Influence of conditioners for sludge deep dewatering on emission of sulfur-containing gases during sludge drying process

LIU Peng; LIU Huan; ZHANG Qiang; LUO Guangqian; YAO Hong

doi:10.3969/j.issn.0438-1157.2014.03.044

您当前的位置：

首页 >

文章列表页 >

Influence of conditioners for sludge deep dewatering on emission of sulfur-containing gases during sludge drying process

更新时间：2025-12-10

- Influence of conditioners for sludge deep dewatering on emission of sulfur-containing gases during sludge drying process
- CIESC Journal Issue 3, Pages: 1084-1092(2014)
- 作者机构：
  
  华中科技大学煤燃烧国家重点实验室,湖北,武汉,430074
- 作者简介：
- 基金信息：
- DOI：10.3969/j.issn.0438-1157.2014.03.044
  CLC： 705
- Online First：05 March 2014，
  
  Published：05 March 2014
- 稿件说明：
移动端阅览
LIU Peng, LIU Huan, ZHANG Qiang, et al. Influence of conditioners for sludge deep dewatering on emission of sulfur-containing gases during sludge drying process[J]. CIESC Journal, 2014, (3): 1084-1092.
DOI：

LIU Peng, LIU Huan, ZHANG Qiang, et al. Influence of conditioners for sludge deep dewatering on emission of sulfur-containing gases during sludge drying process[J]. CIESC Journal, 2014, (3): 1084-1092. DOI： 10.3969/j.issn.0438-1157.2014.03.044.

摘要

采用5种复合调理剂改善污泥脱水性能，制得深度脱水泥饼。通过检测N2气氛下，不同干化温度（100℃、200℃），停留时间（30 min、60 min）时，不同调理脱水污泥含水率的变化情况，以及含硫气体的种类和释放量，探讨不同调理剂对干化过程中含硫气体释放特性的影响。结果表明，提高温度、延长时间都可以有效降低污泥的含水率；原污泥干化过程释放的主要含硫气体为H2S和SO2，其总量占含硫气体的82.4%；FeCl3+CaO和H2SO4+FeSO4+H2O2+CaO复合调理剂调理脱水泥饼在干化过程中SO2释放量占原污泥释放量的40.3%和40.6%，H2S则基本没有释放；H2SO4+FeSO4+H2O2+CaO调理脱水污泥在100℃和200℃干化过程中的总硫释放量分别占原污泥总释放量的75.0%和45.6%，该复合调理剂在有效提高污泥脱水性能的基础上，能最大限度地抑制含硫气体的释放。

Abstract

To improve sludge dewaterability the different kinds of deep dewatered sludge were prepared by using five kinds of composite conditioners. The influence of the conditioners on the emission characteristics of sulfur-containing gases during the sludge drying process was investigated via detection of water content in dewatered sludge

and of types and amount of sulfur-containing gases released at various drying temperatures (100℃

200℃) and various residence time (30 min

60 min). The results showed that the water content in sludge can be effectively reduced with increase of temperature and prolong of time. The major sulfur-containing gases released during raw sludge drying process were H2S and SO2

accounted for 82.4% of the total emission gas. The amount of SO2 released using conditioner FeCl3+CaO and H2SO4+FeSO4+H2O2+CaO were only 40.3% and 40.6% of the raw sludge

respectively

and no H2S was detected. While for conditioner H2SO4+FeSO4+H2O2+CaO the total amount of sulfur-containing gases released were 75.0% and 45.6% of the raw sludge at 100℃ and 200℃

respectively. So

these composite conditioners could efficiently enhance sludge dewaterability while maximally inhibit the emission of sulfur-containing gases.

关键词

Keywords

references

Views

350

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Drying characteristics of deep dewatered sludge

Pyrolysis characteristic of deep dewatered sludge

Gaseous pollutants emissions from rotary kiln combustion of municipal sewage sludge

Effect of hydrothermal carbonization temperature on transformation path of organic nitrogen in sludge

Influence of pyrolysis time on sludge-derived biochar performance for peroxymonosulfate activation

Related Author

LIU Peng

LIU Huan

YAO Hong

HU Hongyun

LU Geng

WANG Jiaxing

ZHANG Qiang

HU Hongyun

Related Institution

EU Institute for Clean and Renewable Energy, Huazhong University of Science and Technology,,, China

State Key Laboratory of Coal Combustion, School of Energy and Power Engineering, Huazhong University of Science and Technology

Key Laboratory of Energy Thermal Conversion and Control，Ministry of Education，School of Energy and Environment，Southeast University

Hunan Zhongye Changtian Energy Conservation and Environmental Protection Company Limited

School of Energy and Power Engineering, Changsha University of Science and Technology

⁰