 , 笹崎修司 . 4K GM-JT 冷凍システムの開発 [J ] . 低温工学 , 2023 , 58 ( 5 ): 235 - 239

Takuya SHIMADA , Syuji SASAZAKI . Development of 4K GM-JT Cryocooler Systems [J ] . Cryogenics , 2023 , 58 ( 5 ): 235 - 239 .

Ciovati G , Anderson J , Balachandran S , et al . Development of a prototype superconducting radio-frequency cavity for conduction-cooled accelerators [J ] . Physical Review Accelerators and Beams , 2023 , 26 ( 4 ): 044701 .

Vennekate J , Castilla A , Cheng G , et al . On the way to a 10 mev, conduction-cooled, compactsrf accelerator [C ] // 21th International Conference on RF Superconductivity (SRF'23 ), Grand Rapids, MI, USA : JACOW Publishing , 2023 : 471 - 476 .

Wang Y H , Wu P F , Wang W C , et al . Cryogen-free superconducting magnetic resonance imaging system: a review [J ] . Fundamental Research , https://doi.org/10.1016/j.fmre.2025.05.006 https://doi.org/10.1016/j.fmre.2025.05.006

J Gary , A O Gallagher , R Radebaugh , et al . REGEN3 . 3 : USER MANUAL[M ] . no. April , 2008.

胡进勤 . 斯特林型脉管制冷机的理论和实验研究 [D ] . 杭州 : 浙江大学 , 2007 .

Hu J Q . Theoretical and experimental study of stirling type pulse tube cooler [D ] . Hangzhou : Zhejiang University , 2007 .

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

双面组合槽型干气密封性能分析与结构优化

微重力条件下低温贮箱加注-保持-排气式预冷特性研究

窗式空调器轴流风机的风速非均匀分布特性及其对冷凝器流路优化设计的影响规律

空调用套管式分流器结构设计及分流效果验证

余热梯级驱动热湿调控系统性能影响分析及应用