A new method for measuring moisture distribution in fluidized bed

ZHOU Yunlong; YANG Ning

doi:10.3969/j.issn.0438-1157.2014.10.018

您当前的位置：

首页 >

文章列表页 >

A new method for measuring moisture distribution in fluidized bed

更新时间：2025-12-10

- A new method for measuring moisture distribution in fluidized bed
- CIESC Journal Issue 10, Pages: 3878-3883(2014)
- 作者机构：
  
  东北电力大学能源与动力工程学院,吉林市,吉林省,132012
- 作者简介：
- 基金信息：
- DOI：10.3969/j.issn.0438-1157.2014.10.018
  CLC： K121
- Online First：05 October 2014，
  
  Published：05 October 2014
- 稿件说明：
移动端阅览
ZHOU Yunlong, YANG Ning. A new method for measuring moisture distribution in fluidized bed[J]. CIESC Journal, 2014, (10): 3878-3883.
DOI：

ZHOU Yunlong, YANG Ning. A new method for measuring moisture distribution in fluidized bed[J]. CIESC Journal, 2014, (10): 3878-3883. DOI： 10.3969/j.issn.0438-1157.2014.10.018.

摘要

在流化床中团聚物主要以宏观团聚物、微小团聚物、自由颗粒3种形式存在，通过TEB雾化喷嘴制造流化床颗粒团聚物，其中宏观团聚物沉积在流化床的底部位置，微小团聚物和自由颗粒均匀分布在整个流化床中。研究发现本文自主研制开发的多通道电导电路实验装置测量所得电导信号与流化床内水分含量存在线性比例的关系，利用流化床的持续流化效应造成团聚物破裂引发电导信号回升，实现了颗粒团聚物水分分布状态的测量。利用该装置测量了TEB雾化喷嘴气液比在0～4%范围内变化时流化床内颗粒及团聚物的水分分布状态，结果表明随着气液比的增加，微小团聚物、自由颗粒所包含的水分有所增加，宏观团聚物所包含的水分有所减小，即使在气液比增加到4%时，大量的水分仍然被宏观团聚物所吸收。

Abstract

Mainly three groups exist in the fluidized bed: macro-agglomerates

micro-agglomerates

and free-particles. Agglomerates were generated by using TEB nozzles. Macro-agglomerates were distributed at the bottom of the fluidized bed

while micro-agglomerates and free-particles were uniformly distributed in the fluidized bed. The conductance signals measured by the self-developed multi-channel conductance electrical circuit experimental device showed linear relationship with moisture content inside the fluidized bed. Conductance signal was recovered under the influence of agglomerates breakup by continuous fluidization

so that measurement of moisture distribution could be implemented. Measurement of moisture distribution with TEB atomization nozzle gas liquid ratio in the range of 0-4% indicated that with the increase of gas liquid ratio

the moisture content in the micro-agglomerates and free-particles increased

while the moisture content in the macro-agglomerates decreased. But even when gas liquid ratio increased to 4%

most of the moisture content still existed in the macro-agglomerates.

关键词

Keywords

references

Views

243

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Investigation on the static properties and annihilation characteristics of particle clusters in gas-solid fluidized beds

Numerical simulation of residence time distribution in multi-chamber fluidized bed with continuous feeding

Numerical study on heat and mass transfer characteristics of particle coating in a spray fluidized bed with draft plates

Effects of turbulence on radial gas diffusion in binary particle fluidized bed

Current status and prospects of research on fluidization characteristics of high-density particles

Related Author

ZHOU Zhikang

HU Shanwei

LIU Xinhua

GUO Xiaodie

ZHOU Wenjing

WEI Jinjia

DENG Aiming

HE Yurong

Related Institution

State Key Laboratory of Mesoscience and Engineering, Institute of Process Engineering, Chinese Academy of Sciences

School of Chemical Engineering, University of Chinese Academy of Sciences

School of Chemical Engineering and Technology, Xi’an Jiaotong University

School of Energy Science and Engineering, Harbin Institute of Technology

Zhengzhou Research Institute, Harbin Institute of Technology

⁰