预混气体爆炸火焰与压力的耦合振荡特性

时高龙; 温小萍; 王发辉; 裴蓓; 潘荣锟; 刘志超; 陈卫

doi:10.11949/0438-1157.20190070

您当前的位置：

首页 >

文章列表页 >

预混气体爆炸火焰与压力的耦合振荡特性

过程安全 | 更新时间：2026-07-24

- 预混气体爆炸火焰与压力的耦合振荡特性
- Coupling oscillation characteristics of premixed gas explosion flame and pressure
- 化工学报 2019年70卷第7期页码：2811-2818
- 作者机构：
  
  1.河南理工大学机械与动力工程学院，河南焦作 454003
  2.河南理工大学安全科学与工程学院，河南焦作 454003
- 作者简介：
  
  时高龙（1993—），男，硕士研究生，1013402675@qq.com
  温小萍（1977—），男，博士，副教授，wenxiaoping666@163.com
- 基金信息：
  
  国家重点研发计划项目(2018YFC0808103)
- DOI：10.11949/0438-1157.20190070
  中图分类号： TD 712
- 收稿：2019-01-22，
  
  修回：2019-04-19，
  
  网络首发：2026-07-24，
  
  纸质出版：2019-07-05
- 稿件说明：
移动端阅览
时高龙, 温小萍, 王发辉, 裴蓓, 潘荣锟, 刘志超, 陈卫. 预混气体爆炸火焰与压力的耦合振荡特性[J]. 化工学报, 2019, 70(7): 2811-2818

SHI Gaolong, WEN Xiaoping, WANG Fahui, PEI Bei, PAN Rongkun, LIU Zhichao, CHEN Wei. Coupling oscillation characteristics of premixed gas explosion flame and pressure[J]. CIESC Journal, 2019, 70(7): 2811-2818
时高龙, 温小萍, 王发辉, 裴蓓, 潘荣锟, 刘志超, 陈卫. 预混气体爆炸火焰与压力的耦合振荡特性[J]. 化工学报, 2019, 70(7): 2811-2818 DOI： 10.11949/0438-1157.20190070.

SHI Gaolong, WEN Xiaoping, WANG Fahui, PEI Bei, PAN Rongkun, LIU Zhichao, CHEN Wei. Coupling oscillation characteristics of premixed gas explosion flame and pressure[J]. CIESC Journal, 2019, 70(7): 2811-2818 DOI： 10.11949/0438-1157.20190070.

摘要

为研究预混气体爆炸火焰和压力的耦合振荡特性，自行搭建了尺寸为80 mm×80 mm×1000 mm透明有机玻璃爆炸管道实验平台。实验结果表明，在氧气浓度

和泄爆面积比

变化的条件下，会对CH

预混气体爆炸火焰与压力的耦合振荡产生影响。当氧气浓度

从0.21到0.40变化时，火焰传播时间逐渐缩短，火焰结构发生动态演变，火焰后期的振荡现象愈加明显，同时测到的压力曲线在后期也存在振荡增强现象；当泄爆面积比

从0.125到1.000变化时，

=0.21工况下

=0.125和

=0.250两个工况与其他工况的压力曲线有所不同，出现了一个更高的压力峰值，

=0.30工况下

=0.125也出现了新的压力峰值，

=0.30和

=0.40两种工况的压力峰值都逐渐减小，压力后期的振荡幅值与泄爆面积比有关。

Abstract

To study the coupling oscillation characteristics of the explosion flame and pressure of premixed gas

a transparent plexiglass explosive pipeline experimental platform with dimensions of 80 mm×80 mm×1000 mm was built. The results show that the coupling oscillation of CH

premixed gas explosion flame and pressure will be affected under the condition that the oxygen concentration

and the detonation area ratio

change. When the oxygen concentration

changes from 0.21 to 0.40

the flame propagation time decreases gradually

the flame structure evolves dynamically

the oscillation phenomenon in the later flame is more obvious

and the oscillation enhancement phenomenon also exists in the later stage of the measured pressure curve. When the detonation area changes from 0.125 to 1.000

the pressure curves of

=0.125 and

=0.250 under

=0.21 conditions are different from those of other working conditions

a higher pressure peak is observed

and new pressure peaks appear in

=0.125 under

=0.30 conditions

and the peak pressure of

=0.30 and

=0.40 two kinds of working conditions decreases gradually

the oscillation amplitude in the later stage of pressure is related to the explosion area ratio.

关键词

Keywords

references

Ciccarelli G , Dorofeev S B . Flame acceleration and transition to detonation [J ] . Progress in Energy and Combustion Science , 2008 , 34 ( 4 ): 499 - 550 .

郑立刚 , 吕先舒 , 郑凯 , 等 . 点火源位置对甲烷-空气爆燃超压特征的影响 [J ] . 化工学报 , 2015 ， 66 ( 7 ): 2749 - 2756 .

