三叶后掠-HEDT组合桨搅拌釜内流场的模拟及实验

周勇军; 袁名岳; 徐昊鹏; 何华; 孙建平

doi:10.11949/0438-1157.20190800

您当前的位置：

首页 >

文章列表页 >

三叶后掠-HEDT组合桨搅拌釜内流场的模拟及实验

流体力学与传递现象 | 更新时间：2026-07-24

- 三叶后掠-HEDT组合桨搅拌釜内流场的模拟及实验
- Investigation on flow field in stirred tank equipped with three-blade swept-back-HEDT combined impeller by experiment and simulation
- 化工学报 2019年70卷第12期页码：4599-4607
- 作者机构：
  
  1. 南京工业大学机械与动力工程学院，江苏南京 211816
  2. 江苏省特种设备安全监督检验研究院国家化工设备质量监督检验中心，江苏苏州 215600
- 作者简介：
  
  周勇军（1969—），男，硕士，副教授，zhouyj@njtech.edu.cn
- 基金信息：
  
  国家自然科学基金项目(51775262)
- DOI：10.11949/0438-1157.20190800
  中图分类号： TQ 022
- 收稿：2019-07-11，
  
  修回：2019-10-08，
  
  网络首发：2020-06-09，
  
  纸质出版：2019-12-05
- 稿件说明：
移动端阅览
周勇军, 袁名岳, 徐昊鹏, 何华, 孙建平. 三叶后掠-HEDT组合桨搅拌釜内流场的模拟及实验[J]. 化工学报, 2019, 70(12): 4599-4607

ZHOU Yongjun, YUAN Mingyue, XU Haopeng, HE Hua, SUN Jianping. Investigation on flow field in stirred tank equipped with three-blade swept-back-HEDT combined impeller by experiment and simulation[J]. CIESC Journal, 2019, 70(12): 4599-4607
周勇军, 袁名岳, 徐昊鹏, 何华, 孙建平. 三叶后掠-HEDT组合桨搅拌釜内流场的模拟及实验[J]. 化工学报, 2019, 70(12): 4599-4607 DOI： 10.11949/0438-1157.20190800.

ZHOU Yongjun, YUAN Mingyue, XU Haopeng, HE Hua, SUN Jianping. Investigation on flow field in stirred tank equipped with three-blade swept-back-HEDT combined impeller by experiment and simulation[J]. CIESC Journal, 2019, 70(12): 4599-4607 DOI： 10.11949/0438-1157.20190800.

摘要

对应用于聚乙烯聚合反应中的三叶后掠-HEDT组合桨的搅拌釜内流场进行了模拟研究，分析组合桨的离底距

、桨间距

以及转速

的变化对搅拌釜内流场的影响，利用PIV实验对模拟结果进行了验证；将该组合桨与三叶后掠-六直叶圆盘涡轮组合桨进行了模拟对比研究。结果表明：当桨间距与釜内径的比为0.35时，釜内桨叶间的流体流动效果最好，该条件下能够改善搅拌釜上层流体的速度分布；当离底距与釜内径的比值为0.29时，组合桨下方出现了整体的环流，有利于釜底流体的混合；桨叶转速

=90 r/min时釜内流体速度分布均匀，同时上层HEDT桨叶产生的射流方向趋于水平。两种组合桨的对比研究表明：二者流型相近，但前者搅拌功率能够得到明显降低。研究结果可为三叶后掠-HEDT组合桨在聚乙烯聚合反应釜中的工程应用提供参考。

Abstract

The flow field in a stirred tank with three-blade swept-back HEDT combined impeller for polyethylene polymerization was simulated. The effects of the installation height of impellers (

)

the distance between two impellers (

) and the rotational speed of the combined impeller(

) on the flow field in the stirred tank were analyzed

and the simulation results were validated by PIV experiments. The comparison between the three-blade swept-back HEDT and the three-blade swept-six straight blade disc turbine combined propeller are carried out. The results show that when the ratio of propeller spacing to vessel diameter is 0.35

the fluid flow between the blades in the stirred tank is the best

and the velocity distribution of the upper fluid in the stirred tank is improved. When the installation height of impellers to vessel diameter is 0.29

an overall circulation occurs under the combined paddle

which is beneficial to the mixing of the bottom fluid of the kettle. When

= 90 r/min

the fluid velocity distribution in the kettle is uniform

and the jet direction produced by the upper HEDT blade tends to be horizontal. The comparison between the combined impeller and the three-b

lade swept-six-straight blade disc turbine shows that the flow pattern of the two combined impellers is similar

but the mixing power of the former can be significantly reduced. The research results can provide reference for engineering application of three-blade sweep-HEDT combined impeller in the polyethylene polymerization reactor.

