Enriched-air gasification of refuse derived fuel in bubbling fluidized bed

NIU Miaomiao; HUANG Yaji; JIN Baosheng; WANG Yanyan; DONG Xinxin

doi:10.3969/j.issn.0438-1157.2014.12.044

您当前的位置：

首页 >

文章列表页 >

Enriched-air gasification of refuse derived fuel in bubbling fluidized bed

更新时间：2025-12-10

- Enriched-air gasification of refuse derived fuel in bubbling fluidized bed
- CIESC Journal Issue 12, Pages: 4971-4977(2014)
- 作者机构：
  
  东南大学能源热转换及其过程测控教育部重点实验室,江苏,南京,210096
- 作者简介：
- 基金信息：
- DOI：10.3969/j.issn.0438-1157.2014.12.044
  CLC： 705
- Online First：05 December 2014，
  
  Published：05 December 2014
- 稿件说明：
移动端阅览
NIU Miaomiao, HUANG Yaji, JIN Baosheng, et al. Enriched-air gasification of refuse derived fuel in bubbling fluidized bed[J]. CIESC Journal, 2014, (12): 4971-4977.
DOI：

NIU Miaomiao, HUANG Yaji, JIN Baosheng, et al. Enriched-air gasification of refuse derived fuel in bubbling fluidized bed[J]. CIESC Journal, 2014, (12): 4971-4977. DOI： 10.3969/j.issn.0438-1157.2014.12.044.

摘要

在鼓泡流化床上进行两种垃圾衍生燃料(RDF)的富氧气化试验

考察了RDF的热重特性并分析了气化温度、当量比及富氧浓度对气化特性的影响.结果表明:两种RDF均由纤维素及塑料类组分构成.随着温度由650℃升高至800℃

两种RDF产气的H2、CO及CH4浓度均逐渐增加

产气热值和气化效率同时提高.当量比增大时可燃组分浓度先略有增大后逐渐减小

但气体产率不断增大.RDF1及RDF2分别在当量比为0.22及0.27处达到最佳气化效率.富氧气化可有效改善气化品质

提升合成气热值

富氧浓度为45%时RDF1及RDF2合成气热值均达到最大

分别为8.6 MJ·m-3及9.2 MJ·m-3.

Abstract

Enriched air gasification of two different refuse derived fuels (RDF) was performed in a bubbling fluidized bed reactor. Thermo-gravimetric analysis of the two RDFs was performed and the effect of temperature

equivalence ratio (ER) and oxygen percentage of enriched air was investigated. Both RDFs were composed of cellulose and plastics based materials. With increasing temperature from 650℃ to 800℃

concentrations of H2

CO and CH4 increased in both RDFs gasification. Gas yield and gasification efficiency were also improved. The combustible components first increased slightly and then decreased with increasing ER

while gas yield kept constant growth. The optimum ER values for RDF1 and RDF2 were 0.22 and 0.27 respectively for obtaining the highest gasification efficiency. The use of enriched air could improve gasification effectively and lead to higher heating value of the syngas. When oxygen percentage of enriched air was 45%

the maximum low heating values of the syngas for RDF1 and RDF2 were 8.6 MJ·m-3 and 9.2 MJ·m-3 respectively.

关键词

Keywords

references

Views

354

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Progress of molten salt-assisted thermochemical high-value conversion of biomass

Study on the steam gasification mechanism of waste PP plastics based on ReaxFF-MD and DFT methods

Fluidized bed two-stage gasification of coal with steam/O2 for production of low-tar syngas

Biomass chemical-looping gasification characteristics of K-modified BaFe2O4 oxygen carrier

Numerical simulation of 3D fluidized bed biomass gasification based on CPFD

Related Author

CAO Wenxuan

WU Boyang

LI Jun

LIU Tianji

ZENG Kuo

YANG Haiping

CHEN Hanping

XUAN Weiwei

Related Institution

School of Energy and Power Engineering, Huazhong University of Science and Technology

EU Institute for Clean and Renewable Energy, Huazhong University of Science and Technology

School of Energy and Environmental Engineering, University of Science and Technology Beijing

Key Laboratory for Thermal Science and Power Engineering of Ministry of Education, Tsinghua University

Key Laboratory of Resources Chemicals and Materials (Shenyang University of Chemical Technology), Ministry of Education

⁰