Zheng L G , Lyu X S , Zheng K , et al . Influence of ignition position on overpressure of premixed methane-air deflagration [J ] . CIESC Journal , 2015 ， 66 ( 7 ): 2749 - 2756 .

Phylaktou H , Andrews G E . Gas explosions in long closed vessels [J ] . Combustion Science and Technology , 1991 , 77 ( 1 / 2 / 3 ): 27 - 39 .

沈伟 , 杜扬 . 受限空间尺度对可燃气体爆燃波发展过程的影响 [J ] . 实验力学 , 2006 , 21 ( 2 ): 122 - 128 .

Shen W , Du Y . Effect of scale on deflagration of fuel-air mixture in confined space [J ] . Journal of Experimental Mechanics , 2006 , 21 ( 2 ): 122 - 128 .

Zhang Q , Li W , Rumei T , et al . Combustion parameters of gaseous epoxypropane/air in a confined vessel [J ] . Fuel , 2013 , 105 ( 2 ): 512 - 517 .

Xiao H H , Sun J H , Chen P . Experimental and numerical study of premixed hydrogen/air flame propagating in a combustion chamber [J ] . Journal of Hazardous Materials , 2014 , 268 : 132 - 139 .

Xiao H H , Duan Q L , Jiang L , et al . Effects of ignition location on premixed hydrogen/air flame propagation in a closed combustion tube [J ] . International Journal of Hydrogen Energy , 2014 , 39 ( 16 ): 8557 - 8563 .

林柏泉 . 瓦斯爆炸动力学特征参数的测定及其分析 [J ] . 煤炭学报 , 2002 , 27 ( 2 ): 164 - 167 .

Lin B Q . The measurement and analysis of dynamics feature parameter in gas explosion [J ] . Journal of China Coal Society , 2002 , 27 ( 2 ) : 164 - 167 .

朱传杰 , 林柏泉 , 江丙友 , 等 . 瓦斯爆炸在封闭管道内冲击振荡特征的数值模拟 [J ] . 振动与冲击 , 2012 , 31 ( 16 ): 8 - 12 .

Zhu C J , Lin B Q , Jiang B Y , et al . Numerical simulation on oscillation and shock of gas explosion in a closed end pipe [J ] . Journal of Vibration and Shock , 2012 , 31 ( 16 ): 8 - 12 .

朱传杰 , 林柏泉 , 江丙友 , 等 . 受限空间内爆燃波瞬态流速与超压的耦合关系 [J ] . 燃烧科学与技术 , 2012 , 18 ( 4 ): 326 - 330 .

Zhu C J , Lin B Q , Jiang B Y , et al . Coupled relationship between gas velocity and peak overpressure of deflagration wave in confined space [J ] . Journal of Combustion Science and Technology , 2012 , 18 ( 4 ): 326 - 330 .

Kerampran S , Desbordes D , VeyssiÈRe B . Study of the mechanisms of flame acceleration in a tube of constant cross section [J ] . Combustion Science and Technology , 2000 , 158 ( 1 ): 71 - 91 .

Benedetto A D , Cammarota F , Sarli V D , et al . Combustion-induced rapid-phase transition (cRPT) in CH 4 /CO 2 /O 2 -enriched mixtures [J ] . Energy and Fuels , 2012 , 26 ( 8 ): 4799 – 4803 .

Benedetto A D , Cammarota F , Sarli V D , et al . Direction of pressure wave propagation during combustion-induced rapid phase transition [J ] . Journal of Loss Prevention in the Process Industries , 2016 , 40 : 524 - 528 .

Benedetto A D , Cammarota F , Sarli V D , et al . Effect of diluents on rapid phase transition of water induced by combustion [J ] . AIChE Journal , 2012 , 58 ( 9 ): 2810 - 2819 .

Basco A , Cammarota F , Sarli V D , et al . Theoretical analysis of anomalous explosion behavior for H 2 /CO/O 2 /N 2 and CH 4 /O 2 /N 2 /CO 2 mixtures in the light of combustion-induced rapid phase transition [J ] . International Journal of Hydrogen Energy , 2015 , 40 ( 25 ): 8239 - 8247 .

Thomas G O . Flame acceleration and the development of detonation in fuel-oxygen mixtures at elevated temperatures and pressures [J ] . Journal of Hazardous Materials , 2009 , 163 ( 2 ): 783 - 794 .

Schildberg H P . The course of the explosions of combustible/O 2 /N 2 mixtures in vessel-like geometry [J ] . Forschung Im Ingenieurwesen , 2009 , 73 ( 1 ): 33 - 65 .

Clanet C , Searby G . On the “tulip flame” phenomenon [J ] . Combustion and Flame , 1996 , 105 ( 1 / 2 ): 225 - 238 .

