微反应器内CO<sub>2</sub>解吸过程流动行为及气提强化

刘宏臣; 周峰; 尧超群; 陈光文

doi:10.11949/0438-1157.20190142

您当前的位置：

首页 >

文章列表页 >

微反应器内CO₂解吸过程流动行为及气提强化

流体力学与传递现象 | 更新时间：2026-07-24

- 微反应器内CO₂解吸过程流动行为及气提强化
- Flow behavior and stripping enhancement of CO₂ desorption process in microreactor
- 化工学报 2019年70卷第7期页码：2448-2455
- 作者机构：
  
  1.中国科学院大连化学物理研究所，辽宁大连 116023
  2.西安工程大学环境与化学工程学院，陕西西安 710048
- 作者简介：
  
  刘宏臣（1989—），男，博士研究生，讲师，liuhc1108@163.com
  陈光文（1967—），男，博士，研究员，gwchen@dicp.ac.cn
- 基金信息：
  
  中国科学院青年创新促进会项目(2017229);科技部重点领域创新团队项目(2016RA4053)
- DOI：10.11949/0438-1157.20190142
  中图分类号： TQ 028.3
- 收稿：2019-02-22，
  
  修回：2019-04-12，
  
  网络首发：2026-07-24，
  
  纸质出版：2019-07-05
- 稿件说明：
移动端阅览
刘宏臣, 周峰, 尧超群, 陈光文. 微反应器内CO₂解吸过程流动行为及气提强化[J]. 化工学报, 2019, 70(7): 2448-2455 DOI: 10.11949/0438-1157.20190142.

LIU Hongchen, ZHOU Feng, YAO Chaoqun, CHEN Guangwen. Flow behavior and stripping enhancement of CO₂ desorption process in microreactor[J]. CIESC Journal, 2019, 70(7): 2448-2455 DOI: 10.11949/0438-1157.20190142.
刘宏臣, 周峰, 尧超群, 陈光文. 微反应器内CO₂解吸过程流动行为及气提强化[J]. 化工学报, 2019, 70(7): 2448-2455 DOI: 10.11949/0438-1157.20190142. DOI：

LIU Hongchen, ZHOU Feng, YAO Chaoqun, CHEN Guangwen. Flow behavior and stripping enhancement of CO₂ desorption process in microreactor[J]. CIESC Journal, 2019, 70(7): 2448-2455 DOI: 10.11949/0438-1157.20190142. DOI：

摘要

研究了微反应器内

-甲基二乙醇胺溶液解吸过程的流动和气提强化行为。观测到解吸过程中气-液两相流型主要有泡状流、弹状流、环状流和细环流。高温时，流型交替演化将导致气泡速度波动。气提促进强化CO

解吸过程的结果表明，低溶液流量时，少量惰性气体就可显著提高CO

解吸速率；大惰性气体流量将缩短停留时间，经计算解吸强化效率，确定了解吸过程的最佳气提流量。

Abstract

The flow pattern and stripping enhancement of CO

desorption from

-methyldiethanolamine solution were investigated in microreactor. It is observed that the gas-liquid two-phase flow patterns in the desorption process mainly include bubble flow

slug flow

annular flow and fine circulation. However

the periodic change of flow patterns resulted in the fluctuation of bubble velocity at high temperature. According to the results of stripping enhancement on the CO

desorption

it showed that CO

desorption rate was significantly enhanced at low solution rate by adding small amount of inert gas

while excessive gas will lead to a reduction in the solution residence time. The optimal inert gas flow rate was determined by calculating the stripping enhancement per unit gas flow rate.

关键词

Keywords

references

Pachauri R K , Allen M , Barros V , et al . Climate Change 2014: Synthesis Report. Contribution of Working Groups I , II and III to the Fifth Assessment Report of the Intergovernmental Panel on Climate Change , IPCC2014 [R ] .

Rochelle G T . Amine scrubbing for CO 2 capture [J ] . Science , 2009 , 325 ( 5948 ): 1652 - 1654 .

Li B Y , Duan Y H , Luebke D , et al . Advances in CO 2 capture technology: a patent review [J ] . Applied Energy , 2013 , 102 : 1439 - 1447 .

Li T Y , Keener T C . A review: desorption of CO 2 from rich solutions in chemical absorption processes [J ] . Int . J . Greenhouse Gas Control , 2016 , 51 : 290 - 304 .

Mondal M K , Balsora H K , Varshney P . Progress and trends in CO 2 capt ure/separation technologies: a review [J ] . Energy , 2012 , 46 ( 1 ): 431 - 441 .

Aaron D , Tsouris C . Separation of CO 2 from flue gas: a review [J ] . Sep. Sci. Technol ., 2005 , 40 ( 1 / 2 / 3 ): 321 - 348 .

Haszeldine R S . Carbon capture and storage: how green can black be? [J ] . Science , 2009 , 325 ( 5948 ): 1647 - 1652 .

Abu-Zahra M R M , Niederer J P M , Feron P H M , et al . CO 2 capture from power plants (Ⅱ): A parametric study of the economical performance based on mono-ethanolamine [J ] . Int . J . Greenhouse Gas Control , 2007 , 1 ( 2 ): 135 - 142 .

Bieringer T , Buchholz S , Kockmann N . Future production concepts in the chemical industry: modular-small-scale-continuous [J ] . Chemical Engineering & Technology , 2013 , 36 ( 6 ): 900 - 910 .

Yao C Q , Dong Z Y , Zhao Y C , et al . Gas-liquid flow and mass transfer in a microchannel under elevated pressures [J ] . Chem. Eng. Sci ., 2015 , 123 : 137 - 145 .