关键词

Keywords

references

杨苏 , 虞清 , 黄志坚 , 等 . 搅拌技术在聚合反应釜中的应用 [J ] . 化学推进器与高分子材料 , 2003 , 1 ( 3 ): 19 - 22 .

Yang S , Yu Q , Huang Z J , et al . Applications of mixing technique in polymerization reaction kettle [J ] . Propellants & Polymeric Materials , 2003 , 1 ( 3 ): 19 - 22 .

Sudhakar , Krishna R S , Kishor R . Synthesis of ultrahigh molecular weight polyethylene: a differentiate material for specialty applications [J ] . Materials Science and Engineering , 2010 , 168 ( 1 / 2 / 3 ): 132 - 135 .

骆广生 , 王凯 , 王佩坚 , 等．反应器内聚合物合成反应进展 [J ] . 化工学报 , 2014 , 65 ( 7 ): 2563 - 2573 .

Luo G S , Wang K , Wang P J , et al . Advances in polymer synthesis in microreactors [J ] . CIESC Journal , 2014 , 65 ( 7 ): 2563 - 2573 .

冯连芳 , 王嘉骏 . 反应器 [M ] . 北京 : 化学工业出版社 , 2009 : 17 - 41 .

Feng L F , Wang J J . Reactor [M ] . Beijing : Chemical Industry Press , 2009 : 17 - 41 .

Ding J , Wang X , Zhou X F . CFD optimization of continuous stirred-tank (CSTR) reactor for biohydrogen production [J ] . Bioresource Technology , 2010 , 101 ( 18 ): 7005 - 7013 .

Sarhan K , Zied D , Hedi K , et al . Numerical simulation of fluid-structure interaction in a stirred vessel equipped with an anchor impeller [J ] . Journal of Mechanical Science and Technology , 2011 , 25 ( 7 ): 1749 - 1760 .

Li X J , Guan X P , Zhou R T . CFD simulation of gas dispersion in a stirred tank of dual Rushton turbines [J ] . International Journal of Chemical Reactor Engineering , 2017 , 15 ( 4 ): 20160221 .

杨斌 , 高凯 , 淡勇 . 化工搅拌釜内流动测量技术的应用进展 [J ] . 化工进展 , 2012 , 31 ( 11 ): 2364 - 2372 .

Yang B , Gao K , Dan Y , et al . Development of the flow measurement techniques used in the experimental study of the chemical stirred tank [J ] . Chemical Industry and Engineering Progress , 2012 , 31 ( 11 ): 2364 - 2372 .

Dmitry V G , Arto L , Ilkka T , et al . Experimentally validated CFD model for gas-liquid flow in a round-bottom stirred tank equipped with Rushton turbine [J ] . International Journal of Chemical Reactor Engineering , 2017 , 15 ( 2 ): 20150215 .

Akhilesh K , Divya R , Basudeb M . Study on residence time distribution of CSTR using CFD [J ] . Indian Journal of Chemical Technology , 2016 , 23 : 114 - 120 .

Rahmani L , Seghier O , Benmoussa A , et al . CFD study of the thermal transfer of a non-Newtonian fluid within a tank mechanically stirred by an anchor-shaped impeller [J ] . EPJ Web of Conferences , 2018 , 180 : 1 - 6 .

Atibeni R , Gao Z M , Bao Y Y . Effect of bafﬂes on fluid flow field in stirred tank with floating particles by using PIV [J ] . Canadian Journal of Chemical Engineering , 2013 , 91 : 571 - 578 .

Liu N N , Wang W , Han J C , et al . A PIV investigation of the effect of disperse phase fraction on the turbulence characteristics of liquid–liquid mixing in a stirred tank [J ] . Chemical Engineering Science , 2016 , 152 : 528 - 546 .

Kalmbach A , Breuer M . Experimental PIV/V3V measurements of vortex-induced fluid-structure interaction in turbulent flow — a new benchmark FSI-PfS-2a [J ] . Journal of Fluids and Structures , 2013 , 42 ( 4 ): 369 - 387 .

鲍苏洋 , 周勇军 , 王璐璐 , 等 . 涡轮桨搅拌槽内流场特性的V3V实验 [J ] . 化工学报 , 2016 , 67 ( 11 ): 4580 - 4586 .

Bao S Y , Zhou Y J , Wang L L , et al . V3V study on flow field characteristics in a stirred vessel with Rushton turbine impeller [J ] . CIESC Journal , 2016 , 67 ( 11 ): 4580 - 4586 .

施乃进 , 周勇军 , 鲍苏洋 , 等 . 涡轮桨搅拌槽内湍流特性的V3V 实验及大涡模拟 [J ] . 化工学报 , 2017 , 68 ( 11 ): 4069 - 4078 .

