Heat transfer of thermal cracking and initiated cracking of aviation kerosene

JIA Zhenjian; ZHOU Weixing; HUANG Hongyan; YU Wenli

doi:10.3969/j.issn.0438-1157.2014.z1.022

您当前的位置：

首页 >

文章列表页 >

Heat transfer of thermal cracking and initiated cracking of aviation kerosene

更新时间：2025-12-10

- Heat transfer of thermal cracking and initiated cracking of aviation kerosene
- CIESC Journal Issue S1, Pages: 138-143(2014)
- 作者机构：
  
  1. 哈尔滨工业大学能源科学与工程学院,黑龙江,哈尔滨,150001
  2. 哈尔滨工业大学基础与交叉科学研究院,黑龙江,哈尔滨,150001
- 作者简介：
- 基金信息：
- DOI：10.3969/j.issn.0438-1157.2014.z1.022
  CLC： Q028.8
- Online First：30 May 2014，
  
  Published：30 May 2014
- 稿件说明：
移动端阅览
JIA Zhenjian, ZHOU Weixing, HUANG Hongyan, et al. Heat transfer of thermal cracking and initiated cracking of aviation kerosene[J]. CIESC Journal, 2014, (S1): 138-143.
DOI：

JIA Zhenjian, ZHOU Weixing, HUANG Hongyan, et al. Heat transfer of thermal cracking and initiated cracking of aviation kerosene[J]. CIESC Journal, 2014, (S1): 138-143. DOI： 10.3969/j.issn.0438-1157.2014.z1.022.

摘要

通过流动管反应器对碳氢燃料RP-3在超临界条件下的热裂解及引发裂解进行了实验，对两种条件下的燃料吸热能力及传热特性进行了对比分析，并对裂解产物进行了采样分析。结果表明，引发裂解降低了燃料的裂解起始温度，在一定温度区间内提高了燃料的裂解率，从而有效提高了燃料热沉，在相同热通量条件下，降低了燃料温度，并降低了加热段壁面温度。对流换热受化学反应及物性变化的影响，燃料裂解吸热可增强换热，而大量气态产物的生成会降低换热，因此，裂解反应的增强不一定增强换热。

Abstract

Nitro-propane (NP) was employed as the initiator to investigate the effect of initiated cracking on heat transfer of aviation fuel RP-3 with a one-stage and cracking system operating under supercritical pressure. The pyrolysis products are analyzed using a chromatograph/mass spectrometry (GC-MS). The heat sink

conversion rate and heat transfer coefficient were calculated based on the experimental results. Experimental results indicate that the heat transfer characteristics are influenced by the pyrolysis rate and physical property change caused by products distribution. NP accelerates the pyrolysis and increases the heat sink of fuel in temperature range of 800 K to 900 K. Under the same heat flux conditions

the effects of NP are reflected in the reduction of fuel and wall temperature. The reductions of fuel and wall temperature increase first and decrease along the flow direction

and the maximum decrease is more than 10 K. However

the Reynolds numbers decrease because of large amount gaseous products generated by pyrolysis reaction

which has negative effect on the convective heat transfer. So the influence of initiated cracking on the heat transfer of RP-3 is not a simple effect of promotion or inhibition

the regularity is different in different temperature ranges.

关键词

Keywords

references

Views

221

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

R245fa flow boiling heat transfer characteristics in horizontal tube with segmented porous coating

Experimental investigations of condensation droplet shedding characteristics on star-shaped hydrophobic-hydrophilic hybrid surfaces

Research on thermodynamic properties of supercritical compressed carbon dioxide energy storage system with waste heat recovery

Effects of cylindrical particle structure modification on the flow and heat transfer characteristics in packed beds

Experimental study on convection heat transfer characteristics of supercritical carbon dioxide flowing in mini square channels

Related Author

CAO Shuang

LIU He

GUO Jiaju

ZHANG Yi

LIU Wenpei

WU Xuehong

LIU Lu

YANG Ying

Related Institution

Henan International Joint Laboratory of Energy Efficient Conversion and Utilization

College of Energy and Power Engineering, Zhengzhou University of Light Industry

Department of Power Engineering, North China Electric Power University

School of Energy and Power Engineering, Xi’an Jiaotong University

School of Energy and Power Engineering, University of Shanghai for Science and Technology

⁰