Bubble breakup and distribution in asymmetric Y-bifurcating microchannels

CONG Zhenxia; ZHU Chunying; FU Taotao; MA Youguang

doi:10.3969/j.issn.0438-1157.2014.01.012

您当前的位置：

首页 >

文章列表页 >

Bubble breakup and distribution in asymmetric Y-bifurcating microchannels

更新时间：2025-12-10

- Bubble breakup and distribution in asymmetric Y-bifurcating microchannels
- CIESC Journal Issue 1, Pages: 93-99(2014)
- 作者机构：
  
  天津大学化工学院, 化学工程联合国家重点实验室,天津,300072
- 作者简介：
- 基金信息：
- DOI：10.3969/j.issn.0438-1157.2014.01.012
  CLC： Q021.4
- Online First：05 January 2014，
  
  Published：05 January 2014
- 稿件说明：
移动端阅览
CONG Zhenxia, ZHU Chunying, FU Taotao, et al. Bubble breakup and distribution in asymmetric Y-bifurcating microchannels[J]. CIESC Journal, 2014, (1): 93-99.
DOI：

CONG Zhenxia, ZHU Chunying, FU Taotao, et al. Bubble breakup and distribution in asymmetric Y-bifurcating microchannels[J]. CIESC Journal, 2014, (1): 93-99. DOI： 10.3969/j.issn.0438-1157.2014.01.012.

摘要

利用高速摄像仪对气泡在非对称Y型微通道分岔口的破裂行为和分配规律进行了实验研究。采用氮气（N2）作为分散相，含0.3%表面活性剂十二烷基硫酸钠（SDS）的蒸馏水-甘油（质量分数分别为20%、40%、50%）溶液为连续相。在分岔口处观察到了3种不同的气泡行为：无间隙的不对称破裂、有间隙的不对称破裂以及不破裂。考察了气泡破裂和不破裂行为之间的转变，并与文献进行了比较。考察了两相流率及物性对破裂气泡分配规律的影响。结果表明：破裂后两个子气泡的长度均随气相流量与气泡长度的增大而增大，随液相流量和黏度的增大而减小。随液相速度和黏度的增大，气泡破裂的不对称程度减弱。

Abstract

A high-speed camera was used to observe and record bubble breakup and distribution in bifurcating microchannels. Nitrogen and deionized water with 0.3% surfactant sodium dodecyl sulfate (SDS)-glycerol (20%

40%

50%) were used as dispersed and continuous phases

respectively. Three different flow patterns were observed at the divergence: asymmetric breaking with permanent obstruction

asymmetric breaking with gap and non-breaking regimes. The transition between breakup and non-breakup was studied and compared with existing reports. The effects of flow rates of both phases and physical properties of fluids on the distributions of breaking bubbles were investigated. Both breakup lengths increased with increasing flow rate of gas phase and bubble length

and decreased with increasing liquid viscosity and flow rate. As the flow rate and viscosity of liquid phase increased

the degree of asymmetrical breakup decreased.

关键词

Keywords

references

Views

555

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Deformation and breakup behavior of nanoparticle-stabilized bubbles in high-viscosity systems

Formation and flow characteristics of ordered bubble swarm in a step T-junction microchannel

Progress of self-organization behavior of bubbles and droplets in microchannels

Dynamics of droplet breakup with permanent tunnel in asymmetric microfluidic T-junction

Progress in breakup dynamics of droplets and bubbles in microchannels

Related Author

ZHAO He

FEI Yingjie

ZHU Chunying

FU Taotao

MA Youguang

SHENG Lin

CHANG Yu

DENG Jian

Related Institution

State Key Laboratory of Chemical Engineering, School of Chemical Engineering and Technology, Tianjin University

State Key Laboratory of Chemical Engineering, Department of Chemical Engineering, Tsinghua University

State Key Laboratory of Chemical Engineering, School of Chemical Engineering and Technology, Tianjin University

The 712.th Research Institute of China Shipbuilding Industry Corporation

School of Power Engineering, Chongqing University

⁰