Fe<italic style="font-style: italic">x</italic>MnCe1-AC低温SCR催化剂SO2中毒机理研究

陈潇雪; 宋敏; 孟凡跃; 卫月星

doi:10.11949/0438-1157.20190318

您当前的位置：

首页 >

文章列表页 >

Fe_xMnCe₁-AC低温SCR催化剂SO₂中毒机理研究

更新时间：2026-07-24

- Fe_xMnCe₁-AC低温SCR催化剂SO₂中毒机理研究
- Mechanism study on SO₂ poisoning of Fe_xMnCe₁-AC catalyst for low-temperature SCR
- 化工学报 2019年70卷第8期页码：3000-3010
- 作者机构：
  
  东南大学能源与环境学院，能源热转换及其过程测控教育部重点实验室，江苏南京 210096
- 作者简介：
  
  陈潇雪（1994—），女，硕士研究生，2296761847@qq.com
  宋敏（1982—），女，博士，副教授，minsong@seu.edu.cn
- 基金信息：
  
  燃煤过程有机污染物排放控制技术(2018YFB0605200)
- DOI：10.11949/0438-1157.20190318
  中图分类号： TQ 028.8
- 收稿：2019-04-01，
  
  修回：2019-06-20，
  
  网络首发：2026-07-24，
  
  纸质出版：2019-08-05
- 稿件说明：
移动端阅览
陈潇雪, 宋敏, 孟凡跃, 卫月星. Fe_xMnCe₁-AC低温SCR催化剂SO₂中毒机理研究[J]. 化工学报, 2019, 70(8): 3000-3010 DOI: 10.11949/0438-1157.20190318.

CHEN Xiaoxue, SONG Min, MENG Fanyue, WEI Yuexing. Mechanism study on SO₂ poisoning of Fe_xMnCe₁-AC catalyst for low-temperature SCR[J]. CIESC Journal, 2019, 70(8): 3000-3010 DOI: 10.11949/0438-1157.20190318.
陈潇雪, 宋敏, 孟凡跃, 卫月星. Fe_xMnCe₁-AC低温SCR催化剂SO₂中毒机理研究[J]. 化工学报, 2019, 70(8): 3000-3010 DOI: 10.11949/0438-1157.20190318. DOI：

CHEN Xiaoxue, SONG Min, MENG Fanyue, WEI Yuexing. Mechanism study on SO₂ poisoning of Fe_xMnCe₁-AC catalyst for low-temperature SCR[J]. CIESC Journal, 2019, 70(8): 3000-3010 DOI: 10.11949/0438-1157.20190318. DOI：

摘要

以活性炭为载体，通过超声辅助浸渍法制备了一系列Fe

MnCe

-AC催化剂，考察了该系列催化剂的低温NH

-SCR脱硝活性，确立了活性最佳的催化剂，并探究了SO

对其脱硝性能的影响。结果表明，Fe

0.1

MnCe

-AC催化剂低温脱硝活性最高，在120~220℃范围内NO的转化率均在90%以上（无SO

）。此外，在180℃、SO

浓度为429 mg/m

时，该催化剂仍能保持77%左右的脱硝率。通过BET、XRD、XPS、H

-TPR、NH

-TPD、FT-IR、TGA等表征手段对催化剂的SO

中毒机理进行了分析。研究发现，SO

能与NH

及催化剂中金属组分生成硫酸铵盐((NH

)

、(NH

)

)、MnSO

等物质，改变了原催化剂孔道结构并减少了催化剂表面Brönsted和Lewis酸性位点，抑制了催化剂吸附NH

的能力。更多地，SO

促使催化剂中Mn

、Ce

、Fe

和Fe

—OH

基团数量下降，表面可还原物质减少，从而降低了催化剂的脱硝活性。

Abstract

A series of Fe

MnCe

-AC catalysts were prepared by ultrasonic-assisted impregnation method with activated carbon as carrier. The low-temperature NH

-SCR denitrification activity of the catalysts was investigated

and the best activity catalyst was established. The effect of SO

on its denitration performance was also explored. The results showed that Fe

0.1

MnCe

-AC catalyst exhibited best denitration efficiency at low-temperature among prepared catalysts

e conversion rate of NO exceeded 90% with the temperature range from 120℃ to 220℃ (no SO

). In addition

the catalyst could maintain NO conversion rate of approximately 77% under the atmosphere of 180℃ and SO

concentration of 429 mg/m

. The mechanism of SO

poisoning on the catalyst was characterized with BET

XRD

XPS

-TPR NH

-TPD

FT-IR and TGA. It was observed that SO

could form ammonium sulfate ( (NH

)

(NH

)

and MnSO

with NH

and the metal components in the catalyst

which changed the pore structure of the fresh catalyst and reduced the Brönsted acid sites and Lewis acid sites on the catalyst surface. These variation made the inhibitory effect on the catalytic adsorption capacity of NH

. Moreover

also promoted a decrease in the number of Mn

and Fe

—OH

groups in the catalyst

and lessened the surface reducible species

thereby reducing the activity of the catalyst denitration.

