LiFePO<sub>4</sub>锂离子电池的数值模拟：正极材料颗粒粒径的影响

许于; 陈怡沁; 周静红; 隋志军; 周兴贵

doi:10.11949/0438-1157.20191199

您当前的位置：

首页 >

文章列表页 >

LiFePO₄锂离子电池的数值模拟：正极材料颗粒粒径的影响

材料化学工程与纳米技术 | 更新时间：2026-07-24

- LiFePO₄锂离子电池的数值模拟：正极材料颗粒粒径的影响
- Numerical simulation of lithium-ion battery with LiFePO₄ as cathode material: effect of particle size
- 化工学报 2020年71卷第2期页码：821-830
- 作者机构：
  
  华东理工大学化学工程联合国家重点实验室，上海 200237
- 作者简介：
  
  许于（1995—），男，硕士研究生，ce.xuyu@foxmail.com
  周静红（1971—），女，博士，教授，jhzhou@ecust.edu.cn
- 基金信息：
  
  国家自然科学基金项目(21676082);国家重点基础研究发展计划项目(2014CB239702)
- DOI：10.11949/0438-1157.20191199
  中图分类号： TQ 028.8
- 收稿：2019-10-14，
  
  修回：2019-11-29，
  
  网络首发：2020-08-14，
  
  纸质出版：2020-02-05
- 稿件说明：
移动端阅览
许于, 陈怡沁, 周静红, 隋志军, 周兴贵. LiFePO₄锂离子电池的数值模拟：正极材料颗粒粒径的影响[J]. 化工学报, 2020, 71(2): 821-830 DOI: 10.11949/0438-1157.20191199.

XU Yu, CHEN Yiqin, ZHOU Jinghong, SUI Zhijun, ZHOU Xinggui. Numerical simulation of lithium-ion battery with LiFePO₄ as cathode material: effect of particle size[J]. CIESC Journal, 2020, 71(2): 821-830 DOI: 10.11949/0438-1157.20191199.
许于, 陈怡沁, 周静红, 隋志军, 周兴贵. LiFePO₄锂离子电池的数值模拟：正极材料颗粒粒径的影响[J]. 化工学报, 2020, 71(2): 821-830 DOI: 10.11949/0438-1157.20191199. DOI：

XU Yu, CHEN Yiqin, ZHOU Jinghong, SUI Zhijun, ZHOU Xinggui. Numerical simulation of lithium-ion battery with LiFePO₄ as cathode material: effect of particle size[J]. CIESC Journal, 2020, 71(2): 821-830 DOI: 10.11949/0438-1157.20191199. DOI：

摘要

LiFePO

（LFP）作为正极材料时，锂离子电池安全性高且循环寿命长，是目前应用最广泛的正极材料，但其电池倍率性能较差。提升倍率性能的有效手段之一是将LFP材料颗粒纳米化，但材料纳米化过程中颗粒粒径减小对于锂离子电池充放电过程中锂在固液相的扩散及表面电化学反应的影响机制仍缺乏清晰的认识。采用锂离子电池的准二维模型，模拟锂离子电池的放电过程，定量研究了正极材料颗粒粒径对锂离子电池倍率性能的影响，分析了固液相扩散速率与电化学反应速率受LFP材料颗粒粒径的影响程度。研究结果表明：电极材料中固相扩散阻力是锂离子电池电化学性能的主要限制因素。小粒径的LFP作为正极材料时，电极材料内的金属锂的迁移路径较短，同时颗粒与电解液的接触面积增加，界面的电化学反应速率较快，放电倍率对于锂离子电池性能影响较小；大粒径的LFP作为正极材料时，电极材料内的金属锂扩散路径的增加和较高的固相扩散阻力限制了界面的电化学反应速率，导致锂离子电池的倍率性能显著降低。LFP材料的纳米化可以有效减小固相扩散阻力，提升锂离子电池的倍率性能。

