Suspended fluidized bed desulfurization characteristics of humidified fly ashes from circulating fluidized bed at low temperature

WANG Qinhui; CAI Yi; CHENG Leming; XU Linjie; FANG Mengxiang

doi:10.3969/j.issn.0438-1157.2014.02.045

您当前的位置：

首页 >

文章列表页 >

Suspended fluidized bed desulfurization characteristics of humidified fly ashes from circulating fluidized bed at low temperature

更新时间：2025-12-10

- Suspended fluidized bed desulfurization characteristics of humidified fly ashes from circulating fluidized bed at low temperature
- CIESC Journal Issue 2, Pages: 684-691(2014)
- 作者机构：
  
  浙江大学能源清洁利用国家重点实验室,浙江,杭州,310027
- 作者简介：
- 基金信息：
- DOI：10.3969/j.issn.0438-1157.2014.02.045
  CLC： Q534.9
- Online First：05 February 2014，
  
  Published：05 February 2014
- 稿件说明：
移动端阅览
WANG Qinhui, CAI Yi, CHENG Leming, et al. Suspended fluidized bed desulfurization characteristics of humidified fly ashes from circulating fluidized bed at low temperature[J]. CIESC Journal, 2014, (2): 684-691.
DOI：

WANG Qinhui, CAI Yi, CHENG Leming, et al. Suspended fluidized bed desulfurization characteristics of humidified fly ashes from circulating fluidized bed at low temperature[J]. CIESC Journal, 2014, (2): 684-691. DOI： 10.3969/j.issn.0438-1157.2014.02.045.

摘要

以循环流化床锅炉飞灰作为实验对象，研究增湿活化飞灰在低温悬浮反应器中的脱硫特性。实验结果表明：增湿低温悬浮脱硫过程中，当水钙比能保证反应器中增湿灰的悬浮流化状态时，反应温度对钙利用率存在促进与抑制作用。水钙比为1时，钙利用率随反应温度的升高而增大；水钙比为3、5时，钙利用率随反应温度升高先升高后降低；水钙比为10时，钙利用率随反应温度的升高而降低；当水钙比为10，飞灰增湿低温悬浮脱硫可将循环流化床锅炉飞灰初始钙利用率由41%提高至60%左右，最佳反应温度在60～80℃之间。扫描电镜表明，飞灰增湿活化后，飞灰颗粒表面空隙增多、产生裂缝，有利于进一步在悬浮反应器中脱硫。

Abstract

Humidified activation of fly ashes from circulating fluidized bed (CFB) boilers was conducted. Samples of the fly ash were characterized by desulfurization in the suspended fluidized bed and scanning electron microscopy (SEM). The desulfurization of humidified fly ashes was conducted at low temperature. The results indicated that with increase of reaction temperature

the calcium utilization increased when water/CaO ratio was 1. The utilization increased continuously and then decreased with temperature when the ratio was 3 or 5. The rate decreased when the ratio was 10. It was shown that the calcium utilization of humidified fly ashes in a suspended fluidized bed could be increased from 41% to 60%. The optimal reaction temperature was between 60℃ and 80℃. The results from SEM showed that treatment of humidified activation promoted an increase in ash porosity

while the porosity contributed to further desulfurization in suspended fluidized beds.

关键词

Keywords

references

Views

349

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Effect of rapid water-cooling process on desulfurization performance of CFB bottom ash

Construction of transition metal-based nitrogen-doped carbon and their desulfurization performance

Solvent effect of titanium-silicate zeolite catalyzed epoxidation of α-olefins

Oxidation-ultrafiltration coupling process: advances and challenges in mitigating membrane fouling and degrading emerging pollutants

Degradation performance and mechanism of antibiotics in water by peracetic acid activated by Cu2O facets under sunlight

Related Author

LI Hao

CHEN Wufeng

WANG Chang'an

CHE Defu

JIN Changzhou

YIN Mengyang

WANG Haochen

SONG Jia

Related Institution

State Key Laboratory of Multiphase Flow in Power Engineering, Xi'an Jiaotong University

College of Resources and Environment, Henan Agricultural University

College of Chemistry and Chemical Engineering, China University of Petroleum

College of Chemistry, Cardiff University, Cardiff CF24 4HQ, United Kingdom

Department of Chemical Engineering, Norwegian University of Science and Technology, Trondheim

⁰