Hydrogen production by steam reforming of methanol in reactor with comby micro-channel network

BU Yongdong; SHEN Yinqi; DU Xiaoze; YANG Lijun; YANG Yongping

doi:10.3969/j.issn.0438-1157.2013.06.037

您当前的位置：

首页 >

文章列表页 >

Hydrogen production by steam reforming of methanol in reactor with comby micro-channel network

更新时间：2025-12-10

- Hydrogen production by steam reforming of methanol in reactor with comby micro-channel network
- CIESC Journal Issue 6, Pages: 2177-2185(2013)
- 作者机构：
  
  华北电力大学能源动力与机械工程学院,北京,102206
- 作者简介：
- 基金信息：
- DOI：10.3969/j.issn.0438-1157.2013.06.037
  CLC： K124
- Online First：05 June 2013，
  
  Published：05 June 2013
- 稿件说明：
移动端阅览
BU Yongdong, SHEN Yinqi, DU Xiaoze, et al. Hydrogen production by steam reforming of methanol in reactor with comby micro-channel network[J]. CIESC Journal, 2013, (6): 2177-2185.
DOI：

BU Yongdong, SHEN Yinqi, DU Xiaoze, et al. Hydrogen production by steam reforming of methanol in reactor with comby micro-channel network[J]. CIESC Journal, 2013, (6): 2177-2185. DOI： 10.3969/j.issn.0438-1157.2013.06.037.

摘要

针对甲醇蒸汽的微通道重整催化反应过程

建立了三维稳态多组分传输反应模型;利用数值模拟分析

分别研究了平行阵列微通道和仿蜂巢分叉微通道在Zn_Cr/CeO2/ZrO2催化剂下的反应情况。通过双速率模型考察这两种流道中操作条件对甲醇蒸汽重整制氢输运规律的影响

发现这两种微通道反应器均可促进甲醇转化率和氢气产率的提高。与常规平行微通道的比较发现

仿蜂巢分叉微通道内反应气流动所需的泵功较小;在相同的加热面积下所能吸收的热量更大

而且更有利于反应器内温度的均匀分布

从而提高甲醇的转化率、减小出口CO的含量。研究结果表明

仿蜂巢分叉微通道结构具有较好的重整制氢综合性能

并可改善氢气产出的品质。

Abstract

For methanol steam reforming process in a micro-channel reactor

a steady-state multi-component three-dimension transport-reaction model was established.The catalytic process over Zn_Cr/CeO2/ZrO2 taken place in rectangular parallel micro-channels and in comby fractal micro-channel network was simulated numerically

and the effect of operating condition on reaction performance was investigated. The results indicated that the use of these micro-channels can make methanol conversion and hydrogen yield increase.Meanwhile

compared with rectangular parallel micro-channels

comby micro-channel network is of several advantages:much smaller requirement for pump power

adsorbing more heat under the same heating area and producing more uniform distribution of temperature.So

methanol conversion can be enhanced and CO reduced

which improve quality of hydrogen production.

关键词

Keywords

references

Views

419

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

PEMFC system incorporating a methanol electrolytic reformer

Controlled synthesis of Bi2MoO6/MoO3 composite fibers via in-situ hydrothermal method and their high-efficiency photocatalytic hydrogen production performance

Bimetallic Ni2P/Fe2P/Fe2O3@NF heterostructure catalyzes oxygen evolution reaction through coupled mechanism and promotes overall water splitting

Thermal management modeling and decoupling control design and optimization for PEM electrolytic hydrogen production system

Economic study on the in-situ CO2 enrichment process in FCC regenerators coupled with green electrolysis

Related Author

LI Qing

YE Qiang

YANG Xiaoguang

CAO Tieping

LI Yuejun

SUN Dawei

XIAO Lei

LI Jiarun

Related Institution

School of Mechanical and Power Engineering, Shanghai Jiao Tong University

College of Chemistry and Materials Engineering, Hainan Vocational University of Science and Technology

College of Chemistry, Baicheng Normal University

School of Chemistry and Chemical Engineering, Xi’an University of Architecture and Technology

Shaanxi Hanjiang Pharmaceutical Group Co., Ltd.

⁰