Influence of gravity on composition shift of zeotropic mixtures in vertical tube

ZHANG Jianyuan; ZHAO Li

doi:10.3969/j.issn.0438-1157.2013.07.012

您当前的位置：

首页 >

文章列表页 >

Influence of gravity on composition shift of zeotropic mixtures in vertical tube

更新时间：2025-12-10

- Influence of gravity on composition shift of zeotropic mixtures in vertical tube
- CIESC Journal Issue 7, Pages: 2394-2399(2013)
- 作者机构：
  
  天津大学机械工程学院, 中低温热能高效利用教育部重点实验室,天津,300072
- 作者简介：
- 基金信息：
- DOI：10.3969/j.issn.0438-1157.2013.07.012
  CLC： K114
- Online First：05 July 2013，
  
  Published：05 July 2013
- 稿件说明：
移动端阅览
ZHANG Jianyuan, ZHAO Li. Influence of gravity on composition shift of zeotropic mixtures in vertical tube[J]. CIESC Journal, 2013, (7): 2394-2399.
DOI：

ZHANG Jianyuan, ZHAO Li. Influence of gravity on composition shift of zeotropic mixtures in vertical tube[J]. CIESC Journal, 2013, (7): 2394-2399. DOI： 10.3969/j.issn.0438-1157.2013.07.012.

摘要

为探究重力对非共沸混合工质组分迁移的影响

在竖直管式色谱分析实验台上

以R290/R600(Z1、Z2、Z3

质量比分别为25%/75%、50%/50%、75%/25%)为工质

通过改变配比、温度和静置时间等变量进行了不同工况下的实验研究

对组分变化的规律做出了理论分析并提出了进一步的研究建议。实验发现:对于工质Z1、Z2、Z3

组分迁移度受混合物配比的影响很小;温度28.0℃的条件下

将静置的时间由3 h延长至24 h后

液相中丙烷递减率由"大—小—大"的趋势向"逐渐减小"变化

同时丙烷组分迁移度增大了70.13%;静置3 h的条件下

将温度由28.0℃升高至40.0℃后

丙烷的组分迁移度减小了61.25%。

Abstract

Zeotropic mixtures are considered to be popular alternatives to chlorofluorocarbons and hydrochlorofluorocarbons in refrigeration systems.It has been discovered that composition shift of multicomponent mixtures will have negative effect on system performance.In order to reveal the influence of gravity on composition shift

by varying mass fraction

temperature and standing time and using refrigerants Z1

Z2 and Z3 (R290/R600

25%/75%

50%/50% and 75%/25%

by mass fraction)as working fluids

an experimental study of composition shift was carried out in a vertical copper tube with internal diameter of 10 mm and length of 2 m.A chromatographic analysis test bench was used to make an analysis on the composition shift and bring forward research suggestions.The results show that composition shift is weakly dependent on the mass fractions of mixtures.At 28.0℃

prolonging the standing time from 3 h to 24 h

decline rate of propane in the liquid phase varies from "large—small—large" to "decrease gradually"

and composition shift of propane increases by 70.13%.In 3 h of standing time

composition shift of propane decreases 61.25% as the temperature increases from 28.0℃ to 40.0℃.

关键词

Keywords

references

Views

271

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Selection of ternary zeotropic mixtures for high-temperature heat pumps on multiparameter evaluation principles

Thermo-economic modelling and optimization of a zeotropic organic Rankine cycle with composition adjustment

Numerical simulation of R32 condensation heat transfer in horizontal circular microchannel

Low gas velocity of PEMFC aided by gravity water drainage

Influence of gravity on flow pattern modulation in vertical phase separation condenser tube

Related Author

ZHANG Xiaosong

ZHOU Fang

LIU Jian

LUO Xianglong

YANG Zhi

HUANG Renlong

LU Pei

CHEN Jianyong

Related Institution

Department of Energy and Environment, Southeast University

Changzhou Research Institute of Southeast University

Institute of Materials and Energy, Guangdong University of Technology

Key Laboratory for Thermal Science and Power Engineering of Ministry of Education, Department of Thermal Engineering, Tsinghua University

School of Energy and Power Engineering, Huazhong University of Science and Technology

⁰