不同温度下煤灰熔渣的结构演变规律

王浩男; 玄伟伟; 夏德宏

doi:10.11949/0438-1157.20190310

您当前的位置：

首页 >

文章列表页 >

不同温度下煤灰熔渣的结构演变规律

更新时间：2026-07-24

- 不同温度下煤灰熔渣的结构演变规律
- Structural evolution of coal ash slag at different temperatures
- 化工学报 2019年70卷第8期页码：3094-3103
- 作者机构：
  
  北京科技大学能源与环境工程学院，北京 100083
- 作者简介：
  
  王浩男（1994—），男，硕士研究生，s20170164@xs.ustb.edu.cn
  玄伟伟（1988—），女，博士，讲师，xww@ustb.edu.cn
- 基金信息：
  
  国家自然科学基金项目(51606009);中央高校基本业务费项目(FRF-TP-18-017A2)
- DOI：10.11949/0438-1157.20190310
  中图分类号： TQ 546.4
- 收稿：2019-04-01，
  
  修回：2019-05-09，
  
  网络首发：2026-07-24，
  
  纸质出版：2019-08-05
- 稿件说明：
移动端阅览
王浩男, 玄伟伟, 夏德宏. 不同温度下煤灰熔渣的结构演变规律[J]. 化工学报, 2019, 70(8): 3094-3103

WANG Haonan, XUAN Weiwei, XIA Dehong. Structural evolution of coal ash slag at different temperatures[J]. CIESC Journal, 2019, 70(8): 3094-3103
王浩男, 玄伟伟, 夏德宏. 不同温度下煤灰熔渣的结构演变规律[J]. 化工学报, 2019, 70(8): 3094-3103 DOI： 10.11949/0438-1157.20190310.

WANG Haonan, XUAN Weiwei, XIA Dehong. Structural evolution of coal ash slag at different temperatures[J]. CIESC Journal, 2019, 70(8): 3094-3103 DOI： 10.11949/0438-1157.20190310.

摘要

采用热力学计算和分子动力学模拟方法研究了高铁煤灰熔体的结构特征以及结构随温度的变化规律，计算了不同温度下Fe

和Fe

的含量，分析了径向分布函数、配位数、键角、桥氧与非桥氧、Q

结构单元等结构特征。热力学计算的结果显示温度升高有利于Fe

转变成Fe

，据此得到了Fe

/Fe

随温度的变化规律。在采用BMH势函数的基础上，分子动力学模拟显示熔体具有短程有序，长程无序的结构特征。随着温度升高，各离子对的径向分布函数曲线的高度和尖锐度下降，各离子的较高配位状态减少，较低配位状态增加，键角曲线的高度和锐度降低并向较小的方向移动，预示着离子的聚集程度减弱，熔体内部的无序化程度增强。氧的配位状态和Q

的变化是熔体聚合度变化的直观反映，温度升高导致三配位氧和桥氧含量降低，非桥氧和自由氧含量增加，并最终导致较高聚合度的Q

结构单元解体生成较低聚合度的Q

、Q

和Q

结构单元。

Abstract

The structural characteristics of high iron coal ash melt and the variation of structure with temperature were studied by thermodynamic calculation and molecular dynamics simulation. The contents of Fe

and Fe

at different temperatures were calculated

and the radial distribution function

coordination number

bond angle

coordination state of oxygen and Q

structural units were analyzed. The results of thermodynamic calculations show that the increase of temperature is beneficial to the conversion of Fe

to Fe

and the change of Fe

/Fe

with temperature is obtained. Based on the BMH potential function

molecular dynamics simulations show that the melt has short-range order and long-range disordered structural features. As the temperature increases

the height and sharpness of the radial distribution function curve of each ion pair decrease

the higher coordination state of each ion decreases and the lower coordination state increases

the height and sharpness of the bond angle curve decrease and the first peak moves in a smaller direction. These phenomena all indicate that the

degree of aggregation of ions is weakened

and the degree of disorder inside the melt is enhanced. The coordination state of oxygen and the change of Q

are a direct reflection of the change of melt polymerization degree. The increase of temperature leads to the decrease of tri-coordinate oxygen and bridge oxygen

and the increase of non-bridge oxygen and free oxygen. Q

structural unit disintegrated to generate Q

and Q

structural units with lower degree of polymerization.