Chen G W , Yue J , Yuan Q . Gas-liquid microreaction technology: recent developments and future challenges [J ] . Chin . J . Chem . Eng ., 2008 , 16 ( 5 ): 663 - 669 .

陈光文 , 赵玉潮 , 乐军 , 等 . 微化工过程中的传递现象 [J ] . 化工学报 , 2013 , 64 ( 1 ): 63 - 75 .

Chen G W , Zhao Y C , Yue J , et al . Transport phenomena in micro-chemical engineering [J ] . CIESC Journal , 2013 , 64 ( 1 ): 63 - 75 .

董正亚 , 陈光文 , 赵帅南 , 等 . 声化学微反应器——超声和微反应器协同强化 [J ] . 化工学报 , 2018 , 69 ( 1 ): 102 - 115 .

Dong Z Y , Chen G W , Zhao S N , et al . Sonochemical microreactor — synergistic intensification ofultrasound and microreactor [J ] . CIESC Journal , 2018 , 69 ( 1 ): 102 - 115 .

Zhao S N , Dong Z Y , Yao C Q , et al . Liquid-liquid two-phase flow in ultrasonic microreactors: cavitation, emulsification, and mass transfer enhancement [J ] . AIChE Journal , 2018 , 64 ( 4 ): 1412 - 1423 .

Zanfir M , Gavriilidis A , Wille C , et al . Carbon dioxide absorption in a falling film microstructured reactor: experiments and modeling [J ] . Industrial & Engineering Chemistry Research , 2005 , 44 ( 6 ): 1742 - 1751 .

Constantinou A , Barrass S , Pronk F , et al . CO 2 absorption in a high efficiency silicon nitride mesh contactor [J ] . Chem. Eng. J ., 2012 , 207 : 766 - 771 .

Ye C B , Chen G W , Yuan Q . Process characteristics of CO 2 absorption by aqueous monoethanolamine in a microchannel reactor [J ] . Chin . J . Chem . Eng ., 2012 , 20 ( 1 ): 111 - 119 .

Tegrotenhuis W , Cameron R , Viswanathan V , et al . Solvent extraction and gas absorption using microchannel contactors [M ] //Microreaction Technology : Industrial Prospects.Berlin : Springer , 2000 : 541 - 549 .

Lin G Y , Jiang S , Zhu C Y , et al . Mass transfer characteristics of CO 2 absorption into aqueous solutions of N -methyldiethanolamine+diethanolamine in a T-junction microchannel [J ] . ACS Sustainable Chem. Eng ., 2019 , 7 ( 4 ): 4368 - 4375 .

Kenig E Y , Su Y H , Lautenschleger A , et al . Micro-separation of fluid systems: a state-of-the-art review [J ] . Sep. Sci. Technol ., 2013 , 120 : 245 - 264 .

Nguyen D T , Esser-kahn A P . A microvascular system for chemical reactions using surface waste heat [J ] . Angew. Chem. Int. Ed ., 2013 , 52 ( 51 ): 13731 - 13734 .

Liu H C , Yao C Q , Zhao Y C , et al . Desorption of carbon dioxide from aqueous MDEA solution in a microchannel reactor [J ] . Chem. Eng. J ., 2017 , 307 : 776 - 784 .

Liu H C , Zhao S N , Zhou F , et al , Ultrasonic enhancement of CO 2 desorption from MDEA solution in microchannels [J ] . Ind. Eng. Chem. Res., 2019 , 58 ( 4 ): 1711 - 1719 .

Zhang J F , Qiao Y , Agar D W . Intensification of low temperature thermomorphic biphasic amine solvent regeneration for CO 2 capture [J ] . Chemical Engineering Research and Design , 2012 , 90 ( 6 ): 743 - 749 .

Shao N , Gavriilidis A , Angeli P . Flow regimes for adiabatic gas-liquid flow in microchannels [J ] . Chem. Eng. Sci ., 2009 , 64 ( 11 ): 2749 - 2761 .

Zhao Y C , Chen G W , Ye C B , et al . Gas-liquid two-phase flow in microchannel at elevated pressure [J ] . Chem. Eng. Sci ., 2013 , 87 : 122 - 132 .

Triplett K , Ghiaasiaan S , Abdel-khalik S , et al . Gas-liquid two-phase flow in microchannels (Ⅰ): Two-phase flow patterns [J ] . Int . J . Multiphase Flow , 1999 , 25 ( 3 ): 377 - 394 .

Yue J , Chen G W , Yuan Q , et al . Hydrodynamics and mass transfer characteristics in gas-liquid flow through a rectangular microchannel [J ] . Chem. Eng. Sci ., 2007 , 62 ( 7 ): 2096 - 2108 .

Cubaud T , Ho C M . Transport of bubbles in square microchannels [J ] . Physics of Fluids , 2004 , 16 ( 12 ): 4575 - 4585 .

Wu H , Cheng P . Visualization and measurements of periodic boiling in silicon microchannels [J ] . Int . J . Heat Mass Transfer , 2003 , 46 ( 14 ): 2603 - 2614 .

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

MEA吸收CO2富液解吸过程中固体颗粒表面的强化作用分析

基于富氮席夫碱网络聚合物的混合基质膜及其CO2分离性能

考虑延迟特性的电厂-碳捕集系统优化调度

用于CO2捕集的UiO-66-NH2@PVAm混合基质膜制备工艺开发

带有突扩比的新型流道结构对海水激活电池性能的影响

微反应器内CO2解吸过程流动行为及气提强化

Flow behavior and stripping enhancement of CO2 desorption process in microreactor

DOI：10.11949/0438-1157.20190142

摘要

Abstract

关键词

Keywords

references

微反应器内CO₂解吸过程流动行为及气提强化

Flow behavior and stripping enhancement of CO₂ desorption process in microreactor