基于超结构法的热集成间接式功交换网络综合

杨蕊; 庄钰; 邸楠茜; 都健

doi:10.11949/0438-1157.20190888

您当前的位置：

首页 >

文章列表页 >

基于超结构法的热集成间接式功交换网络综合

过程系统工程 | 更新时间：2026-07-24

- 基于超结构法的热集成间接式功交换网络综合
- Synthesis of heat integrated with indirect power exchange networks based on superstructure model
- 化工学报 2019年70卷第12期页码：4689-4697
- 作者机构：
  
  1. 大连理工大学化工学院化工系统工程研究所，辽宁大连 116024
  2. 大连理工大学能源与动力学院，辽宁省海水淡化重点实验室，辽宁大连 116024
- 作者简介：
  
  杨蕊（1994—），女，硕士研究生，876783789@qq.com
  都健（1964—），女，博士，教授，dujian@dlut.edu.cn
- 基金信息：
  
  国家自然科学基金项目(21776035);中国博士后科学基金项目(2019TQ0045)
- DOI：10.11949/0438-1157.20190888
  中图分类号： TQ 021.8
- 收稿：2019-08-06，
  
  修回：2019-08-16，
  
  网络首发：2020-06-09，
  
  纸质出版：2019-12-05
- 稿件说明：
移动端阅览
杨蕊, 庄钰, 邸楠茜, 都健. 基于超结构法的热集成间接式功交换网络综合[J]. 化工学报, 2019, 70(12): 4689-4697

YANG Rui, ZHUANG Yu, DI Nanxi, DU Jian. Synthesis of heat integrated with indirect power exchange networks based on superstructure model[J]. CIESC Journal, 2019, 70(12): 4689-4697
杨蕊, 庄钰, 邸楠茜, 都健. 基于超结构法的热集成间接式功交换网络综合[J]. 化工学报, 2019, 70(12): 4689-4697 DOI： 10.11949/0438-1157.20190888.

YANG Rui, ZHUANG Yu, DI Nanxi, DU Jian. Synthesis of heat integrated with indirect power exchange networks based on superstructure model[J]. CIESC Journal, 2019, 70(12): 4689-4697 DOI： 10.11949/0438-1157.20190888.

摘要

换热网络综合的研究和应用对于提高能源利用率已被证明是有效的，而用于回收更高品质能量的功交换网络综合的研究仍处于起步阶段。针对间接式功交换网络综合中复杂推动力约束对流股匹配的制约问题，构建了一种考虑级间热集成的拓展超结构，基于线性拟合压缩机和涡轮机的操作曲线，提出了功源与功阱间流股匹配的识别方法；针对压力、流量与温度的高度非凸非线性关系，提出了采用热集成优化每一级入口温度的松弛策略，建立了以年度总费用最小为目标的混合整数非线性规划模型，通过GAMS求解得到最优的间接式功交换网络结构。最后通过一个算例分析，验证所提方法的有效性和可行性。

Abstract

The comprehensive research and application of heat exchanger networks has been proven to be effective in improving energy efficiency

and the comprehensive research on power exchange networks for recovering higher quality energy is still in its infancy. To solve the problem of stream matching limited by complex driving force constraints in indirect work exchange network synthesis

an extended superstructure considering inter-stage heat integration is established in this paper. Based on the linear fitting operation curves of compressors and turbines

an identification method is proposed for searching feasible stream matches between work sources and sinks. Specific to the highly non-convex and non-linear relationship among pressure

flowrate and temperature

a relaxation strategy is proposed to optimize the inlet temperature of each stage by heat integration

and a mixed-integer nonlinear programming model is established with the objective of minimizing the total annual cost (TAC) model is solved using GAMS and the optimal indirect work exchange network structure is obtained. Finally

an example is given to verify the validity and feasibility of the proposed method.

关键词

Keywords

references

Linnhoff B , Flower J R . Synthesis of heat exchanger networks(Ⅰ): Systematic generation of energy optimal networks [J ] . AIChE Journal , 1978 , 24 ( 4 ): 633 - 642 .

都健 , 李春妮 , 陈理 . 基于虚拟温度法的间歇过程换热网络结构优化 [J ] . 化工学报 , 2010 , 61 ( 12 ): 3162 - 3166 .

Du J , Li C N , Chen L . Structure optimization of heat exchanger network for batch processes based on pseudo-temperature [J ] . CIESC Journal , 2010 , 61 ( 12 ): 3162 - 3166 .

Papoulias S A , Grossmann I E . A structural optimization approach in process synthesis(Ⅱ): Heat recovery networks [J ] . Computers & Chemical Engineering , 1983 , 7 ( 6 ): 707 - 721 .

Yee T F , Grossmann I E . Simultaneous optimization models for heat integration(Ⅱ): Heat exchanger network synthesis [J ] . Computers & Chemical Engineering , 1990 , 14 ( 10 ): 1165 - 1184 .

Huang Y L , Fan L T . Analysis of a work exchanger network [J ] . Industrial & Engineering Chemistry Research , 1996 , 35 ( 10 ): 3528 - 3538 .

Liu G , Hua Z , Shen R , et al . A graphical method for integrating work exchange network [J ] . Applied Energy , 2014 , 114 ( 2 ): 588 - 599 .

Zhuang Y , Liu L L , Zhang L , et al . Upgraded graphical method for the synthesis of direct work exchanger networks [J ] . Industrial & Engineering Chemistry Research , 2017 , 56 : 14304-14315 .

庄钰 , 刘琳琳 , 李继龙 , 等 . 基于转运模型的功交换网络综合 [J ] . 化工进展 , 2015 , 34 ( 4 ): 952 - 956

Zhuang Y , Liu L L , Li J L , et al . Synthesis of work exchange network based on transshipment model [J ] . Chemical Industry & Engineering Progress , 2015 , 34 ( 4 ): 952 - 956 .