关键词

Keywords

references

Fang N J , Guo J X , Shu S , et al . Effect of calcination temperature on low-temperature NH 3 -SCR activity and the resistance of SO 2 with or without H 2 O over Fe-Mn-Zr catalyst [J ] . Journal of the Taiwan Institute of Chemical Engineers , 2018 , 93 : 277 - 288 .

Roy S , Hegde M S , Madras G . Catalysis for NO x abatement [J ] . Applied Energy , 2009 , 86 ( 11 ): 2283 - 2297 .

Peng Y , Li J , Si W , et al . Insight into deactivation of commercial SCR catalyst by arsenic: an experiment and DFT study [J ] . Environmental Science & Technology , 2014 , 48 ( 23 ): 13895 - 13900 .

Chen L , Li J , Ge M . The poisoning effect of alkali metals doping over nano V 2 O 5 -WO 3 /TiO 2 catalysts on selective catalytic reduction of NO x by NH 3 [J ] . Chemical Engineering Journal , 2011 , 170 ( 2 / 3 ): 531 - 537 .

Gao F , Tang X , Yi H , et al . Improvement of activity, selectivity and H 2 O & SO 2 -tolerance of micro-mesoporous CrMn 2 O 4 spinel catalyst for low-temperature NH 3 -SCR of NO x [J ] . Applied Surface Science , 2019 , 466 : 411 - 424 .

Zhao L , Li C , Zhang X , et al . A review on oxidation of elemental mercury from coal-fired flue gas with selective catalytic reduction catalysts [J ] . Catalysis Science & Technology 2015 , 5 ( 7 ): 3459 - 3472 .

Nie Y , Yan Q , Chen S , et al . CuTi LDH derived NH 3 -SCR catalysts with highly dispersed CuO active phase and improved SO 2 resistance [J ] . Catalysis Communications , 2017 , 97 : 47 - 50 .

Nedyalkova R , Kamasamudram K , Currier N W , et al . Experimental evidence of the mechanism behind NH 3 overconsumption during SCR over Fe-zeolites [J ] . Journal of Catalysis , 2013 , 299 : 101 - 108 .

Putluru S S R , Schill L , Jensen A D , et al . Mn/TiO 2 and Mn-Fe/TiO 2 catalysts synthesized by deposition precipitation-promising for selective catalytic reduction of NO with NH 3 at low temperatures [J ] . Applied Catalysis B: Environmental , 2015 , 165 : 628 - 635 .

Kwon D W , Nam K B , Hong S C . The role of ceria on the activity and SO 2 resistance of catalysts for the selective catalytic reduction of NO x by NH 3 [J ] . Applied Catalysis B: Environmental , 2015 , 166 / 167 : 37 - 44 .

Zhuang K , Zhang Y P , Huang T J , et al . Sulfur-poisoning and thermal reduction regeneration of holmium-modified Fe-Mn/TiO 2 catalyst for low-temperature SCR [J ] . Journal of Fuel Chemistry and Technology , 2017 , 45 ( 11 ): 1356 - 1364 .

Leng X , Zhang Z , Li Y , et al . Excellent low temperature NH 3 -SCR activity over Mn a Ce 0.3 TiO x ( a  = 0.1—0.3) oxides: influ ence of Mn addition [J ] . Fuel Processing Technology , 2018 , 181 : 33 - 43 .

Wang L , Huang B , Su Y , et al . Manganese oxides supported on multi-walled carbon nanotubes for selective catalytic reduction of NO with NH 3 : catalytic activity and characterization [J ] . Chemical Engineering Journal , 2012 , 192 : 232 - 241 .

Li J H , Chang H Z , Ma L , et al . Low-temperature selective catalytic reduction of NO x with NH 3 over metal oxide and zeolite catalysts—a review [J ] . Catalysis Today , 2011 , 175 : 147 - 156 .

Jin R , Liu Y , Wang Y , et al . The role of cerium in the improved SO 2 tolerance for NO reduction with NH 3 over Mn-Ce/TiO 2 catalyst at low temperature [J ] . Applied Catalysis B: Environmental , 2014 , 148 / 149 : 582 - 588 .

Yan D J , Ya Y U , Huang X M , et al . Poisoning effect of SO 2 on Mn-Ce/TiO 2 catalysts for NO reduction by NH 3 at low temperature [J ] . Journal of Fuel Chemistry & Technology , 2016 , 44 ( 2 ): 232 - 238 .