关键词

Keywords

references

袁悦婷 , 袁秋华 , 李伟斌 , 等 . 煤气化技术及气化炉实际应用现状综述 [J ] . 化工设计通讯 , 2019 , 45 ( 1 ): 15+44 .

Yuan Y T , Yuan Q H , Li W B , et al . Summary of actual application status of coal gasification technology and gasifier [J ] . Chemical Engineering Design Communications , 2019 , 45 ( 1 ): 15+44 .

王殿生 . 大型煤气化技术的研究与发展 [J ] . 化工设计通讯 , 2018 , 44 ( 2 ): 11 .

Wang D S . Research and development of large-scale coal gasification technology [J ] . Chemical Engineering Design Communications , 2018 , 44 ( 2 ): 11 .

李文 , 白进 . 煤的灰化学 [M ] . 北京 : 科学出版社 , 2013 .

Li W , Bai J . Coal Ash Chemistry [M ] . Beijing : Science Press , 2013 .

Liao J , Zhang Y , Sridhar S , et al . Effect of Al 2 O 3 /SiO 2 ratio on the viscosity and structure of slags [J ] . ISIJ International , 2012 , 52 ( 5 ): 753 - 758 .

Zhang S , Zhang X , Liu W , et al . Relationship between structure and viscosity of CaO-SiO 2 -Al 2 O 3 -MgO-TiO 2 slag [J ] . Journal of Non-Crystalline Solids , 2014 , 402 : 214 - 222 .

Wu T , He S , Liang Y , et al . Molecular dynamics simulation of the structure and properties for the CaO–SiO 2 and CaO–Al 2 O 3 systems [J ] . Journal of Non-Crystalline Solids , 2015 , 411 : 145 - 151 .

Xuan W , Zhang J , Xia D . The influence of MgO on the crystallization characteristics of synthetic coal slags [J ] . Fuel , 2018 , 222 : 523 - 528 .

Xuan W , Wang Q , Zhang J , et al . Influence of silica and alumina (SiO 2 +Al 2 O 3 ) on crystallization characteristics of synthetic coal slags [J ] . Fuel , 2017 , 189 : 39 - 45 .

Xuan W , Whitty K J , Guan Q , et al . Influence of SiO 2 /Al 2 O 3 on crystallization characteristics of synthetic coal slags [J ] . Fuel , 2015 , 144 : 103 - 110 .

Xuan W W , Wang H N , Xia D H . Deep structure analysis on coal slags with increasing silicon content and correlation with melt viscosity [J ] . Fuel , 2019 , 242 : 362 - 367 .

Xuan W W , Wang H N , Xia D H . Depolymerization mechanism of CaO on network structure of synthetic coal slags [J ] . Fuel Process. Technol ., 2019 , 187 : 21 - 27 .

Wang C H , Lin X C , Sa-Sha Y , et al . Evaluation of the thermal and rheological characteristics of minerals in coal using SiO 2 -Al 2 O 3 -CaO-FeO x quaternary system [J ] . Journal of Fuel Chemistry and Technology , 2016 , 44 ( 9 ): 1025 - 1033 .

Knipping J L , Behrens H , Wilke M , et al . Effect of oxygen fugacity on the coordination and oxidation state of iron in alkali bearing silicate melts [J ] . Chemical Geology , 2015 , 411 : 143 - 154 .

Lin X , Ideta K , Miyawaki J , et al . Correlation between fluidity properties and local structures of three typical Asian coal ashes [J ] . Energy & Fuels , 2012 , 26 ( 4 ): 2136 - 2144 .

