Dewatering performance of sludge modified by inorganic conditioner combined with surfactant

HONG Chen; XING Yi; WANG Zhiqiang; ZHANG Kun; SI Yanxiao

doi:10.3969/j.issn.0438-1157.2014.03.042

您当前的位置：

首页 >

文章列表页 >

Dewatering performance of sludge modified by inorganic conditioner combined with surfactant

更新时间：2025-12-10

- Dewatering performance of sludge modified by inorganic conditioner combined with surfactant
- CIESC Journal Issue 3, Pages: 1068-1075(2014)
- 作者机构：
  
  北京科技大学土木与环境工程学院,北京,100083
- 作者简介：
- 基金信息：
- DOI：10.3969/j.issn.0438-1157.2014.03.042
  CLC： 705
- Online First：05 March 2014，
  
  Published：05 March 2014
- 稿件说明：
移动端阅览
HONG Chen, XING Yi, WANG Zhiqiang, et al. Dewatering performance of sludge modified by inorganic conditioner combined with surfactant[J]. CIESC Journal, 2014, (3): 1068-1075.
DOI：

HONG Chen, XING Yi, WANG Zhiqiang, et al. Dewatering performance of sludge modified by inorganic conditioner combined with surfactant[J]. CIESC Journal, 2014, (3): 1068-1075. DOI： 10.3969/j.issn.0438-1157.2014.03.042.

摘要

研究了CaO、PAFC联合表面活性剂预处理对污泥脱水性能的影响。以污泥滤饼含水率和比阻（SRF）作为评价污泥脱水性能的指标，通过测定污泥调理过程中胞外聚合物（EPS）含量、Zeta电位的变化来阐明污泥脱水性能的变化。实验结果表明，十二烷基二甲基苄基氯化铵（1227）的加入导致上清液中EPS含量发生变化，有效降低了SRF和滤饼含水率，提高污泥脱水性能。CaO、PAFC和表面活性剂的联合调理污泥比单独使用表面活性剂的效果更好，CaO、PAFC的投加不仅改善污泥脱水性能，并有助于减少表面活性剂的用量。污泥上清液中EPS及其各组分含量与污泥滤饼含水率、SRF均有较高的相关性，对污泥的脱水性能有重要贡献。实验中确定的最佳污泥调理条件是CaO投加量为66.67 mg·（g DS）-1、PAFC投加量为33.33 mg·（g DS）-1和表面活性剂投加量为56.25 mg·（g DS）-1，污泥滤饼含水率和SRF分别降至69.41%、0.294×1013 m·kg-1。

Abstract

Dewatering performance of sludge modified by CaO and PAFC combined with surfactant is investigated in this study. Water content of dewatered sludge and specific resistance of filtration (SRF) are used to evaluate the sludge dewaterability

and the change of sludge dewaterability is explained by measuring variation of extracellular polymeric substance (EPS) content and Zeta potential in the conditioning process. The results show that adding surfactant can change EPS content in the filtrate

and reduce SRF and water content of dewatered sludge

and improve dewatering performance of sludge. The effect of CaO and PAFC combined with surfactant is better than individual surfactant. The addition of CaO and PAFC can both improve sludge dewaterability and contribute to reduce the addition of surfactant. The content of EPS and its components in sludge filtrate has a high correlation with the water content of dewatered sludge and SRF

and an important effect on the detwatering performance of sludge. The optimal conditions determined by experiment is that the addition amount of CaO

PAFC

surfactant is 66.67 mg·g-1

33.33 mg·g-1

56.25 mg·g-1

and the water content in dewatered sludge and SRF are 69.41%、0.294×1013 m·kg-1

respectively.

关键词

Keywords

references

Views

354

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Characteristics of dehydrated sludge based on chemical modification: low temperature hot-air drying

Research on the process path of sodium-based dry desulfurization ash combined with fly ash decalcification

Process parameters in the cooperative synthesis of polymorphic micro/nano calcium carbonate from power plant desulfurization gypsum and flue gas

Experimental study on performance of compact three-chamber RTO system for treating waste gas containing ethyl acetate

Experimental study on mass and morphological character during scrap tire pyrolysis

Related Author

LI Haiyan

LIU Huan

WANG Jiaxing

JIN Minghao

DENG Hongping

LU Geng

ZHANG Xiuju

YAO Hong

Related Institution

State Key Laboratory of Coal Combustion, School of Energy and Power Engineering, Huazhong University of Science and Technology

EU Institute for Clean and Renewable Energy, Huazhong University of Science and Technology,,, China

State Key Laboratory of Materials Low-Carbon Recycling, Beijing Building Materials Academy of Sciences Research Corporation

Beijing Tongda Refractory Technologies Corporation

Yangquan Jinyu Tongda High-Temperature Materials Corporation

⁰