熔盐吸热管瞬态传热特性的数值研究

沈向阳; 丁静; 陆建峰

doi:10.11949/0438-1157.20200221

您当前的位置：

首页 >

文章列表页 >

熔盐吸热管瞬态传热特性的数值研究

流体力学与传递现象 | 更新时间：2026-07-24

- 熔盐吸热管瞬态传热特性的数值研究
- Numerical study of transient heat transfer performance for molten salt receiver tube
- 化工学报 2020年71卷第11期页码：5140-5149
- 作者机构：
  
  1.仲恺农业工程学院机电工程学院，广东广州 510225
  2.中山大学材料科学与工程学院，广东广州 510006
- 作者简介：
  
  沈向阳（1982—），男，博士，副教授，xiangyangshen@126.com
- 基金信息：
  
  国家自然科学基金项目(51606227)
- DOI：10.11949/0438-1157.20200221
  中图分类号： TK 124
- 收稿：2020-03-03，
  
  修回：2020-08-09，
  
  网络首发：2020-11-03，
  
  纸质出版：2020-11-05
- 稿件说明：
移动端阅览
沈向阳, 丁静, 陆建峰. 熔盐吸热管瞬态传热特性的数值研究[J]. 化工学报, 2020, 71(11): 5140-5149

SHEN Xiangyang, DING Jing, LU Jianfeng. Numerical study of transient heat transfer performance for molten salt receiver tube[J]. CIESC Journal, 2020, 71(11): 5140-5149
沈向阳, 丁静, 陆建峰. 熔盐吸热管瞬态传热特性的数值研究[J]. 化工学报, 2020, 71(11): 5140-5149 DOI： 10.11949/0438-1157.20200221.

SHEN Xiangyang, DING Jing, LU Jianfeng. Numerical study of transient heat transfer performance for molten salt receiver tube[J]. CIESC Journal, 2020, 71(11): 5140-5149 DOI： 10.11949/0438-1157.20200221.

摘要

建立熔盐吸热管瞬态传热的实验台和数值计算模型，分析管外壁热通量突变、熔盐流速突减、外壁热通量和熔盐流速同时突减对吸热管瞬态传热特性的影响规律，结果表明：管外壁热通量突变（突增或突减）时，吸热管入口段的管中心熔盐温度变化较小，但其管壁温度变化较快。管内熔盐流速突减时，熔盐出口温度和管外壁温度均随时间的推移逐渐增大，而管外壁与管内壁温差随时间的推移先降低后升高，

≥16.0 s，各温度和温差基本稳定。吸热管外壁热通量和管内熔盐流速同时减半时，管中心及出口熔盐温度均随时间的推移先升高后降低，稳态后两处熔盐温度保持定值且与瞬态开始前对应熔盐温度接近。吸热管瞬态稳定后的管外壁与管内壁温差和管外壁热通量变化呈正比，与熔盐流速变化无关。得到瞬态稳定后吸热管熔盐出口温度表达式，为瞬态传热过程中吸热器熔盐出口温度控制提供理论依据。

Abstract

The heat transfer experimental system and mathematical model of receiver tube are established to analyze the transient heat transfer performance of molten salt with heat flux of outer wall sudden change

molten salt velocity sharp reduction

heat flux of outer wall and molten salt velocity sharp reduction at the same time. The results show that when the heat flow on the outer wall of the tube changes suddenly (sudden increase or decrease)

the temperature of the molten salt in the center of the tub

e at the inlet section of the heat absorption tube changes less

but the temperature of the tube wall changes faster. When the molten salt velocity sharp reduction

the outlet temperature of molten salt and the outer wall temperature increase with time

but the difference of outer wall and inner wall temperature decreases at first and then increases

when

≥16.0 s

each temperature and temperature difference reach steady state. When the heat flux on the outer wall of the heat absorption tube and the molten salt flow rate in the tube are halved at the same time

the temperature of the molten salt in the center and the outlet of the tube rises first and then decreases with the passage of time. After the steady state

the two molten salt temperatures maintain a constant value and are compared with the transient state. The corresponding molten salt temperature is close to initial starting temperature. The difference of outer wall and inner wall temperature after transient stability is proportional to the heat flux of outer wall

but which is independent of molten salt velocity. The outlet temperature equation of molten salt in receiver tube after transient stability is obtained

which provides a theoretical basis for the outlet temperature control of molten salt in receiver during the transient heat transfer process.