曾令可 , 邓伟强 , 刘艳春 , 等 . 富氧燃烧技术在陶瓷窑炉中的应用分析 [J ] . 陶瓷学报 , 2007 , 28 ( 2 ): 123 - 128 .

Zeng L K , Deng W Q , Liu Y C , et al . Application of oxygen-enriched combustion technology in ceramic kiln [J ] . Journal of Ceramics , 2007 , 28 ( 2 ): 123 - 128 .

Ponizy B , Claverie A , Veyssière B . Tulip flame — the mechanism of flame front inversion [J ] . Combustion and Flame , 2014 , 161 ( 12 ): 3051 - 3062 .

贾迎梅 , 刘贞堂 , 王从银 , 等 . 瓦斯爆炸气体成分实验研究 [J ] . 煤炭技术 , 2009 , 28 ( 12 ): 78 - 81 .

Jia Y M , Liu Z T , Wang C Y , et al . Experimental study on gas composition after gas explosion [J ] . Coal Technology , 2009 , 28 ( 12 ): 78 - 81 .

温小萍 , 武建军 , 解茂昭 . 瓦斯爆炸火焰结构与压力波的耦合规律 [J ] . 化工学报 , 2013 , 64 ( 10 ): 3871 - 3877 .

Wen X P, Wu J J, Xie M Z, Coupled relationship between flame structure and pressure wave of gas explosion [J ] . CIESC Journal , 2013 , 64 ( 10 ): 3871 - 3877 .

Wen X P , Yu M G , Liu Z C , et al . Large eddy simulation of methane-air deflagration in an obstructed chamber using different combustion models [J ] . Journal of Loss Prevention in the Process Industries , 2012 , 25 ( 4 ): 730 - 738 .

Zheng K , Yu M G , Zheng L G , et al . Experimental study on premixed flame propagation of hydrogen/methane/air deflagration in closed ducts [J ] . International Journal of Hydrogen Energy , 2017 , 42 ( 8 ): 5426 - 5438 .

Yu M G , Zheng K , Zheng L G , et al . Scale effects on premixed flame propagation of hydrogen/methane deflagration [J ] . International Journal of Hydrogen Energy , 2015 , 40 ( 38 ): 13121 - 13133 .

Zheng K , Yu M G , Liang Y P , et al . Large eddy simulation of premixed hydrogen/methane/air flame propagation in a closed duct [J ] . International Journal of Hydrogen Energy , 2018 , 43 ( 7 ): 3871 - 3884 .

Zheng K , Yu M G , Zheng L G , et al . Effects of hydrogen addition on methane-air deflagration in obstructed chamber [J ] . Experimental Thermal and Fluid Science , 2017 , 80 : 270 - 280 .

Zheng K , Yu M G , Zheng L G , et al . Comparative study of the propagation of methane/air and hydrogen/air flames in a duct using large eddy simulation [J ] . Process Safety and Environmental Protection , 2018 , 120 : 45 - 56 .

Benedetto A D , Cammarota F , Sarli V D . Anomalous behavior during explosions of CH 4 in oxygen-enriched air [J ] . Combustion and Flame , 2011 , 158 ( 11 ): 2214 - 2219 .

任少峰 , 陈先锋 , 王玉杰 , 等 . 无约束泄爆对甲烷/空气火焰传播特性影响的试验研究 [J ] . 中国安全科学学报 , 2013 , 23 ( 4 ): 84 - 88 .

Ren S F , Chen X F , Wang Y J , et al . Experimental study on effect of unconstrained explosion venting on methane-air flame propagation characteristics [J ] . China Safety Science Journal , 2013 , 23 ( 4 ): 84 - 88 .

曹勇 , 郭进 , 胡坤伦 , 等 . 点火位置对氢气-空气预混气体泄爆过程的影响 [J ] . 爆炸与冲击 , 2016 , 36 ( 6 ): 847 - 852 .

Cao Y , Guo J , Hu K L , et al . Effect of ignition locations on vented explosion of premixed hydrogen-air mixtures [J ] . Explosion and Shock Waves , 2016 , 36 ( 6 ): 847 - 852 .

任少峰 , 陈先锋 , 王玉杰 , 等 . 泄压口比率对气体泄爆过程中的动力学行为的影响 [J ] . 煤炭学报 , 2011 , 36 ( 5 ): 830 - 833 .

Ren S F , Chen X F , Wang Y J , et al . Effect of pressure-orifice ratio on dynamic behavior during gas venting [J ] . Journal of China Coal Society , 2011 , 36 ( 5 ): 830 - 833 .

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

三元混合气体燃料爆炸特性实验研究

基于振荡座滴测定液滴表面张力的方法

液氢接收终端液氢泄漏扩散及爆炸超压研究

膜片压力对氢-空气混合气体泄爆过程的影响

光电分解水制氢气泡动力学特性及其传质机理研究