Void fraction and pressure drop of gas-liquid two-phase flow accompanied with chemical absorption in microchannel

LI Chunfang; ZHU Chunying; FU Taotao; GAO Xiqun; MA Youguang; LIU Dongzhi

doi:10.3969/j.issn.0438-1157.2013.09.014

您当前的位置：

首页 >

文章列表页 >

Void fraction and pressure drop of gas-liquid two-phase flow accompanied with chemical absorption in microchannel

更新时间：2025-12-10

- Void fraction and pressure drop of gas-liquid two-phase flow accompanied with chemical absorption in microchannel
- CIESC Journal Issue 9, Pages: 3175-3181(2013)
- 作者机构：
  
  1. 天津大学化工学院, 化学工程联合国家重点实验室,天津,300072
  2. 辽阳石油化纤公司亿方公司,辽宁,辽阳,111003
- 作者简介：
- 基金信息：
- DOI：10.3969/j.issn.0438-1157.2013.09.014
  CLC： Q021.4
- Online First：05 September 2013，
  
  Published：05 September 2013
- 稿件说明：
移动端阅览
LI Chunfang, ZHU Chunying, FU Taotao, et al. Void fraction and pressure drop of gas-liquid two-phase flow accompanied with chemical absorption in microchannel[J]. CIESC Journal, 2013, (9): 3175-3181.
DOI：

LI Chunfang, ZHU Chunying, FU Taotao, et al. Void fraction and pressure drop of gas-liquid two-phase flow accompanied with chemical absorption in microchannel[J]. CIESC Journal, 2013, (9): 3175-3181. DOI： 10.3969/j.issn.0438-1157.2013.09.014.

摘要

微通道内气液两相流空隙率与压力降对微反应器的热质传递性能有显著影响

是微反应器的重要设计参数。采用高速摄像仪和压力测量系统分别对矩形微通道内单乙醇胺水溶液化学吸收CO2过程的空隙率和压力降进行了研究

考察了弹状流下气液两相流量与化学反应速率对空隙率及压力降的影响。结果表明:当液相流量一定时

微通道内空隙率和压力降均随着气相流量的增大而增大

空隙率随化学反应速率的增大而减小

压力降随化学反应速率的增大而增大;当气相流量一定时

随着液相流量和化学反应速率的上升

微通道内空隙率下降

而压力降上升。提出了微通道内伴有化学吸收的空隙率和压力降的半理论预测模型

模型平均误差分别为15.79%和11.12%

显示了良好的预测性能。

Abstract

Void fraction and pressure drop of gas-liquid two-phase flow in microchannel have remarkable influence on performance of mass and heat transfer

and also are important design parameters of microreactor.A high speed camera and a pressure measuring system were used to investigate void fraction and pressure drop of CO2 chemical absorption by monoethanolamine(MEA)aqueous solution.The effects of gas/liquid flow rate and chemical reaction rate were studied under Taylor flow.Experimental results showed that

for a given liquid phase flow rate

both void fraction and pressure drop increased with increasing gas phase flow rate

and void fraction decreased while the pressure drop increased with increasing chemical reaction rate.For a given gas flow rate

void fraction decreased while pressure drop increased with increasing liquid phase flow rate and chemical reaction rate.Two semi-theoretical models were proposed for predicting void fraction and pressure drop of gas-liquid two-phase flow accompanied with chemical absorption in microchannel

respectively.The average deviations of the models were 15.79% and 11.12% respectively for void fraction and pressure drop

showing good prediction.

关键词

Keywords

references

Views

238

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Mass transfer performance of CO2/N2 mixture absorption into monoethanolamine aqueous solution in microchannel

Gas-liquid mass transfer and intensification in 3D-rhombus microchannel

Study on boiling characteristics of liquid crystal elastomer surfaces with thermally adaptive wettability

Flow and clogging characteristics of oil-water droplet clusters in a dual-porous medium with both fractures and matrix

Effect of screen on multiscale bubble dynamics and mass transfer characteristics in loop reactor

Related Author

JIANG Shan

ZHU Chunying

ZHANG Fanbin

MA Youguang

CHEN Yiyu

ZHU Chunying

FU Taotao

MA Youguang

Related Institution

State Key Laboratory of Chemical Engineering, Collaborative Innovation Center of Chemical Science and Engineering(TianjinTianjin), School of Chemical Engineering and Technology, Tianjin University

State Key Laboratory of Chemical Engineering, School of Chemical Engineering and Technology, Tianjin University

School of Energy Science Engineering, Harbin Institute of Technology

Suzhou Research Institute, Harbin Institute of Technology

State Key Laboratory of Multiphase Flow in Power Engineer, Xi’an Jiaotong University

⁰