Numerical simulation for water deoxygenation in rotating packed bed

XIANG Yang; LIU Liang; CHU Guangwen; ZOU Haikui; CHEN Jianfeng

doi:10.3969/j.issn.0438-1157.2014.07.040

您当前的位置：

首页 >

文章列表页 >

Numerical simulation for water deoxygenation in rotating packed bed

更新时间：2025-12-10

- Numerical simulation for water deoxygenation in rotating packed bed
- CIESC Journal Issue 7, Pages: 2785-2792(2014)
- 作者机构：
  
  1. 北京化工大学教育部超重力工程研究中心,北京,100029
  2. 北京化工大学有机无机复合材料国家重点实验室,北京,100029
- 作者简介：
- 基金信息：
- DOI：10.3969/j.issn.0438-1157.2014.07.040
  CLC： Q028.8
- Online First：05 July 2014，
  
  Published：05 July 2014
- 稿件说明：
移动端阅览
XIANG Yang, LIU Liang, CHU Guangwen, et al. Numerical simulation for water deoxygenation in rotating packed bed[J]. CIESC Journal, 2014, (7): 2785-2792.
DOI：

XIANG Yang, LIU Liang, CHU Guangwen, et al. Numerical simulation for water deoxygenation in rotating packed bed[J]. CIESC Journal, 2014, (7): 2785-2792. DOI： 10.3969/j.issn.0438-1157.2014.07.040.

摘要

基于旋转填充床流体流动的可视化结果，建立了超重力旋转填充床气液传质过程的数学模型，模拟氮气解吸水中溶解氧的传质过程。模拟结果表明，缩短液相停留时间、提高液相扩散系数都能增大液相传质分系数kL；总体积传质系数KLa随超重力因子的增加而增大、随温度的上升而增大、随气相流率的增加略有下降、随液相流率的增加明显增大；空腔区传质贡献率随空腔区的增大而增大，随超重力因子的增大而减小；且短暂的停留时间是超重力旋转填充床对传质过程强化的本质原因。模型较好地符合文献的实验数据，误差在±16%以内。

Abstract

A mathematical model for gas-liquid interphase mass transfer was established based on the visual study of fluid flow in a rotating packed bed (RPB). The effects of model parameters on liquid mass transfer coefficient kL

as well as the effect of operation parameters on overall volumetric mass transfer coefficient KLa in gas-liquid mass transfer process of water deoxygenation by a nitrogen stream were studied via numerical simulations with the mathematical model. Simulation results indicated that kL increased with decreasing liquid residence time and increasing liquid molecular diffusivity. KLa increased with increasing higee (high gravity) factor

temperature and liquid flow rate but influenced hardly by pressure

and decreased slightly with increasing gas flow rate. Additionally

the mass transfer contribution of cavity zone diminished with increasing higee factor

as well as decreasing cavity zone volume. According to numerical simulation results

the nature of process intensification for gas-liquid mass transfer process in RPB lay in transient liquid residence time. Deoxygenation efficiency E calculated from this model agreed well with experimental E extracted from literatures with deviations within ±16%

which verified the mass transfer model.

关键词

Keywords

references

Views

332

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Local deposition characteristics of CaCO3 fouling under different roughness element structures

Study on coupling operation characteristics of Stirling engine and high temperature heat pipe

Effect of methane explosion on distribution of pressure field inside and outside buildings

Numerical simulation of ion transfer during electrodialysis desalination process

Influence of support boundary conditions of a seal ring on deformation of mechanical seal end face

Related Author

HAN Zhimin

ZHOU Xiangyu

ZHANG Hongyu

XU Zhiming

SONG Jiahao

WANG Wen

Yuxing LI

Yuanbo YIN

Related Institution

School of Energy and Power Engineering, Northeast Electric Power University

School of Mechanical and Power Engineering, Shanghai Jiao Tong University

Shandong Provincial Key Laboratory of Oil and Gas Storage and Transportation Safety, China University of Petroleum

Sinopec Research Institute of Safety Engineering

College Pipeline and Civil Engineering, China University of Petroleum

⁰