半周加热横纹管内熔盐强化传热特性

沈向阳; 丁静; 陆建峰

doi:10.11949/0438-1157.20190685

您当前的位置：

首页 >

文章列表页 >

半周加热横纹管内熔盐强化传热特性

流体力学与传递现象 | 更新时间：2026-07-24

- 半周加热横纹管内熔盐强化传热特性
- Heat transfer characteristic of molten salt in transverse corrugated tube with semi-circumference heating
- 化工学报 2019年70卷第12期页码：4546-4555
- 作者机构：
  
  1.仲恺农业工程学院机电工程学院，广东广州 510225
  2.中山大学材料科学与工程学院，广东广州 510006
- 作者简介：
  
  沈向阳（1982—），男，博士，副教授，xiangyangshen@126.com
  陆建峰（1978—），男，博士，教授，lujfeng@mail.sysu.edu.cn
- 基金信息：
  
  国家自然科学基金项目(51606227)
- DOI：10.11949/0438-1157.20190685
  中图分类号： TK 124
- 收稿：2019-06-19，
  
  修回：2019-08-30，
  
  网络首发：2020-06-09，
  
  纸质出版：2019-12-05
- 稿件说明：
移动端阅览
沈向阳, 丁静, 陆建峰. 半周加热横纹管内熔盐强化传热特性[J]. 化工学报, 2019, 70(12): 4546-4555

SHEN Xiangyang, DING Jing, LU Jianfeng. Heat transfer characteristic of molten salt in transverse corrugated tube with semi-circumference heating[J]. CIESC Journal, 2019, 70(12): 4546-4555
沈向阳, 丁静, 陆建峰. 半周加热横纹管内熔盐强化传热特性[J]. 化工学报, 2019, 70(12): 4546-4555 DOI： 10.11949/0438-1157.20190685.

SHEN Xiangyang, DING Jing, LU Jianfeng. Heat transfer characteristic of molten salt in transverse corrugated tube with semi-circumference heating[J]. CIESC Journal, 2019, 70(12): 4546-4555 DOI： 10.11949/0438-1157.20190685.

摘要

半周加热太阳能吸热器管给管内对流传热系数带来影响，基于此，建立半周加热横纹管内熔盐对流传热的实验台和数值计算模型，分析横纹管槽宽、槽深对管内熔盐传热性能的影响规律，结果表明：从横纹管绝热侧到加热侧，周向管内壁温度逐渐升高，周向管内局部Nusselt数先减小后缓慢增大至稳定。横纹管凹槽处轴向管内壁温度明显低于平滑段，凹槽处轴向管内局部

较大，凹槽后与平滑段交界处管内局部

最小。横纹管槽越宽，加热侧轴向管内局部

越小，管内平均

越小，传热综合性能评价因子PEC越大。横纹管槽越深，轴向管内局部

越大，管内平均

越大，传热强化倍数

越大。槽宽对横纹管PEC的影响比槽深明显，槽深对横纹管内

Nu/Nu

影响比槽宽大。通过线性拟合得到半周加热横纹管内熔盐传热

的关联式，其计算

与模拟值最大偏差在±7%以内。

Abstract

The semi-circumferential heating of the solar heat absorber tube has an effect on the convective heat transfer coefficient in the tube. Base on this

convection heat transfer experimental system and mathematical model of transverse corrugated tube are established to analyze the h

eat transfer performance of molten salt with different groove width and height. The results show that the circumferentially temperature of inner wall increases

and the circumferentially local Nusselt number decreases first and then increases to stability with transverse corrugated tube from adiabatic side to heated side. The axial temperature of inner wall with groove obviously lower than that of smooth section

the axial local Nusselt number of groove in transverse corrugated tube is relatively large

and the convergence of after groove and smooth section is minimal. The axial local Nusselt number of heated side and the average Nusselt number in transverse corrugated tube decrease with the groove width increases

while the PEC(comprehensive performance evaluation factor) rises. The axial local Nusselt number

the average Nusselt number and

(enhanced heat transfer ratio) increase with the groove height increment. The PEC of transverse corrugated tube is obvious affected by groove width

while the

is remarkable affected by groove height. The Nusselt number rule equation of molten salt in transverse corrugated tube with circumferentially non-uniform heat flux is obtained

and the maximum deviation of

between calculated and simulated value is within ±7%.

关键词

Keywords

references

施素丽 , 鹿院卫 , 于强 , 等 . 熔盐单罐释热过程换热器取热方式优选 [J ] . 化工学报 , 2019 , 70 ( 3 ): 857 - 864 .

Shi S L , Lu Y W , Yu Q , et al . Optimization of heat removal modes for heat exchanger in molten salt single storage tank [J ] . CIESC Journal , 2019 , 70 ( 3 ): 857 - 864 .

