管柱式气液旋流分离器液膜厚度的空间分布特性

王亚安; 陈建义; 叶松; 宋占荣; 韩明珊; 杨洋

doi:10.11949/0438-1157.20200139

您当前的位置：

首页 >

文章列表页 >

管柱式气液旋流分离器液膜厚度的空间分布特性

分离工程 | 更新时间：2026-07-24

- 管柱式气液旋流分离器液膜厚度的空间分布特性
- Spatial distribution characteristics of liquid film thickness in gas-liquid cylindrical cyclone
- 化工学报 2020年71卷第11期页码：5216-5225
- 作者机构：
  
  1.中国石油大学重质油国家重点实验室，北京 102249
  2.过程流体过滤与分离技术北京市重点实验室，北京 102249
- 作者简介：
  
  王亚安（1994—），男，博士研究生，yawang0215_cup@163.com
  陈建义（1965—），男，博士，教授，jychen@cup.edu.cn
- 基金信息：
  
  国家重点研发计划项目(2016YFC0303704;2018YFC0310504)
- DOI：10.11949/0438-1157.20200139
  中图分类号： TQ 058.1
- 收稿：2020-02-14，
  
  修回：2020-07-10，
  
  网络首发：2020-11-03，
  
  纸质出版：2020-11-05
- 稿件说明：
移动端阅览
王亚安, 陈建义, 叶松, 宋占荣, 韩明珊, 杨洋. 管柱式气液旋流分离器液膜厚度的空间分布特性[J]. 化工学报, 2020, 71(11): 5216-5225

WANG Ya’an, CHEN Jianyi, YE Song, SONG Zhanrong, HAN Mingshan, YANG Yang. Spatial distribution characteristics of liquid film thickness in gas-liquid cylindrical cyclone[J]. CIESC Journal, 2020, 71(11): 5216-5225
王亚安, 陈建义, 叶松, 宋占荣, 韩明珊, 杨洋. 管柱式气液旋流分离器液膜厚度的空间分布特性[J]. 化工学报, 2020, 71(11): 5216-5225 DOI： 10.11949/0438-1157.20200139.

WANG Ya’an, CHEN Jianyi, YE Song, SONG Zhanrong, HAN Mingshan, YANG Yang. Spatial distribution characteristics of liquid film thickness in gas-liquid cylindrical cyclone[J]. CIESC Journal, 2020, 71(11): 5216-5225 DOI： 10.11949/0438-1157.20200139.

摘要

管柱式气液旋流分离器（GLCC）是一种耦合离心力与重力的分离设备，其上部筒体内旋流液膜的分布特征显著影响其分离性能。液膜厚度作为该旋流液膜的关键参数，掌握其分布规律可为理解液膜的流动机制奠定基础。利用纽扣式电导传感器测量了GLCC上部筒体内的液膜厚度，通过改变入口气液相流量、入口喷嘴尺寸，系统地研究了其空间分布特性。结果表明，操作参数一定时，液膜厚度沿轴向向上趋于减小；在某一轴向位置，液膜厚度随入口气量的增大呈现“S”形分布，随入口液量的增大而近线性增大；此外，入口喷嘴尺寸对液膜厚度的分布影响显著：在不同的轴向位置，不同尺寸喷嘴对应的液膜厚度间的大小存在差异。液膜厚度随气液量的变化规律证明液膜逃逸是GLCC液相分离效率降低的直接原因，而喷嘴尺寸对液膜厚度沿轴向分布的影响则反映了GLCC旋流效应与重力效应间的相互作用。

Abstract

Gas-liquid cylindrical cyclone (GLCC) is a separation device coupling centrifugal force and gravity. The distribution characteristics of the swirling liquid film along the upper cylinder wall of GLCC significantly affect its separation performance. The thickness is the key parameter of the swirling liquid film. Mastering its distribution law can lay the foundation for better understanding the flow mechanism of the liquid film. In this paper

the liquid film thickness in the upper cylinder of GLCC was measured by using button electrodes. And its spatial distribution characteristics were systematically studied by changing the gas-liquid flow-rate and the size of the inlet nozzle. The results show that the liquid film thickness tends to decrease in the axial direction when the operating parameters are constant. At a certain axial position

the liquid film thickness exhibits an “S” shape distribution with the increase of the inlet gas volume

and increases with the inlet liquid volume and nearly linear increase. In addition

the size of inlet nozzle had a significant effect on the distribution of liquid film thickness. The change of liquid film thickness with inlet gas-liquid flow-rate proved that the escape of liquid film was the direct reason for the decrease of liquid separation efficiency of GLCC. The influence of inlet nozzle􀆳s size on the axial distribution of liquid film thickness reflected the interaction between swirl and gravity effects.

