双缸滚动转子式压缩机采暖热泵低温制热性能

尹应德; 朱冬生; 刘世杰; 叶周; 王飞扬

doi:10.11949/0438-1157.20190247

您当前的位置：

首页 >

文章列表页 >

双缸滚动转子式压缩机采暖热泵低温制热性能

流体力学与传递现象 | 更新时间：2020-06-24

- 双缸滚动转子式压缩机采暖热泵低温制热性能
- Heating performance of space heating heat pump based on dual-cylinder rotary compressor in ultra-low temperature
- 化工学报 2019年70卷第S2期页码：220-227
- 作者机构：
  
  1.中国科学院广州能源研究所,广东广州 510640
  2.中国科学院可再生能源重点实验室,广东广州 510640
  3.广东省新能源和可再生能源研究开发与应用重点实验室，广东广州 510640
- 作者简介：
  
  尹应德（1978—），男，博士，工程师，yinyd@ms.giec.ac.cn
- 基金信息：
  
  湖北省中国科学院科技合作专项项目(2018-916-000-009);中国科学院可再生能源重点实验室基金项目;2017佛山市顺德区科技计划项目;2017容桂科技计划项目(容桂经发〔2017〕27号)
- DOI：10.11949/0438-1157.20190247
  中图分类号： TB 61⁺5
- 收稿：2019-03-18，
  
  修回：2019-06-14，
  
  纸质出版：2019-09-05
- 稿件说明：
移动端阅览
尹应德, 朱冬生, 刘世杰, 叶周, 王飞扬. 双缸滚动转子式压缩机采暖热泵低温制热性能[J]. 化工学报, 2019, 70(S2): 220-227

YIN Yingde, ZHU Dongsheng, LIU Shijie, YE Zhou, WANG Feiyang. Heating performance of space heating heat pump based on dual- cylinder rotary compressor in ultra-low temperature[J]. CIESC Journal, 2019, 70(S2): 220-227
尹应德, 朱冬生, 刘世杰, 叶周, 王飞扬. 双缸滚动转子式压缩机采暖热泵低温制热性能[J]. 化工学报, 2019, 70(S2): 220-227 DOI： 10.11949/0438-1157.20190247.

YIN Yingde, ZHU Dongsheng, LIU Shijie, YE Zhou, WANG Feiyang. Heating performance of space heating heat pump based on dual- cylinder rotary compressor in ultra-low temperature[J]. CIESC Journal, 2019, 70(S2): 220-227 DOI： 10.11949/0438-1157.20190247.

摘要

对双缸滚动转子式压缩机采暖热泵在环境温度（

）为-30～0℃，出水温度（

）为41～50℃范围内的制热进行测试。研究表明：外界环境温度对排气温度、蒸发温度影响很大，对冷凝温度影响很小；热水出水温度对冷凝温度影响很大，对排气温度、蒸发温度影响很小。随着外界环境温度的降低，采暖热泵的制热量急剧下降，当

=41℃时，

从0℃下降到-30℃，制热量的降幅达62.16%；随着出水温度的升高，采暖热泵的制热量下降缓慢，当

=0℃时，

从41℃上升到45℃，制热量降幅仅为5.61%；外界环境温度对COP

值的影响也显著，当

=41℃时，

从0℃下降到-30℃，COP

值从2.94下降到1.38，降幅达53.06%。双缸滚动转子式压缩机采暖热泵应用于-30～0℃的低温工况下，具有良好的实用价值。

Abstract

The heating performance of space heating heat pump (SHHP) with dual-cylinder rotary compressor was tested at low ambient temperature (

) in the range of -30—0℃

and water outlet temperature (

) in the range of 41—50℃. The results show that ambient temperature has great influence on its discharge temperature and evaporating temperature

but little on condensing temperature; hot water outlet temperature has great influence on its condensing temperature

and little influence on its discharge temperature and evaporating temperature. With the decrease of ambient temperature

the heat capacity of SHHP decreases sharply

when

= 41℃

decreases from 0℃ to -30℃

and the heat capacity decreases by 62.16%. With the increase of outlet temperature

the heat capacity of SHHP decreases slowly

when

= 0℃

rises from 41℃ to 45℃

the heat capacity decreases by only 5.61%. The influence of ambient temperature on COP

value is also obvious

when

= 41℃

decreases from 0℃ to -30℃

COP

decreases from 2.94 to 1.38

a drop of 53.06%. The SHHP with dual-cylinder rotary compressor has good practical value to be applied in low temperature condition of -30—0℃.

关键词

Keywords

references

江亿 , 杨旭东 , 单明 , 等 . 中国建筑节能年度发展研究报告2016 [M]. 北京 : 中国建筑工业出版社 , 2016 : 7 - 15 .

Jiang Y , Yang X D , Shan M , et al . Annual Report on China Energy Efficiency 2016 [M]. Beijing : China Architecture & Building Press , 2016 : 7 - 15 .

