Bubble behavior in sea water bubbling concentration process

TAO Hengcong; ZHU Baikang; WANG Dongguang

doi:10.3969/j.issn.0438-1157.2014.08.019

您当前的位置：

首页 >

文章列表页 >

Bubble behavior in sea water bubbling concentration process

更新时间：2025-12-10

- Bubble behavior in sea water bubbling concentration process
- CIESC Journal Issue 8, Pages: 2981-2987(2014)
- 作者机构：
  
  1. 浙江海洋学院海洋科学与技术学院,浙江,舟山,316022
  2. 浙江海洋学院石化与能源工程学院,浙江,舟山,316022
- 作者简介：
- 基金信息：
- DOI：10.3969/j.issn.0438-1157.2014.08.019
  CLC： 746.1TQ115
- Online First：05 August 2014，
  
  Published：05 August 2014
- 稿件说明：
移动端阅览
TAO Hengcong, ZHU Baikang, WANG Dongguang. Bubble behavior in sea water bubbling concentration process[J]. CIESC Journal, 2014, (8): 2981-2987.
DOI：

TAO Hengcong, ZHU Baikang, WANG Dongguang. Bubble behavior in sea water bubbling concentration process[J]. CIESC Journal, 2014, (8): 2981-2987. DOI： 10.3969/j.issn.0438-1157.2014.08.019.

摘要

鼓泡操作可强化浓海水蒸发过程，其气泡的大小及运动行为对浓海水蒸发过程有显著影响。实验通过搭建两种不同尺寸的鼓泡池，针对单鼓泡口、双鼓泡口及鼓泡阵列，在不同气量、鼓泡口深度与鼓泡口间距条件下，考察大气泡群与小气泡群在不同运动过程的行为。结果表明，在气体流量更低的情况下，液面上的小气泡群比大气泡群具有更高的表面覆盖度，更易于增加液相扰动，并能迸射出更多的小液滴，提出小气泡更适合于鼓泡浓缩晒盐过程。通过单因素实验优化后，小气泡群的覆盖率可以达到90%，蒸发速率可比传统滩晒过程增加1～1.5倍。优化后操作参数为：单鼓泡口气流量为0.4 L·min-1、鼓泡口深度为8 cm、鼓泡口间距为12 cm。

Abstract

Evaporation process for concentrating sea water can be enhanced by bubbling operation

and it is not only significantly influenced by bubble size but also movement of bubbles. Thus

two different sizes of bubbling test rigs were set up indoor and outdoor. The movement

distribution

coalescence and rupture of large bubbles and small bubbles were experimentally analyzed with a single aeration inlet

two aerations inlets and multi-inlets at different gas fluxes

depths and inlet spacings. Small bubbles floating on the liquid surface had higher coverage and scattered more smaller droplets than large bubbles at a lower gas flow flux

implying that the small bubble pattern was more efficient in bubbling for the solar sea water concentration process. The coverage rate of small bubbles in the operation could reach 90%

increasing evaporation rate by 1-1.5 times

based on optimized operational parameters with gas flux at 0.4 L · min-1

level depth at 8 cm and inlet spacing at 12 cm.

关键词

Keywords

references

Views

367

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Bubbling process of concentrated seawater for solar salt in shoal pool

Analysis of principle, performance and applicability of indirect evaporative water chiller

Character of sessile droplets evaporation on hydrophilic and hydrophobic heating surface with constant heat fluxes

Evaporation characteristics of sessile ethanol-water mixture droplets

Heat and mass transfer characteristics of evaporation and salt crystallization process of a saline droplet during depressurization

Related Author

TAO Hengcong

ZHU Baikang

WANG Dongguang

Jianpei CHANG

Xiang HUANG

Miaomiao AN

Zhaoyang LI

GAO Ming

Related Institution

Zhejiang Ocean University

College of Urban Planning and Municipal Engineering, Xi’an Polytechnic University

Shanghai Key Laboratory of Multiphase Flow and Heat Transfer in Power Engineering, School of Energy and Power Engineering, University of Shanghai for Science and Technology

School of Energy and Power Engineering, University of Shanghai for Science and Technology

School of Energy, Power and Mechanical Engineering, North China Electric Power University

⁰