Jiang Y , Lin X , Ideta K , et al . Microstructural transformations of two representative slags at high temperatures and effects on the viscosity [J ] . Journal of Industrial and Engineering Chemistry , 2014 , 20 ( 4 ): 1338 - 1345 .

Bale C W , Bélisle E , Chartrand P , et al . FactSage thermochemical software and databases — recent developments [J ] . CALPHAD: Computer Coupling of Phase Diagrams and Thermochemistry , 2009 , 33 ( 2 ): 295 - 311 .

王锦团 , 张乐 , 任钟元 , 等 . 气体混合炉中氧逸度控制 [J ] . 地球化学 , 2016 , 45 : 475 - 485 .

Wang J T , Zhang L , Ren Z Y , et al . Oxygen fugacity control in gas mixing furnace [J ] . Geochemistry , 2016 , 45 : 475 - 485 .

Jayasuriya K D , OʼNeill H , St C , Berry A J , et al . A Mössbauer study of the oxidation state of Fe in silicate melts [J ] . American Mineralogist , 2015 , 89 ( 11 ): 1597 - 1609

Sack R O , Carmichael I S E , Rivers M , et al . Ferric-ferrous equilibria in natural silicate liquids at 1 bar [J ] . Contributions to Mineralogy & Petrology , 1981 , 75 ( 4 ): 369 - 376 .

Karalis K T , Dellis D , Antipas G S E , et al . Bona-fide method for the determination of short range order and transport properties in a ferro-aluminosilicate slag [J ] . Scientific Reports , 2016 , 6 : 30216 .

Guillot B , Sator N . A computer simulation study of natural silicate melts (Ⅰ): Low pressure properties [J ] . Geochimica et Cosmo-chimica Acta , 2007 , 71 ( 5 ): 1249 - 1265 .

严六明 , 朱素华 . 分子动力学模拟的理论与实践 [M ] . 北京 : 科学出版社 , 2013 .

Yan L M , Zhu S H . Theory and Practice of Molecular Dynamics Simulation [M ] . Beijing : Science Press , 2013

Hennet L , Drewitt J W E , Neuville D R , et al . Neutron diffraction of calcium aluminosilicate glasses and melts [J ] . Journal of Non-Crystalline Solids , 2016 , 451 : 89 - 93 .

Wagner J , Haigis V , Leydier M , et al . The structure of Y- and La-bearing aluminosilicate glasses and melts: a combined molecular dynamics and diffraction study [J ] . Chemical Geology , 2016 , 461 : 23 - 33 .

Wu T , Wang Q , Yu C , et al . Structural and viscosity properties of CaO-SiO 2 -Al 2 O 3 -FeO slags based on molecular dynamic simulation [J ] . Journal of Non-Crystalline Solids , 2016 , 450 : 23 - 31 .

徐利莹 , 王秀丽 , 吴永全 , 等 . 铝硅酸钙熔体中氧原子的配位性质及动力学 [J ] . 硅酸盐学报 , 2006 , ( 9 ): 1117 - 1123 .

Xu L Y , Wang X L , Wu Y Q , et al . Coordination properties and kinetics of oxygen atoms in calcium aluminosilicate melts [J ] . Journal of Silicate , 2006 , ( 9 ): 1117 - 1123 .

Mills K C , Hayashi M , Wang L , et al . Chapter 2.2—the structure and properties of silicate slags [J ] . Treatise on Process Metallurgy , 2014 , 14 ( 8 ): 149 - 286 .

Mills K C . The estimation of slag properties [D ] . London : Imperial College , 2011 .

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

煤气化熔渣结构的多尺度研究进展

理论计算在药物制剂设计中的研究进展

基于分子动力学的橡胶聚合物计算机辅助设计方法

大语言模型驱动的分子模拟智能体：从自动化到智能化

TPMS-Diamond静态混合器停留时间分布特性研究