生态环境部就 2018 年— 2019 年打赢蓝天保卫战重点区域强化督查答问 [EB/OL].[2018-06-09] . http: // www. gov.cn/ hudong/ 2018-06/09/content_5297458.htm www. gov.cn/ hudong/ 2018-06/09/content_5297458.htm

Question and Answer by the Ministry of Ecology and Environment on Strengthening Supervision over Key Areas of Winning the Blue Sky Defense War from 2018 to 2019 [EB/OL]. [2018-06-09] . http: // www.gov.cn/hudong/2018-06/09/ content_5297 458. htm www.gov.cn/hudong/2018-06/09/ content_5297 458. htm

王沣浩 , 王志华 , 郑煜鑫 , 等 . 低温环境下空气源热泵的研究现状及展望 [J]. 制冷学报 , 2013 , 34 ( 5 ): 47 - 54 .

Wang F H , Wang Z H , Zheng Y X , et al . Research progress and prospect of air source heat pump in low temperature environment [J]. Journal of Refrigeration , 2013 , 34 ( 5 ): 47 - 54 .

Long Z , Yi Q J , Jian K D , et al . Advances in vapor compression air source heat pump system in cold regions: a review [J]. Renew. Sust. Energ. Rev ., 2018 , 81 : 353 - 365 .

Ma G Y , Zhao H X . Experimental study of a heat pump system with flash-tank coupled with scroll compressor [J]. Energ. Buildings , 2008 , 40 ( 5 ): 697 - 701 .

Heo J , Min W J , Baek C , et al . Comparison of the heating performance of air-source heat pumps using various types of refrigerant injection [J]. Int. J. Refrig ., 2011 , 34 ( 2 ): 444 - 453 .

Lyu X , Yan G , Yu J . Solar-assisted auto-cascade heat pump cycle with zeotropic mixture R32/R290 for small water heaters [J]. Renew. Energ ., 2015 , 76 : 167 - 172 .

Adhikari R S , Aste N , Manfren M , et al . Energy savings through variable speed compressor heatpump systems [J]. Energy Procedia , 2012 , 14 : 1337 - 1342 .

Banister C J , Collins M R . Development and performance of a dual tank solar-assisted heat pump system [J]. Appl. Energ ., 2015 , 149 : 125 - 132 .

Ko Y , Park S , Jin S , et al . The selection of volume ratio of two-stage rotary compressor and its effects on air-to-water heat pump with flash tank cycle [J]. Appl. Energ ., 2013 , 104 : 187 - 196 .

Yan G , Jia Q , Bai T . Experimental investigation on vapor injection heat pump with a newly designed twin rotary variable speed compressor for cold regions [J]. Int. J. Refrig ., 2016 , 62 : 232 - 241 .

王宝龙 , 韩林俊 , 石文星 , 等 . 基于制冷剂泄出的涡旋压缩机容量调节技术 [J]. 制冷学报 , 2010 , 31 ( 2 ): 7 - 10 .

Wang B L , Han L J , Shi W X , et al . Modulating technology for scroll compressor with refrigerant release [J]. Journal of Refrigeration , 2010 , 31 ( 2 ): 7 - 10 .

张海锋 . R410A直流变频旋转压缩机年度运行效率及可靠性研究 [D]. 西安 : 西安交通大学 , 2013 .

Zhang H F . Study on the annual efficiency and reliability of R410A variable speed rotary compressors [D]. Xi’an : Xi’an Jiaotong University , 2013 .

马敏 , 黄波 , 耿玮 , 等 . 滚动转子式补气压缩机在热泵系统中的实验研究 [J]. 制冷学报 , 2012 , 33 ( 4 ): 52 - 54 .

Ma M , Huang B , Geng W , et al . Performance investigation of the vapor-injection rotary compressor for residential heat pump Systems [J]. Journal of Refrigeration , 2012 , 33 ( 4 ): 52 - 54 .

贾庆磊 , 冯利伟 , 晏刚 . 带中间补气的滚动转子式压缩系统制热性能的实验研究 [J]. 制冷学报 , 2015 , 36 ( 2 ): 65 - 70 .

Jia Q L , Feng L W , Yan G , et al . Experimental research on heating performance of rotary compression system with vapor injection [J]. Journal of Refrigeration , 2015 , 36 ( 2 ): 65 - 70 .

Baek C , Heo J , Jung J . Effects of the cylinder volume ratio of a twin rotary compressor on the heating performance of a vapor injection CO 2 cycle [J]. Appl. Therm. Eng ., 2014 , 67 : 89 - 96 .

Heo J , Min W J , Baek C , et al . Comparison of the heating performance of air-source heat pumps using various types of refrigerant injection [J]. Int. J. Refrig ., 2011 , 34 ( 2 ): 444 - 453 .

Heo J , Min W J , KimY . Effects of flash tank vapor injection on the heating performance of an inverter-driven heat pump for cold regions [J]. Int. J. Refrig ., 2010 , 33 ( 4 ): 848 - 855 .

Heo J , Yun R , Kim Y . Simulations on the performance of a vapor-injection heat pump for different cylinder volume ratios of a twin rotary compressor [J]. Int. J. Refrig ., 2013 , 36 ( 3 ): 730 - 744 .