Abstract

When LiFePO

(LFP) is used as a cathode material

the lithium-ion battery has high safety and lo

ng cycle life. It is currently the most widely used cathode material

but its battery rate performance is poor. One of the effective means to improve the rate performance of lithium-ion battery is to use LFP material of nanometer size. However

the mechanism of the LFP particle of nano size affecting the eletrochemical process during the charge and discharge of lithium-ion battery still remain unclear. In this work

a quasi-two-dimensional model of lithium-ion battery was established to simulate the discharge process. The influence of LFP particle size on the rate performance of lithium-ion battery was quantitatively studied. The diffusion rate and electrochemical reaction rate at solid-liquid interface were quantitatively analyzed. The results indicate that the resistance in solid phase is the key factor limiting the performance of lithium-ion battery. In the case of small particle LFP as electrode material

the diffusion path of lithium metal within the particles was shortened and the interface between electrode material and electrolyte increased

thus the electrochemical reaction rate was faster

presenting better rate performance. While in the case of large particle LFP as electrode material

the low solid phase diffusion rate of LFP material resulted in low electrochemical reaction rate and thus deteriorate rate performance of the lithium-ion battery. Size reduction of LFP could effectively shorten the migration path of the metal lithium in the electrode material and reduce solid phase diffusion resistance

therefore enhance the rate performance of the lithium-ion battery.

关键词

Keywords

references

Manthiram A , Fu Y , Su Y S . Challenges and prospects of lithium-sulfur batteries [J ] . Accounts of Chemical Research , 2012 , 46 ( 5 ): 1125 - 1134 .

Goodenough J B . How we made the Li-ion rechargeable battery [J ] . Nature Electronics , 2018 , 1 ( 3 ): 204 .

Goodenough J B , Park K S . The Li-ion rechargeable battery: a perspective [J ] . Journal of the American Chemcial Society , 2013 , 135 ( 4 ): 1167 - 1176 .

Simon P , Gogotsi Y , Dunn B . Where do batteries end and supercapacitors begin? [J ] . Science , 2014 , 343 ( 6176 ): 1210 - 1211 .

Cao B , Zhang Q , Liu H , et al . Graphitic carbon nanocage as a stable and high power anode for potassium-ion batteries [J ] . Advanced Energy Materials , 2018 , 8 ( 25 ): 1801149 .

Shi J L , Xiao D D , Ge M Y , et al . High-capacity cathode material with high voltage for Li-ion batteries [J ] . Advanced Materials , 2018 , 30 ( 9 ): 1705575 .

Padhi A K , Goodenough J B , Nanjundaswamy K S . Phospho-olivines as positive-electrode materials for recharageable lithium batteries [J ] . Journal of the Electrochemical Society , 1997 , 144 ( 4 ): 1188 - 1194 .

Chung S Y , Bloking J T , Chiang Y M . Electronically conductive phospho-olivines as lithium storage electrodes [J ] . Nature Materials , 2002 , 1 ( 2 ): 123 - 128 .

胡江涛 , 郑家新 , 潘锋 . 锂电池磷酸铁锂正极材料的结构与性能相关性的研究进展 [J ] . 物理化学学报 , 2019 , 35 ( 4 ): 22 - 31 .

Hu J T , Zheng J X , Pan F . Research progress on the correlation between structure and properties of lithium iron phosphate cathode materials [J ] . Acta Physico-Chimica Sinica , 2019 , 35 ( 4 ): 22 - 31 .

Ferrari S , Lavall R L , Capsoni D , et al . Influence of particle size and crystal orientation on the electrochemical behavior of carbon-coated LiFePO 4 [J ] . The Journal of Physical Chemistry C , 2010 , 114 ( 29 ): 12598 - 12603 .

Ouyang C Y , Shi S Q , Wang Z X , et al . The effect of Cr doping on Li ion diffusion in LiFePO 4 from first principles investigations and Monte Carlo simulations [J ] . Journal of Physics: Condensed Matter , 2004 , 16 ( 13 ): 2265 - 2272 .

Takahashi M , Tobishima S I , Takei K , et al . Reaction behavior of LiFePO 4 as a cathode material for rechargeable lithium batteries [J ] . Solid State Ionics , Diffusion & Reactions , 2002 , 148 ( 3/4 ): 283 - 289 .

Yamada A , Chung S C , Hinokuma K . Optimized LiFePO 4 for lithium battery cathodes [J ] . Journal of the Electrochemical Society , 2001 , 148 ( 3 ): A224 - A229 .

Lee K T , Kan W H , Nazar L F . Proof of intercrystallite ionic transport in LiMPO 4 electrodes (M = Fe, Mn) [J ] . Journal of the American Chemical Society , 2009 , 131 ( 17 ): 6044 - 6045 .

Satyavani T V S L , Ramya K B , Rajesh K V , et al . Effect of particle size on DC conductivity, activation energy and diffusion coefficient of lithium iron phosphate in Li-ion cells [J ] . Engineering Science and Technology , an International Journal , 2016 , 19 ( 1 ): 40 - 44 .