Zhuang Y , Liu L L , Zhang L , et al . Direct work exchanger network synthesis of isothermal process based on improved transshipment model [J ] . Journal of the Taiwan Institute of Chemical Engineers , 2017 , 81 : 295 - 304 .

Zhuang Y , Liu L L , Liu Q L , et al . Step-wise synthesis of work exchange networks involving heat integration based on the transshipment model [J ] . Chinese Journal of Chemical Engineering , 2017 , 25 ( 8 ): 1052 - 1060 . .

Zhuang Y , Liu L , Zhang L , et al . An extended superstructure modeling method for simultaneous synthesis of direct work exchanger networks [J ] . Chemical Engineering Research & Design , 2019 , 144 ( 1 ): 258 - 271 .

Razib M S , Hasan M M F , Karimi I A . Pressure management using optimal compressor networks [C ] // 8th World Congress of Chemical Engineering: Incorporating the 59th Canadian Chemical Engineering Conference and the 24th Interamerican Congress of Chemical Engineering . 2009 .

Razib M S , Hasan M M F , Karimi I A . Preliminary synthesis of work exchange networks [J ] . Computers & Chemical Engineering , 2012 , 37 : 262 - 277 .

周华 , 刘桂莲 , 冯霄 . 考虑效率的功交换网络问题表格法 [J ] . 化工学报 , 2011 , 62 ( 6 ): 1600 - 1605 .

Zhou H , Liu G L , Feng X . Problem table method for work exchange network with efficiency considered [J ] . CIESC Journal , 2011 , 62 ( 6 ): 1600 - 1605 .

陈慧 , 冯霄 . 考虑经济性的功量交换网络的最优匹配 [J ] . 清华大学学报(自然科学版) , 2012 , 52 ( 3 ): 298 - 302 .

Chen H , Feng X . Optimized work exchange networks with economic consideration [J ] . J. Tsinghua Univ . (Sci . & Tech .), 2 012 , 52 ( 3 : 298 - 302 .

Zhuang Y , Liu L L , Zhang L , et al . Synthesis of indirect work exchange networks considering both isothermal and adiabatic process together with exergy analysis [J ] . Chinese Journal of Chemical Engineering , 2018 , 26 ( 8 ): 1644 - 1652 .

Aspelund A , Berstad D O , Gundersen T . An extended pinch analysis and design procedure utilizing pressure based exergy for subambient cooling [J ] . Applied Thermal Engineering , 2007 , 27 ( 16 ): 2633 - 2649 .

Gundersen T , Berstad D O , Aspelund A . Extending pinch analysis and process integration into pressure and fluid phase considerations [J ] . Chemical Engineering Transactions , 2009 , 18 : 33 - 38 .

Fu C , Gundersen T . Sub-ambient heat exchanger network design including expanders [J ] . Chemical Engineering Science , 2015 , 138 : 712 - 729 .

Fu C , Gundersen T . Integrating expanders into heat exchanger networks above ambient temperature [J ] . AIChE Journal , 2015 , 61 ( 10 ): 3404 - 3422 .

Fu C , Gundersen T . Sub-ambient heat exchanger network design including compressors [J ] . Chemical Engineering Science , 2015 , 137 : 631 - 645 .

Fu C , Gundersen T . Integrating compressors into heat exchanger networks above ambient temperature [J ] . AIChE Journal , 2015 , 61 ( 11 ): 3770 - 3785 .

Wechsung A , Aspelund A , Gundersen T , et al . Synthesis of heat exchanger networks at subambient conditions with compression and expansion of process streams [J ] . AIChE Journal , 2011 , 57 ( 8 ): 2090 - 2108 .

Onishi V C , Ravagnani M A S S , Caballero J A . Simultaneous synthesis of work exchange networks with heat integration [J ] . Chemical Engineering Science , 2014 , 112 : 87 - 107 .

Onishi V C , Ravagnani M A S S , Caballero J A . Simultaneous synthesis of heat exchanger networks with pressure recovery: optimal integration between heat and work [J ] . AIChE Journal , 2014 , 60 ( 3 ): 893 - 908 .

Onishi V C , Ravagnani M A S S , Jiménez L , et al . Multi-objective synthesis of work and heat exchange networks: optimal balance between economic and environmental performance [J ] . Energy Conversion Management , 2017 , 140 : 192 - 202 .

Huang K F , Karimi I A . Work-heat exchanger network synthesis(WHENS) [J ] . Energy , 2016 , 113 : 1006 - 1017 .

Nair S K , Rao H N , Karimi I A . Framework for work-heat exchange network synthesis [J ] . AIChE Journal , 2018 , 64 ( 7 ): 2472 - 2485 .

Onishi V C , Quirante N , Ravagnani M A S S , et al . Optimal synthesis of work and heat exchangers networks considering unclassified process streams at sub and above-ambient conditions [J ] . Applied Energy , 2018 , 224 : 567 - 581 .

Yu H S , Fu C , Vikse M , et al . Identifying optimal thermodynamic paths in work and heat exchange network synthesis [J ] . AIChE Journal , 2019 , 65 ( 2 ): 549 - 561 .

Zhuang Y , Zhang L , Liu L L , et al . Simultaneous synthesis of WHEN based on superstructure modelling considering thermodynamic and economic factors [J ] . Computers Aided Chemical Engineering , 2018 , 44 : 1033 - 1038 .

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

工业系统超结构模型应用研究进展

考虑需求不确定性的化工生产计划与调度集成

煤基冷热电联供优化方法

基于催化重整分子级模型的物质流量分析方法

基于ALNS-TS的大规模维修任务调度优化快速求解算法