Shi N J , Zhou Y J , Bao S Y , et al . V3V study and large eddy simulation of turbulence characteristics in a stirred vessel with Rushton turbine impeller [J ] . CIESC Journal , 2017 , 68 ( 11 ): 4069 - 4078 .

Alberini F , Liu L , Stitt E H , et al . Comparison between 3-D-PTV and 2-D-PIV for determination of hydrodynamics of complex fluids in a stirred vessel [J ] . Chemical Engineering Science , 2017 , 171 : 189 - 203 .

谷文涛 , 张纯德 , 戴文权 . 三叶后掠式搅拌器的设计开发及其应用 [J ] . 聚氯乙烯 , 1998 , 2 : 1 - 6 .

Gu W T , Zhang C D , Dai W Q . Design and development of three-blade sweeping stirrer [J ] . Polyvinyl Chloride , 1998 , 2 : 1 - 6 .

杨春辉 , 罗忠新 , 刘生宽 , 等 . 国产PVC聚合釜的技术开发及应用 [J ] . 聚氯乙烯 , 2002 , 1 : 49 - 52 .

Yang C H , Luo Z X , Liu S K , et al . Technological development and application of domestic pvc polymerization vessel [J ] . Polyvinyl Chloride , 2002 , 1 : 49 - 52 .

王昌花 . 悬浮法合成苯并嗪中间体工程化研究 [D ] . 成都 : 四川大学 , 2001 .

Wang C H . Chemical engineering in suspension polymerization of benzoxazine intermediate [D ] . Chengdu : Sichuan University , 2001 .

Bao Y Y , Lu Y , Liao Q Q , et al . Power demand and mixing performance of coaxial mixers in a stirred tank with CMC solution [J ] . Chinese Journal of Chemical Engineering , 2015 , 23 ( 4 ): 623 - 632 .

张金鑫 . 搅拌槽内高黏度流体混合性能实验研究及数值模拟 [D ] . 北京 : 北京化工大学 , 2015 .

Zhang J X . Experimental study and simulation of high viscous fluid mixing in a stirred tank [D ] . Beijing : Beijing University of Chemical Technology , 2015 .

郑津洋 , 桑芝富 . 过程设备设计 [M ] . 北京 : 化学工业出版社 , 2015 : 344 - 345 .

Zheng J Y , Sang Z F . Process Equipment Design [M ] . Beijing : Chemical Industry Press , 2015 : 344 - 345 .

张和照 . 新型气液分散搅拌器介绍 [J ] . 化工设计 , 1997 , 5 : 62 - 69 .

Zhang H Z . Introduction to new gas/liquid dispersing agitato [J ] . Chemical Engineering Design , 1997 , 5 : 62 - 69 .

Zhang J J , Gao Z M , Cai Y T , et al . Mass transfer in gas-liquid stirred reactor with various triple-impeller combinations [J ] . Chinese Journal of Chemical Engineering , 2016 , 24 ( 6 ): 703 - 710 .

朱姝 , 包雨云 , 陈雷 , 等 . 用电导探针测定气-液多层桨搅拌槽内气泡尺寸分布 [J ] . 高校化学工程学报 , 2011 , 25 ( 6 ): 977 - 984 .

Zhu S , Bao Y Y , Chen L , et al . Bubble size distributions measurement in a gas-liquid multi-impeller stirred tank by using dual-conductivity probe [J ] . Journal of Chemical Engineering of Chinese Universities , 2011 , 25 ( 6 ): 977 - 984 .

丁子洋 . 粘性体系搅拌槽内气液分散特性研究 [D ] . 北京 : 北京化工大学 , 2013 .

Ding Z Y . Investigating on gas-liquid dispersion characteristics in stirred tank with viscous system [D ] . Beijing : Beijing University of Chemical Technology , 2013 .

宋戈 . 涡轮桨搅拌槽内湍流特性的三维PIV实验研究 [D ] . 北京 : 北京化工大学 , 2012 .

Song G . The experiment investigation of fluid characteristics in the stirrer tank using stereo PIV [D ] . Beijing : Beijing University of Chemical Technology , 2012 .

Manjunath B , Teri D , Pal T . Numerical and experimental investigation of single phase flow characteristics in stirred tanks using Rushton turbine and flotation impeller [J ] . Minerals Engineering , 2015 , 83 : 156 - 167 .

Hosseini S , Patel D , Ein-Mozaffari F . Study of solid-liquid mixing 490 in agitated tanks through computational fluid dynamics modeling [J ] . Ind. Eng. Chem. Res ., 2010 , 49 : 4426 - 4435 .

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

光热操控双核双重乳液滴核聚并特性

电化学水软化过程中离子输运与成核机理研究

基于响应面法的气浮旋流分离条件优化

基于热短路问题的仿生地埋管换热器模拟

柔性Rushton搅拌桨的振动特性