France L J , Yang Q , Li W , et al . Ceria modified FeMnO x —enhanced performance and sulphur resistance for low-temperature SCR of NO x [J ] . Applied Catalysis B: Environmental , 2017 , 206 : 203 - 215 .

Cao F , Su S , Xiang J , et al . The activity and mechanism study of Fe-Mn-Ce/γ-Al 2 O 3 catalyst for low temperature selective catalytic reduction of NO with NH 3 [J ] . Fuel , 2015 , 139 : 232 - 239 .

乔南利 , 杨忆新 , 刘清龙 , 等 . 载体物化性质对锰铈催化剂NH 3 -SCR脱硝性能的影响 [J ] . 燃料化学学报 , 2018 , 46 ( 6 ): 733 - 742 .

Qiao N L , Yang Y X , Liu Q L , et al . Influence of different supports on the physicochemical properties and denitration performance of the supported MnCe-based catalysts for NH 3 -SCR [J ] . Journal of Fuel Chemistry and Technology , 2018 , 46 ( 6 ): 733 - 742 .

Marban G , Valdessolis T , Fuertes A B . Mechanism of low-temperature selective catalytic reduction of NO with NH 3 over carbon-supported Mn 3 O 4 -role of surface NH 3 species: SCR mechanism [J ] . Physical Chemistry Chemical Physics , 2004 , 6 ( 2 ): 453 - 464 .

周愉千 , 刘超 , 宋鹏 , 等 . CeO x /AC催化剂NH 3 选择性催化还原NO [J ] . 环境工程学报 , 2012 , 6 ( 8 ): 2720 - 2724 .

Zhou Y Q , Liu C , Song P , et al . CeO x /AC catalysts for selective catalytic reduction of NO by NH 3 [J ] . Chinese Journal of Environmental Engineering , 2012 , 6 ( 8 ): 2720 - 2724 .

Jin R , Liu Y , Wu Z , et al . Low-temperature selective catalytic reduction of NO with NH 3 over MnCe oxides supported on TiO 2 and Al 2 O 3 : a comparative study [J ] . Chemosphere , 2010 , 78 ( 9 ): 1160 - 1166 .

Peña D A , Uphade B S , Smirniotis P G . TiO 2 -supported metal oxide catalysts for low-temperature selective catalytic reduction of NO with NH 3 (I): Evaluation and characterization of first row transition metals [J ] . Journal of Catalysis , 2004 , 221 ( 2 ): 421 - 431 .

Xu L , Li X S , Crocker M , et al . A study of the mechanism of low-temperature SCR of NO with NH 3 on MnO x /CeO 2 [J ] . Journal of Molecular Catalysis A: Chemical , 2013 , 378 : 82 - 90 .

Zhang D , Zhang L , Shi L , et al . In situ supported MnO x -CeO x on carbon nanotubes for the low-temperature selective catalytic reduction of NO with NH 3 [J ] . Nanoscale , 2013 , 5 ( 3 ): 1127 .

解智博 , 宋艳军 , 梁金生 , 等 . 锰基催化剂低温选择催化还原处理NO x 的研究现状与展望 [J ] . 材料导报 , 2017 , 31 ( 11 ): 38 - 43 .

Xie Z B , Song Y J , Liang J S , et al . Research status and prospects of low temperature selective catalytic reduction of NO x by MnO x -based catalyst s [J ] . Materials Review , 2017 , 31 ( 11 ): 38 - 43 .

Li W , Zhang C , Li X , et al . Ho-modified Mn-Ce/TiO 2 for low-temperature SCR of NO with NH 3 : evaluation and characterization [J ] . Chinese Journal of Catalysis , 2018 , 39 ( 10 ): 1653 - 1663 .

Liu Z , Wang A , Wang X , et al . Ir-C xerogels synthesized by sol-gel method for NO reduction [J ] . Catalysis Today , 2008 , 137 ( 2 / 3 / 4 ): 162 - 166 .

Lu X , Song C , Jia S , et al . Low-temperature selective catalytic reduction of NO x with NH 3 over cerium and manganese oxides supported on TiO 2 -graphene [J ] . Chemical Engineering Journal , 2015 , 260 : 776 - 784 .

Zhang X M , Deng Y Q , Tian P , et al . Dynamic active sites over binary oxide catalysts: in situ /operando spectroscopic study of low-temperature CO oxidation over MnO x -CeO 2 catalysts [J ] . Applied Catalysis B: Environmental , 2016 , 191 : 179 - 191 .

