Characteristics of flow pattern for condensation heat transfer of R32 in horizontal small tube

YANG Yingying; LI Minxia; MA Yitai

doi:10.3969/j.issn.0438-1157.2014.02.011

您当前的位置：

首页 >

文章列表页 >

Characteristics of flow pattern for condensation heat transfer of R32 in horizontal small tube

更新时间：2025-12-10

- Characteristics of flow pattern for condensation heat transfer of R32 in horizontal small tube
- CIESC Journal Issue 2, Pages: 445-452(2014)
- 作者机构：
  
  天津大学热能工程系, 中低温热能高效利用教育部重点实验室,天津,300072
- 作者简介：
- 基金信息：
- DOI：10.3969/j.issn.0438-1157.2014.02.011
  CLC： K124
- Online First：05 February 2014，
  
  Published：05 February 2014
- 稿件说明：
移动端阅览
YANG Yingying, LI Minxia, MA Yitai. Characteristics of flow pattern for condensation heat transfer of R32 in horizontal small tube[J]. CIESC Journal, 2014, (2): 445-452.
DOI：

YANG Yingying, LI Minxia, MA Yitai. Characteristics of flow pattern for condensation heat transfer of R32 in horizontal small tube[J]. CIESC Journal, 2014, (2): 445-452. DOI： 10.3969/j.issn.0438-1157.2014.02.011.

摘要

采用可视化的方法，对流体R32在内径2 mm 的水平光滑圆管内冷凝换热的流型进行了观测实验，实验设定的流体饱和温度为40℃，质量流量分别为100、200、400 kg·m-2·s-1。观测到的主要流型为塞状流、弹状流、环波状流和环状流。通过实验观察，发现随着流量的增加环状流的流型区域增加，流型由环波状流转换成间歇流的干度推迟，其分界线为一条斜线，主要是由于随着流量的增大，气液表面剪切力增大促进了环波状流的形成。借鉴量纲1准则数提出间歇流与环波状流分界线公式。将实验值与其他5种流型模型进行了对比分析，发现只有与Yang-Shieh模型比较吻合。

Abstract

The flow patterns of R32 were observed for its condensation heat transfer in a smooth horizontal circular tube with inner diameter of 2 mm. The experiments were conducted with the method of visualization under mass fluxes of 100

200

400 kg·m-2·s-1 at the condensation temperature of 40℃. Plug

slug

annular-wavy and annular flow patterns were observed. The results show that with the increase of mass flux

the annular flow regime becomes large and corresponding vapor quality is smaller when the annular flow changes to intermittent flow. The transition line between the two patterns is a slash line. It is because the shear in the vapor-liquid phase interface increases with the mass flux

which promotes the conformation of the annular flow. With dimensionless numbers

a correlation is proposed for predicting the boundary of intermittent flow and annular wavy flow. Compared the results with other five flow pattern maps

Yang-Shieh model can predict the experimental results relatively well.

关键词

Keywords

references

Views

377

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Experimental investigation and correlation development of flow boiling heat transfer characteristics of R32-oil mixture inside tube

Characteristics of flow condensation heat transfer for R134a in pump-assisted heat pipe

Multi objective optimization of flow and heat transfer characteristics of modified manifold microchannel heat sink based on machine learning

Experimental study of heat transfer enhancement by pressure waves in cross flow tube bundles

Heat transfer characteristics of oblique droplet impact on liquid film

Related Author

Guang LI

Dawei ZHUANG

Liyi XIE

Guoliang DING

Liyu ZHENG

Chunxian LONG

Bo JIANG

SHAO Jie

Related Institution

Institute of Refrigeration and Cryogenics Engineering, Shanghai Jiao Tong University

Guangdong Meizhi Compressor Limited

Institute of Energy Engineering, Qingdao University

School of Mechanical and Power Engineering, Zhengzhou University

BK21 FOUR ERICA-ACE Center, Hanyang University

⁰