关键词

Keywords

references

王懿 , 陈建义 , 段梦兰 , 等 . 水下生产系统及工程 [M ] . 北京 : 中国石油大学出版社 , 2017 : 65 - 66 .

Wang Y , Chen J Y , Duan M L , et al . Underwater Production System and Engineering [M ] . Beijing : China University of Petroleum Press , 2017 : 65 - 66 .

Arpandi I A , Joshi A R , Shoham O , et al . Hydrodynamics of two-phase flow in gas-liquid cylindrical cyclone separators [J ] . SPE Journal , 1995 , 1 ( 4 ): 427 - 436 .

Gomez L E , Mohan R S , Shoham O , et al . Enhanced mechanistic model and field application design of gas-liquid cylindrical cyclone separator [J ] . SPE Journal , 1998 , 5 ( 2 ): 190 - 198 .

Movafaghian S , Jaua-Marturet J A , Mohan R S , et al . The effects of geometry, fluid properties and pressure on the hydrodynamics of gas-liquid cylindrical cyclone separators [J ] . Int. J. Multiphase Flow , 2000 , 26 ( 6 ): 999 - 1018 .

Molina R , Wang S , Gomez L E , et al . Wet gas separation in gas-liquid cylindrical cyclone separator [J ] . J. Energy Res. Technol. , 2008 , 130 ( 4 ): 130 - 134 .

Hreiz R , Lainé R , Wu J , et al . On the effect of the nozzle design on the performances of gas-liquid cylindrical cyclone separators [J ] . International Journal of Multiphase Flow , 2014 , 58 ( 1 ): 15 - 26 .

蒋明虎 , 李洪臻 , 张红军 , 等 . 柱状气液分离器入口结构数值模拟及试验研究 [J ] . 石油机械 , 2013 , 41 ( 2 ): 79 - 83 .

Jiang M H , Li H Z , Zhang H J , et al . Numerical simulation and experimental study on the inlet structure of gas-liquid cylindrical cyclone [J ] . Petroleum Machinery , 2013 , 41 ( 2 ): 79 - 83 .

董腾 . 水下生产系统管柱式气液分离器近似模化实验研究 [D ] . 北京 : 中国石油大学(北京) , 2015 : 50 - 77 .

Dong T . Similarity analysis and experimental study on gas-liquid cylindrical cyclone in subsea production system [D ] . Beijing : China University of Petroleum (Beijing) , 2015 : 50 - 77 .

路远 . 深海GLCC分离器入口喷嘴结构改进实验研究 [D ] . 北京 : 中国石油大学(北京) , 2016 : 47 - 76 .

Lu Y . Experimental study on the improvement of inlet nozzle geometry on gas-liquid cylindrical cyclone in subsea production system [D ] . Beijing : China University of Petroleum (Beijing) , 2016 : 47 - 76 .

许承炜 , 陈建义 , 董腾 , 等 . 深海管柱式气液分离器液相分离效率测量与分析 [J ] . 中国海洋平台 , 2018 , 33 ( 4 ): 59 - 65 .

Xu C W , Chen J Y , Dong T , et al . Measurement and analysis of liquid phase separation efficiency of gas-liquid cylindrical cyclones [J ] . China Offshore Platform , 2018 , 33 ( 4 ): 59 - 65 .

许如敏 , 陈建义 , 王婉琳 , 等 . 深海管柱式气液分离器结构优化模拟研究 [J ] . 中国海洋平台 , 2016 , 31 ( 2 ): 55 - 61 .

Xu R M , Chen J Y , Wang W L , et al . Structural optimization of deep sea gas-liquid cylindrical cyclones based on CFD [J ] . China Offshore Platform , 2016 , 31 ( 2 ): 55 - 61 .

Yue T , Chen J Y , Song J F , et al . Experimental and numerical study of upper swirling liquid film among gas-liquid cylindrical cyclones [J ] . Chemical Engineering Journal , 2019 , 358 : 806 - 820 .

Liu L , Bai B F . Flow regime identification of swirling gas-liquid flow with image processing technique and neural networks [J ] . Chemical Engineering Science , 2019 , 199 : 586 - 601 .

Funahashi H , Hayashi K , Hosokawa S , et al . Study on two-phase swirling flows in a gas-liquid separator with three pick-off rings [J ] . Nuclear Engineering & Design , 2016 , 308 : 205 - 213 .

Funahashi H , Kirkland K V , Hayashi K S , et al . Interfacial and wall friction factors of swirling annular flow in a vertical pipe [J ] . Nuclear Engineering & Design , 2018 , 330 : 97 - 105 .

Kataoka H , Tomiyama A , Hosokawa S , et al . Two-phase swirling flow in a gas-liquid separator [J ] . Journal of Power & Energy Systems , 2008 , 2 ( 4 ): 1120 - 1131 .