关键词

Keywords

references

Wang W J , Malmquist A , Aichmayer L , et al . Transient performance of an impinging receiver: an indoor experimental study [J ] . Energy Conversion and Management , 2018 , 158 : 193 - 200 .

何雅玲 , 王坤 , 杜保存 , 等 . 聚光型太阳能热发电系统非均匀辐射能流特性及解决方法的研究进展 [J ] . 科学通报 , 2016 , 61 : 3208 - 3237 .

He Y L , Wang K , Du B C , et al . Non-uniform characteristics of solar flux distribution in the concentrating solar power systems and its corresponding solutions: a review [J ] . Chinese Science Bulletin , 2016 , 61 : 3208 - 3237 .

Xu L , Stein W , Kim J , et al . Transient numerical model for the thermal performance of the solar receiver [J ] . Applied Thermal Engineering , 2018 , 141 : 1035 - 1047 .

Xu L , Stein W , Kim J , et al . Three-dimensional transient numerical model for the thermal performance of the solar receiver [J ] . Renewable Energy , 2018 , 120 : 550 - 566 .

陈政伟 , 王跃社 , 陈开拓 , 等 . 瞬态阶跃热通量下腔式吸热器动态特性研究 [J ] . 工程热物理学报 , 2012 , 33 ( 10 ): 1719 - 1722 .

Chen Z W , Wang Y S , Chen K T , et al . Numerical research on dynamic characteristics in solar cavity receiver based on step-change radiation flux [J ] . Journal of Engineering Thermophysics , 2012 , 33 ( 10 ): 1719 - 1722 .

盛玲霞 , 李佳燕 , 赵豫红 . 塔式太阳能电站接收器的建模及动态仿真 [J ] . 化工学报 , 2016 , 67 ( 3 ): 736 - 742 .

Sheng L X , Li J Y , Zhao Y H . Modeling and dynamic simulation of receiver in a solar tower power station [J ] . CIESC Journal , 2016 , 67 ( 3 ): 736 - 742 .

许昌 , 刘德有 , 郑源 , 等 . 塔式太阳能发电多孔介质吸热器动态模型 [J ] . 中国电机工程学报 , 2010 , 30 ( 29 ): 122 - 127 .

Xu C , Liu D Y , Zheng Y , et al . Dynamic models research on a porous media receiver of solar tower power [J ] . Proceedings of the CSEE , 2010 , 30 ( 29 ): 122 - 127 .

Wu Z Y , Wang Z F . Fully coupled transient modeling of ceramic foam volumetric solar air receiver [J ] . Solar Energy , 2013 , 89 : 122 - 133 .

Wang F Q , Guan Z N , Tan J Y , et al . Transient thermal performance response characteristics of porous-medium receiver heated by multi-dish concentrator [J ] . International Communications in Heat and Mass Transfer , 2016 , 75 : 36 - 41 .

Ribeiro R R , de Lemos M J S . Transient behavior and thermal efficiency of volumetric heat receivers [J ] . International Journal of Heat and Mass Transfer , 2019 , 149 : 119 - 128 .

Najafabadi H A , Ozalp N , Ophoff C , et al . An experimental study on temperature control of a solar receiver under transient solar load [J ] . Solar Energy , 2019 , 186 : 52 - 59 .

屠楠 , 方嘉宾 , 魏进家 . 太阳能腔式吸热器不同启动状态下启动性能研究 [J ] . 工程热物理学报 , 2012 , 33 ( 11 ): 1900 - 1903 .

Tu N , Fang J B , Wei J J . Numerical simulation of different start-up performance of a solar cavity receiver [J ] . Journal of Engineering Thermophysics , 2012 , 33 ( 11 ): 1900 - 1903 .

张强强 , 李鑫 , 常春 , 等 . 多云气象条件下熔融盐腔式吸热器的热性能分析 [J ] . 中国电机工程学报 , 2014 , 34 ( 8 ): 1291 - 1296 .

Zhang Q Q , Li X , Chang C , et al . Thermal performance analysis of molten salt cavity receivers under cloudy conditions [J ] . Proceedings of the CSEE , 2014 , 34 ( 8 ): 1291 - 1296 .

Zhang Q Q , Li X , Wang Z F , et al . Experimental and theoretical analysis of a dynamic test method for molten salt cavity receiver [J ] . Renewable Energy , 2013 , 50 : 214 - 221 .

