Axial backmixing of liquid phase in a trickle bed reactor for selective hydrogenation of phenylacetylene

HU Jiawei; HUANG Binjie; CHENG Zhenmin; ZHOU Zhiming

doi:10.3969/j.issn.0438-1157.2014.01.016

您当前的位置：

首页 >

文章列表页 >

Axial backmixing of liquid phase in a trickle bed reactor for selective hydrogenation of phenylacetylene

更新时间：2025-12-10

- Axial backmixing of liquid phase in a trickle bed reactor for selective hydrogenation of phenylacetylene
- CIESC Journal Issue 1, Pages: 123-130(2014)
- 作者机构：
  
  华东理工大学化学工程联合国家重点实验室,上海,200237
- 作者简介：
- 基金信息：
- DOI：10.3969/j.issn.0438-1157.2014.01.016
  CLC： Q03-3TQ241
- Online First：05 January 2014，
  
  Published：05 January 2014
- 稿件说明：
移动端阅览
HU Jiawei, HUANG Binjie, CHENG Zhenmin, et al. Axial backmixing of liquid phase in a trickle bed reactor for selective hydrogenation of phenylacetylene[J]. CIESC Journal, 2014, (1): 123-130.
DOI：

HU Jiawei, HUANG Binjie, CHENG Zhenmin, et al. Axial backmixing of liquid phase in a trickle bed reactor for selective hydrogenation of phenylacetylene[J]. CIESC Journal, 2014, (1): 123-130. DOI： 10.3969/j.issn.0438-1157.2014.01.016.

摘要

苯乙炔选择性加氢是从裂解汽油C8馏分中回收苯乙烯的关键反应，本文采用滴流床反应器对该反应体系的液相轴向返混行为进行了研究。首先利用脉冲示踪法测得了不同操作条件下的液相停留时间分布密度；然后基于固定床轴向扩散模型，通过有限元正交配置法和Levenberg-Marquardt非线性最小二乘法，计算得到了Péclet数和液相平均停留时间；最后考察了主要操作条件对液相轴向返混的影响。研究结果表明，增大液体流量、气体流量、温度以及压力均可减小液相返混，而增大颗粒粒径会使液相返混加剧。

Abstract

Recovery of styrene from the C8 fraction of pyrolysis gasoline

a byproduct of steam cracking of naphtha

has been recognized as a very promising approach to meet with increasing demand for styrene

and selective hydrogenation of phenylacetylene is the key reaction during the recovery process. The present study investigated the axial backmixing behaviors of liquid phase in a trickle bed reactor for selective hydrogenation of phenylacetylene. The liquid-phase residence time distribution under various experimental conditions was first measured by using a pulse tracer technique

and then Péclet number and average residence time of liquid phase were determined by the finite element orthogonal collocation method and the Levenberg-Marquardt nonlinear least-squares method. Finally

the effects of operation conditions on axial backmixing of liquid were studied. Liquid backmixing could be reduced by increasing liquid flow rate

gas flow rate

temperature and pressure

but would be exacerbated by increasing particle size.

关键词

Keywords

references

Views

599

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Influence of catalyst shape on methane steam reforming and simulation of industrial reactor

Flow and reaction performance of Taylor-vortex flow reactor

High-performance electrocatalytic semi-hydrogenation of acetylene to ethylene via MOF derived Cu/N-C catalyst

Effect of ammonia evaporation time on the reaction performance of hydrogenation of dimethyl oxalate to ethylene glycol over Cu/SiO2

Integrated production of 2-methyltetrahydrofuran through hydrogenation and dehydration of ethyl levulinate

Related Author

QIN Wen

YE Li

LI Linan

CHEN Dan

XIE Fei

DU Zifu

XIE Xiaomi

ZHANG Mimi

Related Institution

School of Energy and Power Engineering, University of Shanghai for Science and Technology

Shaanxi Key Laboratory of Chemical Reaction Engineering, School of Chemistry and Chemical Engineering, Yan’an University, Yan’an

National Key Laboratory of Surface-Interface Chemistry, School of Chemistry and Chemical Engineering, Xiamen University

Key Laboratory of Atmospheric Complex Pollution Control and Synergistic Carbon Reduction of Shanxi Province, School of Environmental Science and Engineering, Taiyuan University of Technology

School of Chemistry and Chemical Engineering, Guangxi University

⁰