Enhanced production of spinosad with strains of Saccharopolyspora spinosa by genome shuffling

XIA Yanchun; WANG Chao; CHEN Yuan; WU Jianglei; ZOU Qiulong; ZHANG Xiaolin; LI Chun

doi:10.3969/j.issn.0438-1157.2014.09.036

您当前的位置：

首页 >

文章列表页 >

Enhanced production of spinosad with strains of Saccharopolyspora spinosa by genome shuffling

更新时间：2025-12-10

- Enhanced production of spinosad with strains of Saccharopolyspora spinosa by genome shuffling
- CIESC Journal Issue 9, Pages: 3576-3582(2014)
- 作者机构：
  
  1. 石河子大学化学化工学院/新疆兵团化工绿色过程重点实验室-省部共建国家重点实验室培育基地,新疆,石河子,832003
  2. 国家粮食局科学研究院,北京,100037
  3. 武汉轻工大学生物与制药工程学院,湖北,武汉,430023
- 作者简介：
- 基金信息：
- DOI：10.3969/j.issn.0438-1157.2014.09.036
  CLC： 482.3+9
- Online First：05 September 2014，
  
  Published：05 September 2014
- 稿件说明：
移动端阅览
XIA Yanchun, WANG Chao, CHEN Yuan, et al. Enhanced production of spinosad with strains of Saccharopolyspora spinosa by genome shuffling[J]. CIESC Journal, 2014, (9): 3576-3582.
DOI：

XIA Yanchun, WANG Chao, CHEN Yuan, et al. Enhanced production of spinosad with strains of Saccharopolyspora spinosa by genome shuffling[J]. CIESC Journal, 2014, (9): 3576-3582. DOI： 10.3969/j.issn.0438-1157.2014.09.036.

摘要

利用课题组前期通过不同物理化学诱变和分子生物学方法获得的8株多杀菌素产生菌为出发菌株，采用96孔板发酵培养结合生物检测的高通量筛选方法，探索了原生质体制备、再生、双亲灭活和原生质体融合等条件，并通过多轮基因组重排获得了多杀菌素高产菌株。结果表明：当菌龄为65 h、溶菌酶浓度为4 mg·ml-1，39℃处理时间20 min时，原生质体的制备率及再生率分别为92.30%和7.66%；60℃恒温水浴90 min以上和紫外照射200 s以上为双亲灭活条件；PEG浓度为50%，在32℃下处理15 min时，原生质体融合率约为1.18%。最终获得1株产量较出发菌株提高了36.07%且遗传稳定的融合株。

Abstract

In this study

genome shuffling of eight original strains obtained by various methods of chemical and physical mutations was used to achieve rapid improvement of spinosad production. The conditions of preparation

regeneration

parents inactivation and fusion of protoplast of the original strain were investigated. The strain grown for 65 h was treated by 4 mg·ml-1 lysozyme at 39℃ for 20 min

and preparation rate and regeneration rate were 92.30% and 7.66%

respectively. The protoplasts were inactivated by heating at 60℃ for more than 90 min and UV treatment more than 200 s

respectively. The inactivated protoplasts were fused and regenerated in polyethylene glycol (PEG 6000

50%) for 15 min

and fusion rate was about 1.18%. After three rounds of genome shuffling

a high yielding strain

designated as S.spinosa 3-652

was isolated. The increased yield was about 36.07% higher than that of the original strain. Subculture experiments indicated that the high producers were stable.

关键词

Keywords

references

Views

216

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Corrosion health status assessment method for refining unit pipeline based on GLAE-MLP

Prediction model for COD in petrochemical wastewater influent based on temporal-spatial dual-stream convolutional neural network

Study on performance enhancement and cold retention characteristics of solid packed bed cold energy storage

Construction of transition metal-based nitrogen-doped carbon and their desulfurization performance

New universal corresponding state equation for correlation and extrapolation of saturated vapor-liquid density

Related Author

No data

Related Institution

No data

⁰