Heo J , Kang H , Kim Y . Optimum cycle control of a two-stage injection heat pump with a double expansion sub-cooler [J]. Int. J. Refrig ., 2012 , 35 ( 1 ): 58 - 67 .

吴建华 , 胡杰浩 , 陈昂 , 等 . 全封闭R32 滚动活塞压缩机的热分析 [J]. 西安交通大学学报 , 2015 , 49 ( 3 ): 14 - 18 .

Wu J H , Hu J H , Chen A , et al . Thermal analysis for hermetic R32 rolling piston compressor [J]. Journal of Xi’an Jiaotong University , 2015 , 49 ( 3 ): 14 - 18 .

虞中旸 , 陶乐仁 , 何俊 , 等 . R32变频滚动转子压缩机变工况模型及运行特性 [J]. 制冷学报 , 2018 , 39 ( 3 ): 58 - 64 .

Yu Z Y , Tao L R , He J , et al . R32 operation performance and modeling for R32 variable frequency rotary compressor under varied operating conditions [J]. Journal of Refrigeration , 2018 , 39 ( 3 ): 58 - 64 .

刘琦 , 马国远 , 许树学 . 单机双级滚动活塞压缩机热泵系统的性能特性 [J]. 化工学报 , 2013 , 64 ( 10 ): 3599 - 3605 .

Liu Q , Ma G Y , Xu S X . Performance characteristics of two-stage compression heat pump system coupled with dual-cylinder rolling piston compressor [J]. CIESC Journal , 2013 , 64 ( 10 ): 3599 - 3605 .

孙晋飞 , 朱冬生 , 尹应德 , 等 . 单缸补气转子式压缩机在热泵系统中制热性能分析 [J]. 化工学报 , 2017 , 68 ( 9 ): 3551 - 3557 .

Sun J F , Zhu D S , Yin Y D , et al . Heating performance of single cylinder vapor injection rotary compressor applying in air-source heat pump system [J]. CIESC Journal , 2017 , 68 ( 9 ): 3551 - 3557 .

尹应德 , 朱冬生 , 孙晋飞 , 等 . 基于准二级压缩空气源热泵热水器的热力性能实验研究 [J]. 高校化学工程学报 , 2018 , 32 ( 1 ): 77 - 83 .

Yin Y D , Zhu D S , Sun J F . Experimental study on thermodynamic performance of air source heat pump water heaters based on quasi two stage compression [J]. Journal of Chemical Engineering of Chinese Universities , 2018 , 32 ( 1 ): 77 - 83 .

孙晋飞 , 朱冬生 , 李修真 , 等 . 基于滚动转子式补气压缩机的准二级压缩热泵系统热力学分析 [J]. 高校化学工程学报 , 2018 , 32 ( 3 ): 499 - 506 .

Sun J F , Zhu D S , Li X Z , et al . Thermodynamic analysis of quasi two-stage compression heat pump with a vapor injection rotary compressor [J]. Journal of Chemical Engineering of Chinese Universities , 2018 , 32 ( 3 ): 499 - 506 .

Sun J F , Zhu D S , Yin Y D , et al . Experimental investigation of the heating performance of refrigerant injection heat pump with a single-cylinder inverter-driven rotary compressor [J]. J. Therm. Anal. Calorim ., 2018 , 133 ( 3 ): 1579 - 1588 .

Sun J F , Zhu D S , Yin Y D , et al . Experimental research on the heating performance of a single cylinder refrigerant injection rotary compressor heat pump with flash tank [J]. Sci. China Technol. Sci ., 2018 , 61 ( 12 ): 1814 - 1823 .

马国远 . 制冷压缩机及其应用 [M]. 北京 : 中国建筑工业出版社 , 2008 : 4 - 6 .

Ma G Y . Refrigeration Compressor and Application [M]. Beijing : China Architecture& Building Press , 2008 : 4 - 6 .

张秀平 , 王汝金 , 昝世超 , 等 . 蒸气压缩循环冷水(热泵)机组性能试验方法(GBT 10870—2014) [S]. 北京 : 中国标准出版社 , 20144 - 8 .

Zhang X P , Wang R J , Zan S C , et al . The methods of performance test for water chilling (heat pump) packages using the vapor compression cycle (GBT 10870—2014) [S]. Beijing : China Standard Press , 20144 - 8 .

Moffat R J . Using uncertainty analysis in the planning of an experiment [J]. J. Fluid Eng ., 1985 , 107 ( 2 ): 173 - 178 .

Kline S J , Mcclintock F A . Describing uncertainties in single-sample experiment [J]. ASME Mechanical Engineering , 1953 , 75 : 3 - 8 .

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

储能电池直冷热管理系统的模拟实验

基于自驱射流装置的强化池沸腾换热研究

内管移动对卧式管壳相变储热器储放热性能影响的实验研究

石蜡/TPMS结构多孔AlSi10Mg合金复合相变材料蓄热性能实验研究

基于热质传递效应的准稳态结霜模型改进及数值验证