刘闪威 , 吴玉庭 , 崔武军 , 等 . 低熔点熔盐圆管内强迫对流换热 [J ] . 化工学报 , 2015 , 66 ( 2 ): 530 - 536 .

Liu S W , Wu Y T , Cui W J , et al . Forced convection heat transfer with low-melting point molten salt in circular pipe [J ] . CIESC Journal , 2015 , 66 ( 2 ): 530 - 536 .

Zhang Q Q , Li X , Chang C , et al . An experimental study: thermal performance of molten salt cavity receivers [J ] . Applied Thermal Engineering , 2013 , 50 : 334 - 341 .

Benoit H , Spreafico L , Gauthier D , et al . Review of heat transfer fluids in tube-receivers used in concentrating solar thermal systems: properties and heat transfer coefficients [J ] . Renewable and Sustainable Energy Reviews , 2016 , 55 : 298 - 315 .

何雅玲 , 王坤 , 杜保存 , 等 . 聚光型太阳能热发电系统非均匀辐射能流特性及解决方法的研究进展 [J ] . 科学通报 , 2016 , 61 : 3208 - 3237 .

He Y L , Wang K , Du B C , et al . Non-uniform characteristics of solar flux distribution in the concentrating solar power systems and its corresponding solutions: a review [J ] . Chinese Science Bulletin , 2016 , 61 : 3208 - 3237 .

Cheng Z D , He Y L , Qiu Y . A detailed nonuniform thermal model of a parabolic trough solar receiver with two halves and two inactive ends [J ] . Renewable Energy , 2015 , 74 : 139 - 147 .

Romero M , Buck R , Pacheco J E . An update on solar central receiver systems, projects, and technologies [J ] . Journal of Solar Energy Engineering , 2002 , 124 ( 5 ): 98 - 108 .

郑建涛 , 韩临武 , 徐海卫 , 等 . 太阳能柱式吸热器非均匀受热的数值模拟 [J ] . 节能技术 , 2016 , 34 ( 1 ): 7 - 12 .

Zheng J T , Han L W , Xu H W , et al . Numerical simulation of the solar thermal cylinder receiver under uneven heat flux [J ] . Energy Conservation Technology , 2016 , 34 ( 1 ): 7 - 12 .

Tao Y B , He Y L , Qu Z G . Numerical study on performance of molten salt phase change thermal energy storage system with enhanced tubes [J ] . Solar Energy , 2012 , 86 : 1155 - 1163 .

Wang W , Zhang Y N , Li Y J , et al . Numerical study on fully-developed turbulent flow and heat transfer in inward corrugated tubes with double-objective optimization [J ] . International Journal of Heat and Mass Transfer , 2018 , 120 : 782 - 792 .

Yang M L , Yang X X , Yang X P , et al . Heat transfer enhancement and performance of the molten salt receiver of a solar power tower [J ] . Applied Energy , 2010 , 87 : 2808 - 2811 .

Lu J F , Shen X Y , Ding J , et al . Convective heat transfer of high temperature molten salt in transversely grooved tube [J ] . Applied Thermal Engineering , 2013 , 61 : 157 - 162 .

Lu J F , Shen X Y , Ding J , et al . Transition and turbulent convective heat transfer of molten salt in spirally grooved tube [J ] . Experimental Thermal and Fluid Science , 2013 , 47 : 180 - 185 .

樊奇伟 . 熔盐管内强化传热实验研究 [D ] . 上海 : 中国科学院上海应用物理研究所 , 2017 .

Fan Q W . Experimental research on heat transfer enhancement of molten salt in tubes [D ] . Shanghai : Shanghai Institute of Applied Physics , Chinese Academy of Sciences , 2017 .

Chen C , Wu Y T , Wang S T , et al . Experimental investigation on enhanced heat transfer in transversally corrugated tube with molten salt [J ] . Experimental Thermal and Fluid Science , 2013 , 47 : 108 - 116 .

Ghadirijafarbeigloo S , Zamzamian A H , Yaghoubi M . 3-D numerical simulation of heat transfer and turbulent flow in a receiver tube of solar parabolic trough concentrator with louvered twisted-tape inserts [J ] . Energy Procedia , 2014 , 49 : 373 - 380 .

Bellos E , Tzivanidis C , Tsimpoukis D . Multi-criteria evaluation of parabolic trough collector with internally finned absorber [J ] . Applied Energy , 2017 , 205 : 540 - 561 .

Bellos E , Tzivanidis C . Enhancing the performance of evacuated and non-evacuated parabolic trough collectors using twisted tape inserts, perforated plate inserts and internally finned absorber [J ] . Energies , 2018 , 11 ( 5 ): 1129 .

常春 , 李石栋 , 李鑫 , 等 . 周向非均匀热通量边界条件下混合熔融盐在太阳能高温吸热管内的强化换热研究 [J ] . 中国电机工程学报 , 2014 , 34 : 1 - 6 .

