用KMnO<sub>4</sub>调质钙基吸收剂从燃煤烟气同时脱硫脱硝

张虎; 佟会玲; 王晋元; 陈昌和

您当前的位置：

首页 >

文章列表页 >

用KMnO₄调质钙基吸收剂从燃煤烟气同时脱硫脱硝

能源和环境工程 | 更新时间：2025-12-10

- 用KMnO₄调质钙基吸收剂从燃煤烟气同时脱硫脱硝
- Simultaneous removal of SO₂ and NO by using calcium absorbent with KMnO₄ as additive
- 化工学报 2007年第7期页码：1810-1815
- 作者机构：
  
  清华大学热能工程系，热科学与动力工程教育部重点实验室
- 作者简介：
- 基金信息：
- DOI：
  中图分类号：
- 网络首发：2007-07-05，
  
  纸质出版：2007-07-05
- 稿件说明：
移动端阅览
张虎, 佟会玲, 王晋元, 等. 用KMnO₄调质钙基吸收剂从燃煤烟气同时脱硫脱硝[J]. 化工学报, 2007,(7):1810-1815.

ZHANG Hu, TONG Huiling, WANG Jinyuan, et al. Simultaneous removal of SO₂ and NO by using calcium absorbent with KMnO₄ as additive[J]. CIESC Journal, 2007, (7): 1810-1815.
张虎, 佟会玲, 王晋元, 等. 用KMnO₄调质钙基吸收剂从燃煤烟气同时脱硫脱硝[J]. 化工学报, 2007,(7):1810-1815. DOI：

ZHANG Hu, TONG Huiling, WANG Jinyuan, et al. Simultaneous removal of SO₂ and NO by using calcium absorbent with KMnO₄ as additive[J]. CIESC Journal, 2007, (7): 1810-1815. DOI：

摘要

在固定床反应器中考察了强氧化剂KMnO4作为添加剂对钙基吸收剂同时脱硫脱硝的调质效果。实验结果表明，不含KMnO4时钙基吸收剂不能有效脱除NO，而当KMnO4存在Ca/(S+0.5N)为1.8时，钙基吸收剂可获得31.4％的脱硫率和13.5％的脱硝率。实验还研究了各种参数变化对脱硫率和脱硝率的影响，反应温度升高能够促进SO2的脱除，但脱硝率对温度的变化不敏感；脱硫率随着烟气相对湿度的增加而增加，但脱硝率与相对湿度的关系不是单调的，存在一个最大值；O2是脱除NO的必要条件。结合气体分析和产物分析的实验结果发现，NO被脱除的机理是先被氧化为NO2，然后再与吸收剂和脱硫产物反应生成了硝酸盐和亚硝酸盐。为半干法脱硫技术中加入脱硝功能的可能性提供参考依据。

Abstract

The simultaneous SO2/NO removal by calcium based absorbent with KMnO4 as additive was studied in a fixed-bed reactor at a low temperature.The experimental results showed that KMnO4 could promote NO removal by calcium hydroxide

and the efficiency of SO2 and NO removal could reach 31.4% and 13.5％ respectively while the stoichiometric ratio of Ca/(S+0.5N) was 1.8.A higher temperature improved SO2 capture

but had little influence on NO removal.The presence of water vapor and oxygen in the gas is necessary for NO removal by the absorbent

and SO2 removal efficiency increased with increasing relative humidity which had an optimal value for NO removal.The results of XRD and IC analysis on the products showed the NO removal mechanism

that NO was firstly oxidized into NO2

and then removed by reacting with calcium hydroxide or calcium sulfite into nitrate and nitrite.

关键词

Keywords

references

浏览量

753

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

表面修饰纳米铜颗粒添加剂的摩擦学性能

丙烷脱氢固定床反应器的动态模拟与优化

烟气气相组分及Ca（OH）2对KMnO4氧化NO的影响机理

表面修饰铁纳米颗粒的制备及其摩擦性能

二甲醚氧化反应及其添加剂效应

用KMnO4调质钙基吸收剂从燃煤烟气同时脱硫脱硝

Simultaneous removal of SO2 and NO by using calcium absorbent with KMnO4 as additive

DOI：

摘要

Abstract

关键词

Keywords

references

用KMnO₄调质钙基吸收剂从燃煤烟气同时脱硫脱硝

Simultaneous removal of SO₂ and NO by using calcium absorbent with KMnO₄ as additive