Samanes J , Garcia-Barberena J . A model for the transient performance simulation of solar cavity receivers [J ] . Solar Energy , 2014 , 110 : 789 - 806 .

Schöttl P , Bern G , Rooyen D W V , et al . Efficient modeling of variable solar flux distribution on solar tower receivers by interpolation of few discrete representations [J ] . Solar Energy , 2018 , 160 : 43 - 55 .

王楚航 . 塔式太阳能热发电系统熔盐回路瞬态模拟分析 [D ] . 上海 : 中国科学院上海应用物理研究所 , 2018 .

Wang C H . Dynamic simulation of molten salt loop in solar tower thermal power plant [D ] . Shanghai : Shanghai Institute of Applied Physics , Chinese Academy of Sciences , 2018 .

Li Z , Zhang Q Q , Wang Z F , et al . Numerical and experimental study of solidification dangers in a molten salt receiver for cloudy conditions [J ] . Solar Energy , 2019 , 193 : 118 - 131 .

Crespi F , Toscani A , Zani P , et al . Effect of passing clouds on the dynamic performance of a CSP tower receiver with molten salt heat storage [J ] . Applied Energy , 2018 , 229 : 224 - 235 .

Fritsch A , Uhlig R , Marocco L , et al . A comparison between transient CFD and FEM simulations of solar central receiver tubes using molten salt and liquid metals [J ] . Solar Energy , 2017 , 155 : 259 - 266 .

Augsburger G , Favrat D . Modelling of the receiver transient flux distribution due to cloud passages on a solar tower thermal power plant [J ] . Solar Energy , 2013 , 87 : 42 - 52 .

Too Y C S , García J , Padilla R V , et al . A transient optical-thermal model with dynamic matrix controller for solar central receivers [J ] . Applied Thermal Engineering , 2019 , 154 : 686 – 698 .

García J , Too Y C S , Padilla R V , et al . Dynamic performance of an aiming control methodology for solar central receivers due to cloud disturbances [J ] . Renewable Energy , 2018 , 121 : 355 - 367 .

Terdalkar R , Doupis D , Clark M , et al . Transient simulation of high temperature high pressure solar tower receiver [J ] . Energy Procedia , 2015 , 69 : 1451 - 1460 .

刘闪威 , 吴玉庭 , 崔武军 , 等 . 低熔点熔盐圆管内强迫对流换热 [J ] . 化工学报 , 2015 , 66 ( 2 ): 530 - 536 .

Liu S W , Wu Y T , Cui W J , et al . Forced convection heat transfer with low-melting point molten salt in circular pipe [J ] . CIESC Journal , 2015 , 66 ( 2 ): 530 - 536 .

杨世铭 , 陶文铨 . 传热学 [M ] . 4版 . 北京 : 高等教育出版社 , 2018 .

Yang S M , Tao W Q . Heat Transfer [M ] . 4th ed . Beijing : Higher Education Press , 2108 .

杨敏林 , 杨晓西 , 丁静 , 等 . 半周加热半周绝热的熔盐吸热管传热特性研究 [J ] . 太阳能学报 , 2009 , 30 ( 8 ): 1007 - 1012 .

Yang M L , Yang X X , Ding J , et al . Heat transfer research on molten salt receiver with semi-circumference heat [J ] . Acta Energiae Solaris Sinica , 2009 , 30 ( 8 ): 1007 - 1012 .

Lu J F , Shen X Y , Ding J , et al . Convective heat transfer of high temperature molten salt in transversely grooved tube [J ] . Applied Thermal Engineering , 2013 , 61 : 157 - 162 .

Lu J F , Shen X Y , Ding J , et al . Transition and turbulent convective heat transfer of molten salt in spirally grooved tube [J ] . Experimental Thermal and Fluid Science , 2013 , 47 : 180 - 185 .

沈向阳 , 张奇淄 , 陆建峰 , 等 . 熔盐吸热管非稳态对流换热特性 [J ] . 化工学报 , 2012 , 63 : 36 - 40 .

Shen X Y , Zhang Q Z , Lu J F , et al . Unsteady convective heat transfer performances of molten salt in receiver tube [J ] . CIESC Journal , 2012 , 63 : 36 - 40 .

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

基于二维梯度树状肋相变储热系统强化传热机理

半周加热横纹管内熔盐强化传热特性

填充多级相变材料的套管式储热器性能研究

平行流道PCHE芯体热-力耦合分析多尺度方法

微重力下液态金属钠沸腾传热特性模拟研究