Miller D D , Chuang S S C . In situ infrared study of NO reduction over Pd/Al 2 O 3 and Ag-Pd/Al 2 O 3 catalysts under H 2 -rich and lean-burn conditions [J ] . Journal of the Taiwan Institute of Chemical Engineers , 2009 , 40 ( 6 ): 613 - 621 .

Xu W , He H , Yu Y . Deactivation of a Ce/TiO 2 catalyst by SO 2 in the selective catalytic reduction of NO by NH 3 [J ] . Journal of Physical Chemistry C , 2009 , 113 ( 11 ): 4426 - 4432 .

Qiao J , Wang N , Wang Z , et al . Porous bimetallic Mn 2 Co 1 O x catalysts prepared by a one-step combustion method for the low temperature selective catalytic reduction of NO x with NH 3 [J ] . Catalysis Communications , 2015 , 72 : 111 - 115 .

Kapteijn F , Singoredjo L , Andreini A , et al . Activity and selectivity of pure manganese oxides in the selective catalytic reduction of nitric oxide with ammonia [J ] . Cheminform , 1994 , 3 ( 2 / 3 ): 173 - 189 .

Shen B , Liu T , Zhao N , et al . Iron-doped Mn-Ce/TiO 2 catalyst for low temperature selective catalytic reduction of NO with NH 3 [J ] . Journal of Environmental Sciences , 2010 , 22 ( 9 ): 1447 - 1454 .

Mukundan D , Oliver K , Martin E , et al . Characterization and catalytic investigation of Fe-ZSM 5 for urea-SCR [J ] . Catalysis Today , 2007 , 119 ( 1 / 2 / 3 / 4 ): 137 - 144 .

Zhou X , Huang X , Xie A , et al . V 2 O 5 -decorated Mn-Fe/attapulgite catalyst with high SO 2 tolerance for SCR of NO x with NH 3 at low temperature [J ] . Chemical Engineering Journal , 2017 , 326 : 1074 - 1085 .

Lin X , Li S , He H , et al . Evolution of oxygen vacancies in MnO x -CeO 2 mixed oxides for soot oxidation [J ] . Applied Catalysis B: Environmental , 2017 , 223 : 91 - 102 .

Li Y , Wan Y , Li Y P , et al . Low-temperature selective catalytic reduction of NO with NH 3 over Mn 2 O 3 -doped Fe 2 O 3 hexagonal microsheets [J ] . ACS Applied Materials & Interfaces , 2016 , 8 ( 8 ): 5224 - 5233 .

Raj A M E , Victoria S G , Jothy V B , et al . XRD and XPS characterization of mixed valence Mn 3 O 4 hausmannite thin films prepared by chemical spray pyrolysis technique [J ] . Applied Surface Science , 2010 , 256 ( 9 ): 2920 - 2926 .

Yang J , Su Z , Ren S , et al . Low-temperature SCR of NO with NH 3 over biomass char supported highly dispersed Mn-Ce mixed oxides [J ] . Journal of the Energy Institute , 2019 : 92 ( 4 ): 883 - 891 .

Shen B X , Liu T . Deactivation of MnO x -CeO x /ACF catalysts for low-temperature NH 3 -SCR in the presence of SO 2 [J ] . Acta Physico-Chimica Sinica , 2010 , 26 ( 11 ): 3009 - 3016 .

Shi Y , Pan H , Zhang Y , et al . Promotion of MgO addition on SO 2 tolerance of Ag/Al 2 O 3 for selective catalytic reduction of NO x with methane at low temperature [J ] . Catalysis Communications , 2008 , 9 ( 5 ): 796 - 800 .

Zhu Z , Niu H , Liu Z , et al . Decomposition and reactivity of NH 4 HSO 4 on V 2 O 5 /AC catalysts used for NO reduction with ammonia [J ] . Journal of Catalysis , 2000 , 195 ( 2 ): 268 - 278 .

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

基于NH3-SCR反应铜基小孔分子筛催化剂Na中毒对比研究

钌钯双金属催化剂催化L-氨基丙酸加氢特性

9种树叶生物炭作为染料敏化太阳电池对电极的光电性能

四氯乙烷脱HCl反应中炭基催化剂的失活机理

微生物燃料电池MnO2/S-AC泡沫镍空气阴极的制备及其性能

FexMnCe1-AC低温SCR催化剂SO2中毒机理研究

Mechanism study on SO2 poisoning of FexMnCe1-AC catalyst for low-temperature SCR

DOI：10.11949/0438-1157.20190318

摘要

Abstract

关键词

Keywords

references

Fe_xMnCe₁-AC低温SCR催化剂SO₂中毒机理研究

Mechanism study on SO₂ poisoning of Fe_xMnCe₁-AC catalyst for low-temperature SCR