Effect of NaOH pretreatment on methane yield of corn straw at different temperatures by anaerobic digestion

SONG Zilin; SUN Xuewen; YANG Gaihe; YAN Zhiying; YUAN Yuexiang; LI Dong; LI Xiangzhen; LIU Xiaofeng

doi:10.3969/j.issn.0438-1157.2014.05.045

您当前的位置：

首页 >

文章列表页 >

Effect of NaOH pretreatment on methane yield of corn straw at different temperatures by anaerobic digestion

更新时间：2025-12-10

- Effect of NaOH pretreatment on methane yield of corn straw at different temperatures by anaerobic digestion
- CIESC Journal Issue 5, (2014)
- 作者机构：
  
  1. 中国科学院环境与应用微生物重点实验室,四川,成都,610041
  2. 环境微生物四川省重点实验室,四川,成都,610041
  3. 河北工程大学医学院,河北,邯郸,056038
  4. 西北农林科技大学, 陕西杨凌,712100
- 作者简介：
- 基金信息：
- DOI：10.3969/j.issn.0438-1157.2014.05.045
  CLC： 216.4
- Online First：05 May 2014，
  
  Published：05 May 2014
- 稿件说明：
移动端阅览
SONG Zilin, SUN Xuewen, YANG Gaihe, et al. Effect of NaOH pretreatment on methane yield of corn straw at different temperatures by anaerobic digestion[J]. CIESC Journal, 2014, (5).
DOI：

SONG Zilin, SUN Xuewen, YANG Gaihe, et al. Effect of NaOH pretreatment on methane yield of corn straw at different temperatures by anaerobic digestion[J]. CIESC Journal, 2014, (5). DOI： 10.3969/j.issn.0438-1157.2014.05.045.

摘要

利用农作物秸秆进行厌氧发酵生产沼气是解决我国农村能源紧张的重要途径，然而秸秆中难以降解的木质纤维结构导致在发酵过程中甲烷转化率较低。利用自行设计的可控性恒温发酵装置，以玉米秸秆为发酵原料，分析了在不同温度条件下氢氧化钠（NaOH）预处理对秸秆木质纤维结构以及厌氧发酵产气效率的影响。结果表明，NaOH预处理能够显著降低玉米秸秆的木质纤维素含量，与未预处理的秸秆相比，经NaOH处理后的秸秆纤维素含量降低了24.4%～33.2%，半纤维素含量降低了14.2%～52.4%，木质素含量降低了9.3%～29.3%。在6%、8%和10%浓度中，经8%NaOH处理的秸秆在55℃下的甲烷产量最高，达到188.7 ml CH4·（g VS）-1，较未处理的增加了84.2%，因此可作为提高秸秆厌氧发酵产气效率的预处理方法。

Abstract

Methane production through anaerobic digestion (AD) using agricultural straw is an important way to resolve the energy shortage in rural China. However

the AD technology is limited by low conversion efficiency due to recalcitrant nature of lignocellulosic structure in the straw. In the present study

the effect of sodium hydroxide (NaOH) pretreatment at three temperatures on the biogasification performance of corn straw through AD was evaluated by using a laboratory-scale

continuous anaerobic biogas digester. NaOH pretreatment was effective in biodegradation of the lignocellulosic structure of corn straw. The cellulose content of pretreated straw was decreased by 24.4% to 33.2%

the hemicellulose content decreased by 14.2% to 52.4%

and the lignin content decreased by 9.3% to 29.3%

compared with those of untreated straw. The highest methane yield

188.7 ml CH4·(g VS)-1

was achieved when the corn straw was pretreated with 8% NaOH at 55℃

which was 84.2% higher than that of untreated straw. Therefore

pretreatment of 8% NaOH at 55℃ is recommended to improve biodegradability and enhance anaerobic digestibility of straw.

关键词

Keywords

references

Views

980

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Affected mechanisms of oxygen-deficient pretreatment on reduction of NO by biochar

Enhanced anaerobic digestion of refinery waste activated sludge based on pretreatment strategy by spend caustic

Efficient fractionation of sugarcane bagasse with phenoxyethanol under mild condition

Optimum design and performance analysis of waste heat recovery system for biomass fermentation

Effect of ions on photocatalytic H2 production using corn straw as sacrificial agent

Related Author

ZHANG Lei

KANG Jiawei

LI Haoran

HONG Wenpeng

LI Jin

HU Shuiqing

WENG Yibin

JIANG Juntao

Related Institution

School of Energy and Power Engineering, Northeast Electric Power University

CNPC Research Institute of Safety and Environmental Technology

College of Science, China University of Petroleum

School of Chemistry and Chemical Engineering, Anhui University of Technology, Ma’anshan

Guangzhou Institute of Energy Conversion, Chinese Academy of Sciences

⁰