王琦 , 邓思旭 , 刘晶冰 , 等 . 提高正极材料磷酸铁锂倍率性能的研究进展 [J ] . 化工进展 , 2011 , 30 ( 12 ): 2652 - 2657 .

Wang Q , Deng S X , Liu J B , et al . Research progress in improving the performance of lithium iron phosphate in cathode materials [J ] . Chemical Industry and Engineering Progress , 2011 , 30 ( 12 ): 2652 - 2657 .

Doyle M , Newman J . Modeling the performance of rechargeable lithium based cells design correlations for limiting cases [J ] . Journal of Power Sources , 1995 , 54 ( 1 ): 46 - 51 .

Doyle M , Fuller T F , Newman J . Modeling of galvanostatic charge and discharge of the lithium/polymer/insertion cell [J ] . Journal of the Electrochemical Society , 1993 , 140 ( 6 ): 1526 - 1533 .

Newman J , Tiedemann W . Porous-electrode theory with battery applications [J ] . AIChE Journal , 1975 , 21 ( 1 ): 25 - 41 .

Shirazi A H N , Azadi K M R , Rabczuk T . Numerical study of composite electrode s particle size effect on the electrochemical and heat generation of a Li-ion battery [J ] . Journal of Nanotechnology in Engineering and Medicine , 2016 , 6 ( 4 ): 041003 .

Newman J , Thomas-Alyea K E . Electrochemical Systems [M ] . John Wiley & Sons , 2012 .

Ye Y , Shi Y , Tay A A O . Electro-thermal cycle life model for lithium iron phosphate battery [J ] . Journal of Power Sources , 2012 , 217 : 509 - 518 .

Safari M , Delacourt C . Modeling of a commercial graphite/LiFePO 4 cell [J ] . Journal of the Electrochemical Society , 2011 , 158 ( 5 ): A562 - A571 .

郭孝东 , 钟本和 , 唐艳 , 等 . 一次粒径和二次粒径对LiFePO 4 性能的影响 [J ] . 高校化学工程学报 , 2013 , ( 5 ): 884 - 888 .

Guo X D , Zhong B H , Tang Y , et al . Effect of primary particle size and secondary particle size on the properties of LiFePO 4 [J ] . Journal of Chemical Engineering of Chinese Universities , 2013 , ( 5 ): 884 - 888 .

Santhanagopalan S , Guo Q , Ramadass P , et al . Review of models for predicting the cycling performance of lithium ion batteries [J ] . Journal of Power Sources , 2006 , 156 ( 2 ): 620 - 628 .

Kumaresan K , Sikha G , White R E . Thermal model for a Li-ion cell [J ] . Journal of the Electrochemical Society , 2008 , 155 ( 2 ): A164 - A171 .

Gerver R E , Meyers J P . Three-dimensional modeling of electrochemical performance and heat generation of lithium-ion batteries in tabbed planar configurations [J ] . Journal of the Electrochemical Society , 2011 , 158 ( 7 ): A835 - A843 .

Valoen L O , Reimers J N . Transport properties of LiPF 6 -based Li-ion battery electrolytes [J ] . Journal of the Electrochemical Society , 2005 , 152 ( 5 ): A882 - A891 .

Taleghani S T , Marcos B , Lantagne G . Modeling and simulation of a commercial graphite-LiFePO 4 cell in a full range of C-rates [J ] . Journal of Applied Electrochemistry , 2018 , 48 ( 12 ): 1389 - 1400 .

Liu H , Strobridge F C , Borkiewicz O J , et al . Capturing metastable structures during high-rate cycling of LiFePO 4 nanoparticle electrodes [J ] . Science , 2014 , 344 ( 6191 ): 1252817 .

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

石墨负极颗粒对锂离子电池容量衰减及SEI膜生长影响的模拟研究

锂离子电池正极涂层孔隙结构优化的数值模拟

锂离子电池异构建模及内部传质机理探究：粒径分布的影响

磷酸钒锂正极材料的氮掺杂碳包覆与Ti4+共掺杂协同改性研究

带有突扩比的新型流道结构对海水激活电池性能的影响

LiFePO4锂离子电池的数值模拟：正极材料颗粒粒径的影响

Numerical simulation of lithium-ion battery with LiFePO4 as cathode material: effect of particle size

DOI：10.11949/0438-1157.20191199

摘要

Abstract

关键词

Keywords

references

LiFePO₄锂离子电池的数值模拟：正极材料颗粒粒径的影响

Numerical simulation of lithium-ion battery with LiFePO₄ as cathode material: effect of particle size