Kataoka H , Shinkai Y , Tomiyama A . Pressure drop in two-phase swirling flow in a steam separator [J ] . Journal of Power & Energy Systems , 2009 , 3 ( 2 ): 382 - 392 .

Tibiriçá C B , Nascimento F J , Ribatski G . Film thickness measurement techniques applied to micro-scale two-phase flow systems [J ] . Experimental Thermal & Fluid Science , 2010 , 34 ( 4 ): 463 - 473 .

王灵萍 , 王亦飞 , 郭强强 , 等 . 洗涤冷却管内垂直降膜流动特性 [J ] . 化工学报 , 2013 , 64 ( 6 ): 1959 - 1968 .

Wang L P , Wang Y F , Guo Q Q , et al . Flow characteristics of vertical falling film in scrubbing-cooling pipe [J ] . CIESC Journal , 2013 , 64 ( 6 ): 1959 - 1968 .

Wang S , Mohan R S , Shoham O , et al . Performance improvement of gas liquid cylindrical cyclone separators using integrated level and pressure control systems [J ] . Journal of Energy Resources Technology , 2000 , 122 : 185 - 192 .

Anastasiou A D , Makatsoris C , Gavriilidis A , et al . Application of μ-PIV for investigating liquid film characteristics in an open inclined microchannel [J ] . Experimental Thermal & Fluid Science , 2012 , 44 : 90 - 99 .

Zhao Y , Markides C N , Matar O K , et al . Disturbance wave development in two-phase gas-liquid upwards vertical annular flow [J ] . International Journal of Multiphase Flow , 2013 , 55 : 111 - 129 .

Aliyu A M , Baba Y D , Lao L , et al . Interfacial friction in upward annular gas-liquid two-phase flow in pipes [J ] . Experimental Thermal & Fluid Science , 2017 , 84 : 90 - 109 .

Zhai L S , Bian P , Han Y F , et al . The measurement of gas-liquid two-phase flows in a small diameter pipe using a dual-sensor multi-electrode conductance probe [J ] . Measurement Science and Technology , 2016 , 27 ( 4 ): 045101 .

孙宏军 , 王伟 , 桂明洋 . 水平管环状流液膜厚度与波动参数分布 [J ] . 化工学报 , 2019 , 70 ( 11 ): 4162 - 4171 .

Sun H J , Wang W , Gui M Y . Distribution of liquid film thickness and wave parameters in horizontal annular flow [J ] . CIESC Journal , 2019 , 70 ( 11 ): 4162 - 4171 .

Henstock W H , Hanratty T J . The interfacial drag and the height of the wall layer in annular flows [J ] . AIChE J. , 1976 , 22 ( 6 ): 990 - 1000 .

Tsochatzidis N A , Karapantsios T D , Kostoglou M V , et al . A conductance probe for measuring liquid fraction in pipes and packed beds [J ] . International Journal of Multiphase Flow , 1992 , 18 ( 5 ): 653 - 667 .

Fukano T , Furukawa T . Prediction of the effects of liquid viscosity on interfacial shear stress and frictional pressure drop in vertical upward gas-liquid annular flow [J ] . International Journal of Multiphase Flow , 1998 , 24 ( 4 ): 587 - 603 .

Ju P , Brooks C S , Ishii M , et al . Film thickness of vertical upward co-current adiabatic flow in pipes [J ] . International Journal of Heat & Mass Transfer , 2015 , 89 : 985 - 995 .

Pan L M , He H , Ju P , et al . Experimental study and modeling of disturbance wave height of vertical annular flow [J ] . International Journal of Heat & Mass Transfer , 2015 , 89 : 165 - 175 .

Hatazawa M . Characteristics of turbulent swirling flow in a straight pipe-swirl effect on pressure lose [J ] . Jpn. Soc. Mech. Flow , 1998 , ( 17 ): 202 - 213 .

阎昌琪 . 气液两相流 [M ] . 3版 . 哈尔滨 : 哈尔滨工程大学出版社 , 2017 : 9 - 25 .

Yan C Q . Gas and Liquid Two-Phase Flow [M ] . 3rd ed . Harbin : Harbin Engineering University Press , 2017 : 9 - 25 .

陈晓慧 . 流体物性对管柱式气液旋流分离器性能影响的研究 [D ] . 北京 : 中国石油大学(北京) , 2018 : 60 - 65 .

Chen X H . On the effect of liquid properties on the performance of gas-liquid cylindrical cyclone [D ] . Beijing : China University of Petroleum (Beijing) , 2018 : 60 - 65 .

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

基于液膜流型的双入口管柱式气液分离器性能研究

低截面气速下气液旋流分离器性能研究

基于递归特性和CNN的上升管内气液两相流型识别研究

微重力条件下低温贮箱加注-保持-排气式预冷特性研究

非对称锯齿型微通道结构流动沸腾传热的模拟研究