Chang C , Li S D , Li X , et al . Enhanced heat transfer characteristics of molten salt in solar thermal absorber tubes with circumferentially non-uniform heat flux boundary condition [J ] . Proceedings of the CSEE , 2014 , 34 : 1 - 6 .

Song X W , Dong G B , Gao F Y , et al . A numerical study of parabolic trough receiver with nonuniform heat flux and helical screw-tape inserts [J ] . Energy , 2014 , 77 : 771 - 782 .

Chang C , Sciacovelli A , Wu Z Y , et al . Enhanced heat transfer in a parabolic trough solar receiver by inserting rods and using molten salt as heat transfer fluid [J ] . Applied Energy , 2018 , 220 : 337 - 350 .

Zheng Z J , Li M J , He Y L . Thermal analysis of solar central receiver tube with porous inserts and non-uniform heat flux [J ] . Applied Energy , 2017 , 185 : 1152 - 1161 .

杨敏林 , 杨晓西 , 丁静 , 等 . 半周加热半周绝热的熔盐吸热管传热特性研究 [J ] . 太阳能学报 , 2009 , 30 ( 8 ): 1007 - 1012 .

Yang M L , Yang X X , Ding J , et al . Heat transfer research on molten salt receiver with semi-circumference heat [J ] . Acta Energiae Solaris Sinica , 2009 , 30 ( 8 ): 1007 - 1012 .

Shen X Y , Lu J F , Ding J , et al . Convective heat transfer of molten salt in circular tube with nonuniform heat flux [J ] . Experimental Thermal and Fluid Science , 2014 , 55 : 6 - 11 .

沈向阳 , 陆建峰 , 丁静 , 等 . 熔盐在螺旋槽管和横纹管内强化传热特性 [J ] . 工程热物理学报 , 2013 , 34 ( 6 ): 1149 - 1152 .

Shen X Y , Lu J F , Ding J , et al . Heat transfer enhancement of molten salt in spirally corrugated tube and transversely corrugated tube [J ] . Journal of Engineering Thermophysics , 2013 , 34 ( 6 ): 1149 - 1152 .

徐志明 , 陈玲 , 孙彬彬 , 等 . 结构对横纹管综合性能影响的研究 [J ] . 热力发电 , 2012 , 40 ( 3 ): 46 - 50 .

Xu Z M , Chen L , Sun B B , et al . Study on the influence of structure upon comprehensive performance of transversally corrugated tubes [J ] . Thermal Power Generation , 2012 , 40 ( 3 ): 46 - 50 .

崔文智 , 尹飞 , 李隆键 . 非均匀热通量边界条件下螺旋管内换热特性 [J ] . 低温与超导 , 2013 , 41 ( 6 ): 81 - 84 .

Cui W Z , Yin F , Li L J . Heat transfer characteristics in helically coiled tube with non-uniform heat flux [J ] . Cryogenics and Superconductivity , 2013 , 41 ( 6 ): 81 - 84 .

Chyu M K , Ding H , Downs J P , et al . Determination of local heat transfer coefficient based on bulk mean temperature using a transient liquid crystals technique [J ] . Experimental Thermal and Fluid Science , 1998 , 18 : 142 - 149 .

Webb R L . Performance evaluation criteria for use of enhanced heat transfer surface in heat exchanger design [J ] . International Journal of Heat and Mass Transfer , 1981 , 24 ( 4 ): 715 - 726 .

谭祥辉 , 孙赫 , 张立振 , 等 . 扭曲椭圆管换热的壳程强化传热特性 [J ] . 化工学报 , 2012 , 63 ( 3 ): 713 - 720 .

Tan X H , Sun H , Zhang L Z , et al . Shell side heat transfer enhancement in twisted elliptical tube heat exchange [J ] . CIESC Journal , 2012 , 63 ( 3 ): 713 - 720 .

陈聪 , 吴玉庭 , 王树涛 , 等 . 横纹管内混合硝酸盐传热特性的实验研究 [J ] . 工程热物理学报 , 2013 , 34 ( 5 ): 927 - 930 .

Chen C , Wu Y T , Wang S T , et al . Experimental study for convective heat transfer with mixed molten salts in transversally corrugated tubes [J ] . Journal of Engineering Thermophysics , 2013 , 34 ( 5 ): 927 - 930 .

文玉良 . 熔融盐横纹管吸热器传递特性与强化机理研究 [D ] . 广州 : 华南理工大学 , 2010 .

Wen Y L . Transport characteristic and its enhancement mechanism for transverse ridged tubes with molten salts materials in receiver [D ] . Guangzhou : South China University of Technology , 2010 .

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

熔盐吸热管瞬态传热特性的数值研究

压力波强化横掠管束传热实验研究

基于三周期极小曲面结构的高密度储热器蓄放热特性研究

薄膜型LNG船液货舱温度场计算分析

交织网状小通道热沉的传热特性