Kinetics of thermal decomposition of epoxy resins modified with phosphorus-containing flame retardant

TIAN Xiujuan; WANG Zhongwei; YU Qing; GAO Jun

doi:10.3969/j.issn.0438-1157.2014.12.059

您当前的位置：

首页 >

文章列表页 >

Kinetics of thermal decomposition of epoxy resins modified with phosphorus-containing flame retardant

更新时间：2025-12-10

- Kinetics of thermal decomposition of epoxy resins modified with phosphorus-containing flame retardant
- CIESC Journal Issue 12, Pages: 5082-5089(2014)
- 作者机构：
  
  1. 山东科技大学材料科学与工程学院,山东,青岛,266590
  2. 山东科技大学化学与环境工程学院,山东,青岛,266590
- 作者简介：
- 基金信息：
- DOI：10.3969/j.issn.0438-1157.2014.12.059
  CLC： 631
- Online First：05 December 2014，
  
  Published：05 December 2014
- 稿件说明：
移动端阅览
TIAN Xiujuan, WANG Zhongwei, YU Qing, et al. Kinetics of thermal decomposition of epoxy resins modified with phosphorus-containing flame retardant[J]. CIESC Journal, 2014, (12): 5082-5089.
DOI：

TIAN Xiujuan, WANG Zhongwei, YU Qing, et al. Kinetics of thermal decomposition of epoxy resins modified with phosphorus-containing flame retardant[J]. CIESC Journal, 2014, (12): 5082-5089. DOI： 10.3969/j.issn.0438-1157.2014.12.059.

摘要

以2-二苯基膦酰基-1

4-苯二酚(DPO-HQ)为阻燃剂制备了阻燃环氧树脂

利用动态热重分析法(TGA)研究了纯环氧树脂(EP)和阻燃环氧树脂(FR-EP)在不同升温速率下的热稳定性

建立了EP和FR-EP体系的动力学模型和非模型动力学(MFK)

并对比分析了模型动力学和非模型动力学对于描述EP体系和FR-EP体系的适用性.结果表明:阻燃剂的引入降低了环氧树脂初始降解温度

但增加了残炭率.由Flynn-Wall-Ozawa方法和Coats-Redfern方法建立的模型动力学表征EP和FR-EP体系高温降解过程中误差较大

而非模型动力学能更准确地预测和描述EP和FR-EP体系的高温降解行为.

Abstract

Phosphorus-containing epoxy resin was prepared from 2-diphenylphosphonothioic-1

4-diphenol (DPO-HQ

as flame retardant). The thermal stabilities of neat epoxy resin (EP) and flame retardant modified epoxy resin (FR-EP) were studied with thermogravimetric analysis (TGA) at different heating rates. Kinetics model and model-free kinetics (MFK) were established based on TGA data. The serviceability values of model kinetics and model-free kinetics to epoxy resin and flame retardant modified epoxy resin were compared and analyzed. The initial degradation temperature of flame retardant modified epoxy resin slightly decreased with introduction of flame retardant

but the yield of char residue increased. The model kinetics of EP and FR-EP determined by using the Flynn-Wall-Ozawa method and the Coats-Redfern method were not applicable to epoxy resin system. MFK was more suitable to describe and predict the degradation behavior of epoxy resin and flame retardant modified epoxy resin.

关键词

Keywords

references

Views

581

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Synthesis, properties and application of reactive nitrogen-phosphorus flame retardant

Performance of flame retardant for environmentally friendly refrigerant R290

Controlled synthesis of Bi2MoO6/MoO3 composite fibers via in-situ hydrothermal method and their high-efficiency photocatalytic hydrogen production performance

Study on flash evaporation characteristics as well as thermodynamic variation performance in liquid hydrogen tank during on-orbit venting

Corrosion health status assessment method for refining unit pipeline based on GLAE-MLP

Related Author

HU Wentian

YANG Rong

XU Liang

SONG Yan

LI Jinchun

FENG Biao

ZHANG Zhao

LI Siqi

Related Institution

School of Materials Science and Engineering, Changzhou University

Key Laboratory of Cleaner Intelligent Control on Coal & Electricity, Ministry of Education(MOC) College of Electrical and Power Engineering, Taiyuan University of Technology

College of Physics and Optoelectronics, Taiyuan University of Technology

⁰