Experimental research and process simulation on biomass fast pyrolysis for production of bio-oil

WANG Chao; CHEN Guanyi; LAN Weijuan; MA Wenchao

doi:10.3969/j.issn.0438-1157.2014.02.044

您当前的位置：

首页 >

文章列表页 >

Experimental research and process simulation on biomass fast pyrolysis for production of bio-oil

更新时间：2025-12-10

- Experimental research and process simulation on biomass fast pyrolysis for production of bio-oil
- CIESC Journal Issue 2, Pages: 679-683(2014)
- 作者机构：
  
  1. 天津大学环境科学与工程学院,天津,300072
  2. 中国石化工程建设有限公司,北京,100101
- 作者简介：
- 基金信息：
- DOI：10.3969/j.issn.0438-1157.2014.02.044
  CLC： K6
- Online First：05 February 2014，
  
  Published：05 February 2014
- 稿件说明：
移动端阅览
WANG Chao, CHEN Guanyi, LAN Weijuan, et al. Experimental research and process simulation on biomass fast pyrolysis for production of bio-oil[J]. CIESC Journal, 2014, (2): 679-683.
DOI：

WANG Chao, CHEN Guanyi, LAN Weijuan, et al. Experimental research and process simulation on biomass fast pyrolysis for production of bio-oil[J]. CIESC Journal, 2014, (2): 679-683. DOI： 10.3969/j.issn.0438-1157.2014.02.044.

摘要

使用自主研发的流化床热解反应器对生物质热解制油进行实验研究，通过对不同实验温度450、500、525、550、580、610℃下得到的目标产物进行分析，得到了反应温度对生物油产率的影响规律。实验表明：550℃时，最大液体产率为42.5%（质量）；实验得到的不可冷凝气体的组分以CO、CO2、CH4和H2为主，气相产物产率约为37.7%（质量）。在实验基础上，利用Aspen Plus流程模拟软件，建立了生物质热解制油工艺模拟流程，模拟分析了热解温度对生物油产率的影响，结果表明该模型能准确模拟实际热解过程，具有较好的适用性和可靠性。

Abstract

The experimental research of biomass pyrolysis for production of bio-oil is performed with a fluidized bed reactor designed by ourselves. By analysis of desired products collected at different temperature 450

500

525

550

580

610℃

influence of reaction temperature on the yield of bio-oil is investigated in this paper. The results show that the highest yield of bio-oil is 42.5%(mass) received around 550℃

while gas yield is 37.7%(mass)

gas components are mainly CO

CO2

CH4

H2. On the basis of the experiment

using Aspen Plus software for process simulation a biomass fast pyrolysis model for production of bio-oil is set up

the effects of temperature on bio-oil yield is simulatedly analyzed. The results show that the pyrolysis process is simulated exactly

the model is proved applicable and reliable.

关键词

Keywords

references

Views

558

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Progress of molten salt-assisted thermochemical high-value conversion of biomass

Synergetic production of phenols and syngas from the catalytic pyrolysis of cellulose on activated carbon

Effect of bio-oil on properties of bio-oil starch adhesive

Revealing mechanisms of tar formation and char structural evolution during lignin pyrolysis from microscopic perspective

New universal corresponding state equation for correlation and extrapolation of saturated vapor-liquid density

Related Author

CAO Wenxuan

WU Boyang

LI Jun

LIU Tianji

ZENG Kuo

YANG Haiping

CHEN Hanping

Yinhai SU

Related Institution

School of Energy and Power Engineering, Huazhong University of Science and Technology

EU Institute for Clean and Renewable Energy, Huazhong University of Science and Technology

School of New Energy, Nanjing University of Science and Technology, Jiangyin

School of Energy and Power Engineering, Nanjing University of Science and Technology

Key Laboratory of Energy Thermal Conversion and Control of Ministry of Education, School of Energy and Environment, Southeast University

⁰